2023 HYUNDAI SANTA FE Complaints

One two separate occasions while driving the car has lost the ability to accelerate. There is no acceleration power even when completely flooring the gas pedal. The dash displays a red circle warming that states "Check Hybrid system. Stop Safely". I have had to coast to the side of the road and then the car shuts off. It has taken several minutes before it can start again, and then displays a warning "Park with engine On to charge battery" before being able to shift the car into drive. I immediately took the vehicle to the dealership at which I had purchased the car. They have run a diagnostic on it and did not find any error codes stored in the computer. I picked up the vehicle from them and immediately upon pulling out of their lot it happened again. After losing power, coasting to the side of the road, and waiting for the engine to be able to restart I took it immediately back to the dealership. They have had my car for 5 weeks and cannot diagnose the problem or offer any recommendations for repairs.

Both horns on my 2023 Hyundai Santa FE have failed 3 times. The first set was covered under warranty (3/24), the second set cost $499.64 (3/25). Now both horns are nonfunctional after just being replaced this Spring. After reviewing many complaints on the Hyundai community form, it is very obvious there is a major issue with their horns ( and not just the Santa Fe model). Twice this week I was in need of my horn to alert other drivers but instead had to make quick maneuvers to avoid an incident. My vehicle currently cannot pass a state inspection.

The vehicle will not accelerate and comes to a complete stop while driving. Within days, it displayed ‘Check Hybrid System. Stop safely’ and lost propulsion while driving.

The horn has broken 4 times. I was told that it is a design defect in the car and there is no permanent fix. Water gets in to the horn when it rains and because of the location of the horn it would have to be moved to fix it. Hyundai is aware of this safety issue and has not issued a recall because there is no permanent fix. They are supposed to be buying back my car but are dragging their feet. I'm sure this is an issue in more than just my car and it's very unsafe for the horn to just stop working.

The vehicle cannot pick up speed, and it is displaying the DTC- P1C2D03. This is similar to the issues that led to "Safety Recall 236 to repair a condition involving the 8-Speed Dual-Clutch Transmission (DCT) system" in earlier model years (till 2022) for certain Hyundai and Kia vehicles. NHTSA should issue a recall for 2023 model years also as Hyundai has not addressed this issue to the fullest extent in 2023 model years.

On a clear road a sencor comes on detect comes on says detection collision. The breaks come on when you are traveling on interstate or two lane roads. When you are traveling 75 mph and breaks come on all of a sudden on the highway. We are lucky we never got hit in the back of the car going that fast. We will stop 75 to 35 mph in 10 seconds.

At stop sign and car with auto start stop on and at the time of releasing the brake, car was not able to start engine. Car had to be shifted to parking position to start engine.

Component/System: Automatic Emergency Braking / Forward Collision-Avoidance (AEB/FCA) system and/or Electronic Parking Brake (EPB). The vehicle is available for inspection upon request. What happened: While driving my 2023 Hyundai Santa Fe (VIN: XXX) at highway speeds, the vehicle suddenly and aggressively applied the emergency braking system on two separate occasions within the same day (approximately 45–60 minutes apart). In both instances, the red emergency braking warning lights illuminated on the dashboard, and a warning sound activated. There were no vehicles, obstacles, or hazards in front of me either time. The braking was forceful and abrupt, causing rapid deceleration at highway speed. Both events occurred under normal, clear driving conditions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Safety risk: My safety and the safety of other drivers were put at significant risk. Sudden unintended braking at highway speeds can easily lead to a rear-end collision since the deceleration was not caused by driver input and gave no warning. Reproduction / dealer confirmation: The dealer has not been able to reproduce the issue, and no diagnostic trouble codes have been found so far. The vehicle is currently at the dealership for inspection. Inspection: The vehicle has been inspected by the Hyundai dealership, but the cause has not been identified. No manufacturer field engineer, police, or insurance inspection has taken place yet. Warning lamps / prior symptoms: During the failures, the red emergency braking indicator and audible warning activated immediately when the brakes engaged. There were no warning lights or symptoms prior to either event. Assessment: Cause UNKNOWN. The problem appears to be an intermittent malfunction of the Automatic Emergency Braking system, forward collision sensors, or related braking components. No diagnostic codes were stored. This is a serious safety issue that occurred twice within one hour and could easily result in a collision.

While operating the vehicle, the cruise control turns off without any warning. The warning messages that come up only after the cruise control is turned off by the vehicle state "Smart cruise conditions not met" and "forward safety system disabled. Radar blocked". This disables the vehicle from utilizing cruise control in any manner. This happened on the highway with the cruise set at 72 mph, with a semi truck right behind my vehicle in moderate traffic! The semi slammed brakes on and after initial shock, I was able to accelerate the vehicle somewhat to avoid a collision. The dealership claims that "ALL" new vehicles do this when operated in wintery weather, snow, or mud kicked up from the road, or when sensors get iced over. They claim that there is NO reprogramming that can be done to fix this HUGE safety issue. I have NEVER heard of this or experienced this in any other vehicle other than this Hyundai Santa Fe! As a disabled veteran, this honestly scared the hell out of me and makes me very leery to operate the vehicle in the wintertime time and I am the primary driver for the family! At the time of the incident, it was not snowing, the temperature was approximately 36 degrees, and the roadways were clear of snow or ice! The only thing that could be noted was that the roadway was wet, and after stopping, there was sand or salt film in the front of the vehicle. As a disabled veteran with a lower back injury and radicular pain down both legs, I rely on a vehicle's cruise control when driving more than short distances, in order to not cause lower back or leg pain while driving! This issue with the cruise control stopping operation and not allowing the cruise to be restarted is both a HUGE safety issue for both the operator and all vehicles around/near the vehicle on/at highway speeds, and a violation of the ADA (Americans with Disabilities Act). With no way to reprogram or reset this awful feature, the Hyundai Santa Fe is unsafe for disabled individuals.

The vehicle front brake disks are not compatible for this vehicle. The action of braking causes heating of the disks. The disks warp due to the heat. The result is when braking at highway speeds, the entire front end vibrates excessively. This is unsafe in wet or snowy conditions as this greatly decreases the braking efficiency. The first time this was observed the vehicle had 22,000 miles and the dealership machined the rotors. The second time it happened at vehicle mileage of 32,000. Once again the rotors were 'machined' by the dealership. The action of braking at highway speeds and the resulting front end vibrations is a troublesome event. If this occurs a third time, I will try to find and install non-Hyundai disks.