2023 HYUNDAI SANTA FE Complaints

While driving on the interstate, while using cruise control, my vehicle braked and decelerated, uncontrollably. The collision alert alarm went off. I forced the vehicle to accelerate and it stopped the braking and the collision alarm ceased. I took the car to the dealer and they spend the day checking it over. They said they couldn’t get the same reaction I reported, but reset the cruise control. On my way back home on, again on the interstate, and with the cruise control activated, it again had the same failures. I called the dealer and told them. They asked if I had recently mounted any new equipment on the windshield. I said I had Velcro attached and EZPASS toll reader. They asked me to remove it, because might be interfering with the cruise sensor. After I removed it, and while continuing on the interstate, with cruise activated, it again repeated the same failures. The dealer arranged to have my vehicle towed to their shop.

It is not just this vehicle; it is ALL vehicles with adaptive cruise control and automatic emergency braking. When sensors get snow or debris on them, they shut the vehicles down without warning. I have had 3 times this winter when the roads were fine, cruise control set, and because another vehicle was kicking up road salt, the vehicle instantly shut off the cruise control without any warning to the driver, all 3 times I had traffic behind me at 55mph or on the highway at 70mph. The emergency braking is another issue, as it will bring the vehicle to almost a stop, and does not take into account if there are other vehicles behind it or not! How more people have not been killed because of these 2 systems is beyond me! BOTH of these systems and the vehicle they are on NEED to be recalled and either sensors removed or workarounds implemented, that at least give the driver some advanced notice before the cruise control is turned off or before a vehicle decides to hard-brake itself!

The front rotors need machining every 10,000 to 15,000 miles. The rotors experience exceeding distortion due heating by the brake pads. When brakes are applied, there are large vibrations in the front suspension which inhibits braking. This is especially true when braking on wet pavement where stopping distances become unsafe.

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while operating the vehicle, the horn was inoperable and inaudible when pressed. The cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The failure mileage was approximately 31,000.

Today, i received an extended warranty for my horn. There is a known issue with water getting into the horn and causing them to fail. Upon researching this, people have reported having their horns changed several times. This is a safety matter that an extended warranty is not fixing. Please enforce a recall so that this matter may be properly resolved. Canada has already issued a recall, I hope we can do the same. Thank you.

During on driving, engine stopped 3 or 4times since Jan/2025 Last time engine stopped yesterday around 6:30pm on 3/30/2026 at [XXX] between [XXX] and [XXX] in Los Angeles INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On March 4, 2026, at approximately 7:30 AM EST, while driving my 2023 Hyundai Santa Fe Limited on [XXX] , the vehicle experienced a sudden loss of propulsion while traveling at approximately 70 mph (posted speed limit). The vehicle would not accelerate or maintain speed and would not move forward when placed in drive, indicating a failure within the powertrain/transmission system. The vehicle is currently located at a Hyundai dealership and is available for inspection upon request. This incident created a significant safety risk, as I was traveling at highway speed in active traffic when the vehicle unexpectedly lost the ability to move under its own power. This placed me at risk of being rear-ended and made it difficult to safely maneuver out of traffic. The vehicle was inspected by a Hyundai dealership. Diagnostic trouble code P284001 (Shift Fork “D” Position) was identified, and I was informed the failure is transmission-related. The condition was reproduced by placing the vehicle in drive, at which point the vehicle would not move. The vehicle has been inspected by the dealership. The manufacturer has been notified but has not physically inspected the vehicle. No police or insurance inspection was involved. There were no warning lights, messages, or prior symptoms before the failure. The issue occurred suddenly without any indication of a problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driving on sunny day, the fixed roof glass located between the windshield and sunroof exploded across the entire width of the glass insert with a very distracting noise.

I have been fighting this issue now for 2 years, vibration while driving interstate speeds, especially right rear seat. I have had tires replaced twice trying to fix balance issue only to find out that one rim will not road force balance correctly, even with tire matched it only reduced road force balance to 20lbs (30lbs with out match). I have had it at discount tire and Gettel Hyundai of Lakewood ranch, FL several times. Hyundai sent a senior tech to look at tires, did not speak to me to get explanation of my concern, did a balance, got same numbers and said was good to go. My other 3 rims have a max road force of 12lbs without even being matched. This causes vibrations when driving, extra wear and force on the tire and is a safety concern. This rim is the issue and Hyundai refuses to fix it.

Driving to work and a loud noise (pop) was heard and then I realized the sunroof had basically exploded. Glass was all over the car and all over myself. I immediately got off the road and turned on my hazard lights to assess the situation. This could have caused an accident had I not remained calm. Contacted dealership this morning. Waiting to hear back. No prior warning to this happening.