2017 HYUNDAI SONATA Complaints

The vehicle suffered a sudden, catastrophic internal mechanical engine failure out of nowhere without any warning lights or previous symptoms. An inspection of the engine cylinder revealed a physical hole blown through the top of the Cylinder 2 piston, causing immediate and complete loss of engine compression. This sudden structural failure caused the vehicle to completely lose all propulsion and stall unexpectedly while in operation, creating an immediate, severe safety hazard on the road.This vehicle features Hyundai's 2.4L Theta II Gasoline Direct Injection (GDI) engine, a family with a well-documented history of manufacturing defects, severe oil consumption, and catastrophic internal structural failures. Because this failure occurred instantly and without a progressive warning, it put occupants at risk of a severe rear-end collision or stranding in an unsafe traffic pattern. I am filing this safety report because the catastrophic destruction of the internal engine components presents a persistent and dangerous hazard to public safety.

The contact owns a 2017 Hyundai Sonata. The contact stated that the vehicle experienced excessive oil consumption with an abnormal burning odor. The vehicle was taken to a dealer, and an oil consumption test was performed. The contact was informed that the vehicle passed the inspection. While driving later, the vehicle stalled and was taken back to the dealer, where it was determined that the vehicle was consuming an excessive amount of engine oil, and several DTC including the Knock Sensor Detection System (KSDS) were found. The contact stated that while driving or reversing at various speeds, the vehicle shuddered, made abnormal rattling sounds, entered HEV Lock Mode, and the vehicle stalled. The vehicle occasionally came to a complete stop in the middle of the road and had to be pushed out of the roadway. On other occasions, the driver was able to pull over to the side of the road. The vehicle failed to restart and was towed after stalling. The contact stated that the check engine warning light was illuminated before the vehicle entered HEV Lock Mode, with several unknown warning lights illuminated. The vehicle was towed to the dealer, where several tests, including bearing clearance tests and unknown repairs, were performed; however, the failure persisted. During the final service visit, the dealer diagnosed the vehicle with engine wear and tear and fractured pistons. The dealer determined that the engine needed to be replaced; however, the service manager informed the contact that there was no guarantee that replacing the engine or catalytic converter would resolve the failure due to severe engine damage. The vehicle was not repaired. The manufacturer was notified of the failure and offered loaner vehicle assistance on several occasions; however, coverage for the engine replacement was denied. The failure mileage was approximately 110,000.

We had a recall done, Campaign 92C, and every since then the car drives horrible. It's worse when cool, it sputters, and hesitates especially when excellerating. Even after warmed up it seems to slam in and out of gear at low speeds, even when foot is not on the gas. The drive is choppy. The dealership told us to drive it and let the transmission "learn" our driving patterns, but it has not resolved itself. Before campaign car ran smooth, now shuttering and sputtering.

I was driving and all of a sudden the traction lights turned on and the sterring wheel is hard to turn. Almost go in a car accident. The windows just stopped working and the brakes light constantly keep getting burned out.

I am writing to report a direct violation of the Theta II Class Action Settlement terms by Hyundai Motor America. This morning , I emailed an Executive Case Manager explicitly explaining that my 2017 Sonata has an active P1326 code, has the 2019 KSDS update, and requires a mandatory diagnostic under NHTSA Recall 17V226 that cannot be denied due to a salvage title. Instead of replying to my facts, the Case Manager Kathy gave me a hard denial falsely framing my federal recall safety request as a "voluntary goodwill warranty" issue to justify her rejection. Please help me in getting authorization my car with Hyundai dealership in Plano Tx to run the bearing rod test and get it fixed.

My engine seemed to be consuming oil way to much I had to do a oil change at 61,000 recommend by tire plus but at 58,000 is when I had to change my oil I also noticed there is a buring smell and its also been leaking oil at times I went to get it checked out by a mechanic at tireplus but they also they are seeing that the oil consumption was not normal and they recommend a possible recall for it because it hazardous for how fast its consuming and the leaks

Driving home from work on [XXX] (not a safe location)when my car lost power and engine light began to flash. I pulled off to the side of road and called my dad. He came with a code reader and said there was a code P1326. He cleared the code and car drove normally again. 2 days later it began to run rough. I was told about the engine recall so I called Hyundai corporate and told them this same story. I was advised to take to dealership and have the “rod bearings inspected” and shouldn’t matter that my dad cleared the code. The dealership(Massey Hyundai MD) said it had a burnt valve and not part of warranty. But never checked rod bearings. When I called corporate. They said nothing they could do. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

High oil consumption, burning a quart of oil or more every 500 miles since bought used at Hyundai dealership.

My 2017 Hyundai Sonata SE, equipped with the Theta II 2.4L GDI engine, is experiencing severe powertrain failures including rhythmic metallic engine knocking, catastrophic oil consumption, and un-commanded surges/jumping in speed while driving. These symptoms manifested following an unauthorized engine replacement performed by Hyundai of El Cajon under Repair Order [XXX], where the dealer covertly outsourced my vehicle to a third-party shop (Legacy Motor Works) to install an unverified used salvage engine block rather than a certified factory assembly. This vehicle is a Class Vehicle under In re: Hyundai and Kia Engine Litigation (Case No. [XXX]), and the KSDS software update (Campaign 953) was successfully completed on my vehicle in 2019. The engine knock, surging, and oil consumption are consistent with the known connecting rod bearing failure defect described in NHTSA investigation PE17-007. The dealership is currently denying warranty coverage, citing a mileage limit that does not exist under my Lifetime Powertrain Warranty, and they are withholding physical documentation of the repair terms. The vehicle is also experiencing secondary safety failures, including a continuous airbag SRS warning light (two years) and electrical shorts caused by the salvage-yard alternator installation, which have destroyed 4 to 5 car batteries. This engine failure represents a significant safety hazard, as the vehicle periodically loses power and surges without driver input. I am requesting that NHTSA investigate this pattern of warranty denial, parts-sourcing fraud, and the safety risks posed by this substandard engine installation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The RED light is lit on the dashboard for the airbag. Unable to use steering wheel electronic features which helps with and was designed for hands free controls. I am unable to cycle through the electronic features or engage the cruise control due to the steering wheel electronics are in-op. Please help and get a recall started. This is not on the consumer.