2003 HYUNDAI SONATA Complaints

THE INTERIOR DOOR HANDLES OF MY 2003 HYUNDAI SONATA WENT UNDER A RECALL IN JULY 2009 BECAUSE THE CHROME PLATING WAS SPLITTING OPEN AND CUTTING PEOPLE. THREE DOOR HANDLES WERE REPLACED AND ONE WAS REWRAPPED TO FIX THE PROBLEM. IN SEPTEMBER 2013 THE SAME ISSUE AROSE WHEN MY WIFE AND BROTHER-IN-LAW CUT THEIR HANDS ON THE DOOR HANDLES, WHOSE CHROME PLATING HAS AGAIN BEGUN TO SPLIT. HYUNDAI HAS SAID THAT NO REPAIRS WILL BE MADE, SINCE THE HANDLES WERE TREATED AND THE 2009 RECALL HAS FINISHED. *TR

TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE REAR OF THE VEHICLE BEGAN SWAYING ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THE MECHANIC STATED THAT BOTH REAR STRUTS WOULD HAVE TO BE REPLACED. WHILE THE REPAIR WAS BEING PERFORMED THE REAR DRIVER'S SIDE UPPER CONTROL ARM FRACTURED. THE MECHANIC STATED THAT THE REAR UPPER CONTROL ARM AND FRAME WERE SEVERALLY CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. UPDATED 1/6/14*CN

I WAS INFORMED THIS MODEL HAS A SAFETY VALVE IN THE GAS FILLER NECK THAT WILL PREVENT THE GAS FROM LEAKING OUT SHOULD THE VEHICLE OVERTURN. MY VALVE MUST BE STUCK IN THE PARTIALLY OPEN POSITION SINCE I CAN ONLY FILL THE GAS TANK EVERY ONE-THIRD OF A GALLON BEFORE THE GAS DISPENSER SHUTS OFF. THEN I HAVE TO WAIT 10 SECONDS FOR IT TO SEEP INTO THE TANK BEFORE I CAN CONTINUE TO PUMP. FILLING MY 17 GAL TANK TAKES ABOUT 10-12 MINUTES WITH MOST OF THE TIME JUST WAITING FOR THE GAS TO SEEP INTO THE TANK. HYUNDAI WANTS OVER $600 TO REPAIR. UNACCEPTABLE SINCE IT APPEARS TO BE A DESIGN FLAW. *TR

REAR ENDED THE VEHICLE IN FRONT AT A STOP LIGHT. THE AIRBAGS NEVER DEPLOYED. NOW THE AIRBAG LIGHT IS ON IN THE VEHICLE. REPAIRS ARE $1349.00 REPLACE THE WIRE HARNESS. I NOTICED THIS HAS HAPPENED REPEATEDLY WITH THESE VEHICLES, WHY HAS NOTHING BEEN DONE. THIS IS A SAFETY HAZARD, BUT THE CHROME WEARS OFF THE DOOR HANDLE AND A RECALL IS ISSUED. SOMETHING IS ROTTEN HERE. *TR

LIKE MANY OTHER COMPLAINANTS, FOR THE PAST MONTH, I HAVE EXPERIENCED PROBLEMS FILLING UP MY GAS TANK. AFTER ONLY 1 GALLON OR LESS, THE PUMP AUTOMATICALLY SHUTS OFF AS IF THE TANK IS FULL. IT HAS TAKEN ME APPROXIMATELY 10 MINUTES JUST TO PUT 1/4 TANK OF GAS IN MY VEHICLE. WHEN THIS FIRST HAPPENED, GAS OVERFLOWED AND SPILLED ON MY SHOES, MY CAR, AND THE GROUND. THINKING THERE WAS A PROBLEM WITH THE GAS PUMP, I WENT TO A DIFFERENT GAS STATION AND HAD THE SAME PROBLEM. IN VIEWING FORUMS THROUGHOUT THE INTERNET, THIS APPEARS TO BE A PROBLEM THAT'S BEEN ONGOING FOR SEVERAL YEARS NOW FOR THIS CAR MODEL. IT IS A SAFETY HAZARD DUE TO THE POTENTIAL FOR GAS TO OVERFLOW ONTO A PERSON AND THE OUTSIDE OF THE VEHICLE, WHICH COULD LEAD TO A FIRE UNDER CERTAIN CIRCUMSTANCES. *TR

THE CHROME ON THE INTERIOR DOOR HANDLE OF DRIVER SIDE EXHIBITED A CRACK AND SEPARATED. MY WIFE CUT HER FINGER ON THE CRACKED CHROME PLATING. I CONTACTED HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151 AND WAS TOLD THAT MY VEHICLE WAS NOT INCLUDED IN THE DOOR HANDLE RECALL (I.E., NHTSA CAMPAIGN ID NUMBER: 09V171000). I DON'T UNDERSTAND HOW ONE VEHICLE CAN BE RECALLED WHILE OTHERS OF THE SAME YEAR AND MODEL ARE NOT. *TR

TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, HE HEARD A LOUD, ABNORMAL NOISE. THE CONTACT PULLED OVER AND INSPECTED THE VEHICLE WHEN HE NOTICED THAT THE SUB FRAME WAS FRACTURED. THE VEHICLE WAS LATER TOWED TO AN INDEPENDENT MECHANIC WHERE THEY CONFIRMED THAT THE FRONT SUB FRAME WAS FRACTURED AND ALSO ADVISED THAT IT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 160,000.

VEHICLE HAD BEEN RECALLED IN 2009 (PE08071) DUE TO DEFECTIVE CHROME ON DOOR HANDLES. THIS VEHICLE HAD BEEN TAKEN TO DEALERSHIP, CHROME WAS REPAIRED AS IT HAD CAUSED A SMALL LACERATION. CHROME IS AGAIN DEFECTIVE, CAUSED LACERATION ON HAND AGAIN TODAY WHEN ATTEMPTED TO OPEN DOOR. THIS OCCURRED ON THE PASSENGER SIDE DOOR WHICH IS VERY RARELY USED. CHROME IS ALSO PEELING OFF OF EMERGENCY BRAKE HANDLE, RISKING FURTHER LACERATION. CONTACTED DEALERSHIP (GO HYUNDAI - 104TH & FEDERAL, WESTMINSTER, CO), DEALERSHIP SAID THIS IS NO LONGER COVERED AS THEY DO NOT WARRANTY THE WORK DONE AS PART OF A RECALL. IN ADDITION, CAR IS TOO OLD FOR IT TO BE COVERED UNDER WARRANTY. CAR DOES CONTINUE TO BE COVERED UNDER WARRANTY FOR POWERTRAIN ONLY. I HAVE NEVER EXPERIENCED THIS TYPE OF PROBLEM ON ANY MODEL OF CAR REGARDLESS OF AGE. THIS APPEARS TO BE UNIQUE TO HYUNDAI. *JS

I TOOK MY CAR IN TO HAVE A FAULTY DOOR HANDLE REPLACED WHICH I CUT MY HAND ON. IT HAD ALREADY BEEN REPLACED ONCE DURING A RECALL. OBVIOUSLY THE SAME FAULTY PART WAS PUT ON AGAIN. I WAS ADVISED THAT I WOULD HAVE TO PAY $125.00 FOR A NEW HANDLE BECAUSE THEY ONLY PERFORM A RECALL ONCE. I THOUGHT THAT RECALL PARTS WERE REPLACED WITH DIFFERENT PARTS THAT ARE NOT FAULTY AND THE PARTS WERE GUARANTEED. I SHOULD NOT HAVE TO PAY FOR THIS SERVICE DUE TO ANOTHER FAULTY HANDLE THAT THEY REPLACED. I NEVER EXPECT TO OPEN MY CAR DOOR AND CUT MY HAND NOR SHOULD I HAVE TO WRAP MY DOOR HANDLE AS THEY SUGGESTED. I AM SO UPSET OVER THIS AND WILL NEVER PURCHASE ANOTHER HYUNDAI AND EVEN HAVE MY CAR SERVICED THERE AGAIN. ALL I AM ASKING IS FOR HYUNDAI TO TAKE RESPONSIBILITY AND REPLACE THIS HANDLE WITH ONE THAT WILL NOT CHIP. *JS

MY BACKUP LIGHTS, CORNERING LIGHTS, AND BRAKE LIGHTS ALL WENT OUT ON BOTH SIDES OF THE REAR OF MY CAR AT THE SAME TIME. THE FUSES ARE FINE AND THE BULBS ARE FINE. NOW I DO NOT HAVE ANY WORKING LIGHTS ON THE BACK OF MY CAR. *JS