2023 HYUNDAI SANTA FE Complaints

Hello, I would like to point out a safety issue many new car manufacturers have actually implemented. I've witnessed this safety issue at two accident myself. Most automakers today lock your car doors automatically unnoticed by most drivers . The door locks are operated by electrical current only, if a accident destroys your car battery mechanically or by shorting out the battery in water, a person is unable to unlock their door. Thereby trapping them inside their car. In case your car is on fire or submerging in water you are trapped. There normally is a mechanical lock release if you are aware of how to use it, most people today if questioned have no idea how to do that. My son recently purchased a new Ford pickup that when the doors are locked the little plunger that you would pull up manually to release your door lock is recessed in the panel to the point you cannot grab hold of it. GMC truck owners are told to just pull the handle three times and the door will unlock, this is a true statement, if, the battery is connected. Research will show many people drowning and killed by automobile fire, When they have been perfectly physically capable of escaping the car If the door lock had not prevented them from escaping. It Is such a simple fix, just by redesigning the mechanical operation to only luck the door from the outside not the person inside. This auto lock future can not be changed on this car as i have requested. Please contact me with questions. Thank you for your help in saving lives! [XXX] My back ground has been 25 years with IBM in R&D also aircraft electrician, and industrial electrician INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

This is related to Complaint Number 11526621 filed June 13, '23. Today I experienced the same issue described in my previous complaint but under different circumstances. I was at an intersection of two 2-lane highways, one going east-west and the other going north-south, and was facing oncoming traffic as I waited for a gap in the oncoming traffic that would allow me to make the left turn. Once a gap appeared (perhaps 4 or 5 car lengths long), I pressed the accelerator to turn left but there was zero propulsion for about 2 seconds. I was simply stalled in the path of the oncoming traffic. At the end of the 2 second delay, as the vehicle transitioned from EV (electric) to internal combustion (gasoline) mode of propulsion, my vehicle GRADUALLY accelerated just enough to allow me to complete the turn; however, I came very close to being broadsided by the oncoming traffic. This is a dangerous fault of the 2023 Hyundai Santa Fe Hybrid vehicle and needs to be addressed asap! There is obviously something wrong with the EV/internal combustion synchronization/communication causing the momentary loss of power!

The issue I'm about to describe has occurred multiple times during the seven (7) months I've owned the vehicle - including again today. In all cases, I was attempting gradual acceleration to merge onto a highway or high-traffic street (e.g., when exiting a mall parking lot onto a busy city street). When I press the accelerator nothing happens - NO power whatsoever for at least two seconds! And on three of these occasions, I was almost broadsided by oncoming high-speed traffic! I've reported this issue to my dealership (both sales and service) and their response was that this is a known problem with the Hyundai hybrid models BUT that there is NO fix available nor, to the best of their knowledge, is there one in the process of being developed! As stated above, there is sometimes as much as a 2-second delay from when stepping on the accelerator (even when fully depressing) to when the vehicle slowly starts to accelerate. And there are no warning lights to indicate that there is a problem. I've observed that in all cases when this issue occurs, it does so when the power train is transitioning from the EV (electric) mode to the internal combustion mode of propulsion. This should NOT be a difficult issue for Hyundai to resolve and should be addressed with utmost urgency before someone is seriously injured or killed! NHTSA - please intervene by directing Hyundai to launch an immediate recall campaign to resolve this very dangerous issue, or offer to refund the affected owners' purchase price!

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the RPM would be elevated while the vehicle was idling. The failure recurred while the brake pedal was depressed. There were no warning lights illuminated. The failure recurred approximately 3-4 times within 30 days. The failure recurred approximately 15 times within 6 months of owning the vehicle. The contact took the vehicle to the dealer who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 12.

Driving on highway with cruise control selected to 80 mph. Left signal is applied to travel to left lane to pass a semi trailer. When the vehicle is half way into the left lane, the automatic system applies hard braking even though the semi trailer has not been detected as too close. Vehicle slowed to 74 to 75 mph before cruise control was turned off. Vehicle behavior is a total surprise to vehicles following since the braking is unexpected on a clear road. Repeated the symptoms several times. This braking does not occur if the vehicle ahead in the right hand lane is an automobile. This only occurs if it is a large vehicle such as a semi. Moving quickly or slowly to the passing lane affects the total time the braking is applied. The slower the movement, the longer the braking is applied. Repeated this behavior at 75 mph and 70 mph with similar results.

While driving under normal conditions with vehicle in Drive, transmission shifting into Neutral with no driver input or action and the engine remained running. Transmission indicator remained in Drive, and engine would rev, without forward propulsion. This occurred three times is close proximity, within 30 minute period. Each time, shutting down the vehicle, waiting approximately 5 minutes to restart, the vehicle would then shift into Drive normally and move under power. There were no warning messages or indicators prior to or during the three episodes. Dealer was unable to diagnosis any errors, even using GDS. If the vehicle had been moving at highway speed or on a more congested roadway, this could have posed a significant safety risk to the occupants and any nearby vehicles, as the driver may have not been able to safely pull off the roadway when the vehicle lost propulsion (shifted to neutral).

Car was purchased January 21st had 3000 mile on it when service was needed for these issues. On march 23rd as I started driving my car wouldn't go above 30 mph, when pressing on the gas pedal the car wouldn't accelerate, the rpm gage would go to 4 but engine wouldn't make noise car wouldn't speed up. I put the car in park and back in drive with no improvement. I pulled off at a gas station restarted the car and it was fine. During this time the auto on off button was orange on the cluster which I had never seen it that color before. Was looked at by the dealer but wasn't reproducible. Not sure the cause, but safety was in jeopardy due to not being able to go with speed of traffic. Also a couple weeks after purchase brakes began to squeal, took car to dealer on march 28th was told brake pads were sanded and cleaned, upon leaving dealer brakes continued to squeal, car is now back at dealer, supposedly needing front rotors and pads replaced. Dealer won't drive car until rotors replaced. Safety was in jeopardy cause of possible brake failure and resulting accident.

While traveling on state highway I heard a sudden, loud pop, similar to a gunshot sound. I looked everywhere and noticed that the sunroof was shattered. It is panoramic and was open. The rear, unopened section was completely shattered. Upon closer inspection there is a jagged hole about 1.5 inches in length in the sunroof. Although the rear part of the sunroof was intact, there were shards of glass scattered throughout the cabin.

4/27/23 - Panoramic sunroof exploded going over a bridge. Front glass panel only. No advance warning. Shade was closed and no glass entered cockpit. Local PD responded and saw no evidence of impact or criminal activity. Vehicle is at local dealership for warranty repairs.

2023 Hyundia Santa Fe bought brand new from the dealership. During the course of the last month and a half the vehicle has done things with unknown origin. The panic alarm will randomly go off when the vehicle is turned off, no one is in it, or even near it. By locking the vehicle with the remote, the alarm will tend to go off about 20-30 seconds after the vehicle is locked and will sometimes not stop until the vehicle is restarted. The transmission will shift very roughly almost to the point that it feels like you are driving a manual transmission vehicle. The transmission lags in gears between 60-70 miles per hour and you feel a very rough back and forth shifting with in the transmission. Next the emergency break would engaging and then not releasing or reengaging when parked on a hill, flat service or anywhere. The break light on the dash would light up, blink, then it would go off, making it unknown if the emergency break was acting engaged or not. The dealership I purchased it from did replace the EMS module along with breaks and rotors on the vehicle. The auto shut off or the idle shut off will also randomly work, and not work. it will cut on and off even if the button is pressed to shut it off or prevent it from coming on. Now the air condition, along with the heat and heated seats has started to not work, randomly cut on, will not cut off etc. While driving i have had the heated seats turn on, along with the heat and not go off, nothing would cut off until the vehicle was physically turned off and restarted. No codes have ever been displayed or found by the dealership.