2010 HYUNDAI SONATA Complaints

Subject: Non-Collision Engine Compartment Fire - 2010 Hyundai Sonata (VIN: [XXX] ) ?"On dec 19 2025, my 2010 Hyundai Sonata suffered a sudden, non-collision fire that originated in the engine compartment. While there are currently no 'open' recalls on this VIN, I am formally reporting this incident as it matches the failure patterns documented in NHTSA Defect Petition DP18-003 regarding non-crash fires in Hyundai/Kia vehicles. ?Preliminary inspection of the damage shows characteristic signs of a manufacturer defect, specifically potentially related to a connecting rod bearing failure leading to an engine block puncture and oil ignition, or an electrical short in the ABS module—both of which have been subjects of major Hyundai fire investigations and class-action settlements (e.g., Engine II settlement) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

External Handles made of plastic continue to break and do not allow access to open car doors

I have had 3 door handles fall off in the last couple months I think this is safety concern i do not see any recalls.I do see that there is a lot of people complaining about this matter door handles should not be fallen off

Car has had check engine light on for 3 + years. Have taken it to several mechanics including a Hyundai dealership and none of them can figure out what is wrong. Have replaced water pump, belts x2 in a year (same belt) and thermostat x 3 again (all within 2 years). Dash fuel gage and Dash heating/cooling gage are completely erratic. Cruise control does not work. Due to chronic check engine light and mechanics unable to pin point the problem, car has become hazardous to drive. With that in mind, today (9/10/2025) while exiting the high way, car stalled and behaved like it was in neutral. Steering wheel also locked up at this time. Luckily was able to stop. Had to restart car and then it occurred again while driving on a side street at 35mph. The codes that are still popping up are ones that I have spent thousands trying to fix and find the root cause of the problem. What could the issue be if no mechanic can seem to diagnose and fix the issue?

While driving 60–70 mph on [XXX] just north of Sylmar, I suddenly heard a loud, deep “pop” from the lower part of the car. Within seconds, the engine began steaming heavily and leaking oil everywhere. I immediately turned on my hazard lights and began maneuvering toward the right shoulder, crossing multiple lanes with semis and fast-moving traffic approaching behind me. I felt unsafe and feared the car could catch fire or explode, especially with smoke and oil present. After safely exiting the vehicle, a mechanic later told me the rod bearing blew and punched a hole through the bottom of the engine block, calling it a total engine failure. He said it would require a full replacement and matched known issues with this model. There was no warning before the failure. I’m having it inspected at Hyundai of Downtown Los Angeles on July 28. I believe this event posed a serious safety hazard to me and others on the road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2010 Hyundai Sonata. The contact stated that upon attempting to turn the ignition key in the ignition switch to start the vehicle, the ignition switch failed to turn, and the steering wheel locked. The vehicle was towed to an independent mechanic, where the ignition switch was replaced; however, the vehicle failed to start. The mechanic determined that an unknown part needed to be replaced. The mechanic contacted the manufacturer for parts and was informed that the unknown part had been discontinued. The vehicle was not repaired. The failure mileage was unknown.

The contact owns a 2010 Hyundai Sonata. The contact stated while driving at various speeds, the steering wheel was constantly pulling to the right. The contact had to steer to the left to keep the vehicle centered. The failure persisted even after wheel adjustments had been made. The vehicle was taken to an independent mechanic where it was diagnosed and determined that an alignment was needed. The wheels were aligned. The manufacturer had been made aware of the failure. The failure mileage was 70,000.

The plastic housing of the brake lights have turned black. I'm on my second set that I got at wrecking yard. The plastic doesn't hold up to the heat of the tail/brake light. I saw other cars like mine with same problem at the wrecking yard. And my ground wire to my radiator fan burned out as well during COVID. I think Hyundai used cheap plastic that can't hold up to the heat. My dash cracked really bad as well. All over. I saw the same cracked dashes of other car in wrecking yards. They know they had a plastic defect and they changed body styles the next year. My door handles brake off in my hands and the a/c vent broke twice. They have hazzard car because all of this happened early when I purchased the car. And my car has Hyundai and Kia parts old body style 2010 bought end of 2009. Theta 2 engine. All of the recalls but they leave my car out. And that stop brake switch light has broken so many times. Replaced free only 1 time by dealership. Other times I had to pay for. Cheap plastic. If I need repair by dealership , I have to leave car on their lot for 6weeks for them to look at. Not appointment. Leave my car on lot until it's my cars turn. And my car just quit running once while driving in my apartment complex. It also quit running driving down the highway.. everything shutting off and lights turned on dash. The battery light was on first, then the check engine , abs, and all lights coming on. I tried to turn on my hazards but everything was failing. I was lucky I wasn't hit by other highway traffic. My headlights went off or really dim. I was allowed to drive really slow to a roach hotel just there on interstate. I was told it was my alternator. But I think it was something else that caused failure. I did have my car professionally washed, that day. (Hardly do that). And the week before it was at Hyundai shop for retinting of windows which my battery was dead in their dusty lot when pickup. That brake light switch lamp stopper was broken and laying in floor l

I purchased a 2010 Hyundai Sonata in February 2022 from the original owner. In July of this year, my engine failed due to the oil consumption defect found in many of Hyundai's engines produced at the Alabama factory. My oil and check engine light came on before it was time for my following oil change, despite making on-time synthetic oil changes during ownership. The vehicle hesitated and jerked on my commute to work, potentially causing harm to myself and other motorists. I went to take my vehicle to the mechanic on my lunch break. The car failed to turn over and has been inoperable ever since. I need my engine replaced at no charge. It's unconscionable that corporate would turn me away because the engine has 146k miles, which is nowhere near the industry standard 200k. Hyundai has inspected the vehicle and confirmed that an engine replacement is needed.

I have several recalls on my vehicle and the dealership only scrub and they did not replace the crossmember and other parts. I need help to see if this is OK