2003 HYUNDAI SONATA Complaints

The contact owns a 2003 Hyundai Sonata. The contact stated that while the vehicle was at Valvoline for a service appointment, the contact was made aware of NHTSA Campaign Number: 09V124000 (Suspension). The vehicle was taken to the dealer, who informed the contact that the subframe assembly and additional unknown parts were not included in the recall repair. In addition, the contact was informed that the recall could not be performed because other repairs were needed prior to the recall repair. The vehicle was not repaired. The contact stated that the vehicle was unsafe to drive. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the repair was not covered under the recall. The failure mileage was approximately 170,000.

The contact owns a 2003 Hyundai Sonata. The contact stated that upon taking the vehicle to an independent mechanic, the mechanic discovered severe corrosion on the suspension. Upon investigation, the contact discovered NHTSA Campaign Number: 09V124000 (Suspension). The vehicle was taken to a dealer, and the contact was informed that due to the severe corrosion, the recall repair could not be performed. The mechanic at the dealer described the vehicle as being unsafe to drive. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 58,000

NHTSA Campaign ID Number: 09V124000 NHTSA Action Number: EA08016 Recall calls for repair or replacement of front sub-frame, due to corrosion. Local dealer responded, “ . . . we will not be able to perform recall”. I was told the corrosion was too far gone to repair. They refuse to replace the defective part.

The contact owns a 2003 Hyundai Sonata. The contact stated that while the vehicle was being serviced by an independent mechanic, the mechanic informed the contact that the front subframe was severely corroded. The mechanic determined that the failure was related to a recall. The vehicle was taken to the dealer, where the contact was informed that the subframe needed to be replaced; however, the repair could not be covered under NHTSA Campaign Number: 09V124000 (Suspension) because the parts had been discontinued. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was unknown. Parts distribution disconnect.

The contact owns a 2003 Hyundai Sonata. The contact stated that while self-inspecting the vehicle, he noticed that the subframe was extremely rusted. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 69,425. The contact stated that no assistance has been offered from the dealership from which the vehicle was purchased from.

Airbag light came on and stays on. Pulled a code that pointed to the wiring in the passenger seat. Moved wiring around and made sure connectors were properly plugged and the light went away for maybe a week. Light is back on again. Removed seat bolts to gain better access, used tubing and electrical tape to straighten any kinked wiring I could find underneath passenger front seat, disconnected and reconnected connections. Airbag light blinked once and still remains on with the code still pointing to the passenger seat wiring. Apparently this issue has been reported many times in online forums with no meaningful response from the company though this clearly affects proper airbag deployment.

TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, WHEN THE VEHICLE LOSS MOTIVE POWER AND STALLED. THE CONTACT PUSHED THE VEHICLE TO THE SIDE OF THE ROADWAY. THE CONTACT HAD THE VEHICLE TOWED TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT CRANKSHAFT POSITION SENSOR AND THE CRANKSHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,922. THE VIN WAS NOT AVAILABLE.*DT*JB

YOU CAN NOT FILL GAS TANK PASS HALF WITH OUT THE SMELL FILLING THE CAR .THE BACK SUSPENSION WHEN YOU GO OVER 40 TALES FROM SIDE TO SIDE .THE CAR WAS ON THE HIGHWAY .

TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED BY AN INDEPENDENT MECHANIC, SHE WAS INFORMED THERE WAS CORROSION TO THE VEHICLE'S SUBFRAME. THE CONTACT WAS ALSO INFORMED THAT THE FRONT PASSENGER'S SIDE SWAY BAR LINKAGE AND BOTH FRONT WHEEL BEARINGS NEEDED TO BE REPLACED. A DEALER WAS NOT NOTIFIED OF FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED NOR REPAIRED AS OF YET. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND A COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 184,077.

AIRBAG LIGHT IS ON BUT THEY HAVE NOT DEPLOYED & NO APPARENT DAMAGE TO THE AIRBAG SYSTEM, WIRING, ETC. WILL NOT PASS INSPECTION WITH THE ABS LIGHT ON, AS YOU WELL KNOW.