2020 JEEP CHEROKEE Complaints

Received "SVC FWD" light on the dash. Four wheel drive stopped working. I was able to continue driving with front wheel drive only. Jeep had 13,000 when it happened. Took it to the dealership for inspection in September 2025. They diagnosed it as a bad PTU and needed replaced. They were going to call me when the new part came in. It's been over 5 months and I never heard from them.

Warning light came on that said "Service 4WD System" at approximately 86,969 miles on a 2020 Jeep Cherokee Trailhawk. Took to dealer and was advised that PTU (power transfer unit) must be replaced at a cost of $3,945.19. Was also advised that DTCM "transfer case control module must be replaced at a cost of $776.95. Total cost to resolve "Service 4WD System" problem as quoted is $4,722.14. It has been noted that older versions of this same vehicle model have been recalled by the manufacturer for this same problem. I would like to know why this particular model year has not been included that recall as it appears that the earlier noted manufacturing defect was not corrected for the 2020 model year.

Issue #1: Fuel pump failure, had to completely replace the fuel pump at approx. 60,000 miles. Approx. $1,300 repair. Issue #2: Rear differential failure due to faulty/poor construction of materials, per the repair shop. Failed at approx. 63,000 miles. There was no external damage to the differential, it was caused by poor construction/defects of the materials used to build the car. Approx. $4,500 repair. Both issues are KNOWN issues with Jeeps of this model year, to the extent that I have not been able to find replacement parts due to them being in such high demand.

The "4WD Needs Service" light appeared on the dashboard of our 2020 Jeep Cherokee Trailhawk. We took vehicle to the Enumclaw Chrysler Jeep Dodge Ram dealer located in Enumclaw, WA. Their service technician determined that the PTU (Power Transfer Unit) was failing and found active code c14a7-97 "ptu motor-component or system operation obstructed or blocked". Had the PTU completely failed we could have been left without any power to the drive wheels. This would have been very dangerous if the vehicle had lost power while driving on a freeway or major highway and the vehicle could not have been driven to a safe location. The dealer replaced the PTU and confirmed that the problem had been repaired. We don't know if the defective part is still available for inspection.

Failed Power Train Unit, and this is available for inspection. I was driving on the highway with my grandson and husband going 70 mph when the unit failed it basically felt like the car was thrown into neutral. Thankfully no one was hurt. Dealership has confirmed the issue. No issues driving the vehicle before the issue after the issue the light did come on and the vehicle is undriveable.

PTU failure needs replacements... 4k to fix. Safety issue and should be a recall.

While driving in northwestern Pennsylvania during a snowstorm, the driver engaged the vehicle’s factory “Snow Mode.” Immediately thereafter, the vehicle experienced a sudden loss of power and loss of steering control. The driver was forced to pull off the I79 interstate in severe winter conditions and exit the vehicle to avoid being struck by a snowplow. This created a dangerous roadside exposure and a significant risk of collision or injury. The vehicle was towed to a Jeep dealership and diagnosed with a failed rear differential requiring replacement. The dealership stated the part has been on national backorder since 2024, with no estimated availability. The failure occurred without warning and rendered the vehicle completely inoperable. The dealership further advised that this rear differential failure is a known issue, and recommended against installing a used replacement due to reliability and safety concerns. Safety Concern: This failure resulted in: •Sudden loss of vehicle control in hazardous weather •Loss of motive power •Forced roadside exposure in active traffic conditions The inability to obtain replacement parts compounds the safety risk by leaving the vehicle unusable and preventing timely repair. Request: I am submitting this complaint so NHTSA can evaluate whether this represents a systemic safety defect related to the rear differential in this vehicle platform, including failure mode, warning adequacy, and parts availability affecting safe remediation.

My PTU failed while driving 70mph on a 4 lane interstate during a heavy rush hour, I'm 7 months pregnant and this was mortifying for me. I lost all power moving forward and could not accelerate. My RPMS would near red-line. When I pulled on to the shoulder, while trying to not get hit or cause an accident from 3 lanes over, I put my car in park and shut it off, it sounded like a dying weedwhacker. It started rolling backwards without me noticing and I almost rolled back into the outside lane. I put on the e-brake, had it towed to Firestone where they said it was likely the PTU that failed as I have every gear, except moving forward. When they had my vehicle on the lift they moved the tires in reverse motion and there was no noise, when they moved the tires in forward motion there was a loud knocking coming out of the PTU and the tires wouldn't budge. If in park on a decline, park works. If in park on an incline or flat, it rolls backwards. It can drive in reverse, but no forward movement at all. I got it towed to another shop where they took out&opened the PTU and checked the gears on the shaft inside, one of the gears was COMPLETELY MISSING. Just completely disintegrated. There was NO warning that anything was failing on my car. No check engine lights, no noises. Just loss of acceleration. PTUs are on back order 3-5 months right now because they're a known issue on the 2017-2019 models of Jeeps. My Jeep is a 2020 Trailhawk with the v6 3.2l.

The Power Transfer Unit on my 2020 vehicle is not working. I bought this car specifically to have four wheel drive. In the Buffalo NY brutal winter I count on 4 wheel drive to get me through the snow. Now, I have a serious safety issue. I wanted to fix the car but not only is it expensive, but the parts are on back order with 2700 in the backlog waiting for parts. This is a known issue and there was a recall for a number of years including 2018 and 2019. They haven't issued it for 2020. I am being forced to sell the car at a loss! I can't drive something that is unsafe. Jeep should make us whole! I shouldn't lose money because of known safety fault. Plus, I can't keep it because i do a lot of driving and can't risk my life with no 4 wheel drive.

4wd service light came on. The code was c14a7-97. A well known PTU problem. There was a previous recall for the same problem. It can be a dangerous situation if it completely fails while driving. Also a very expensive repair bill. My 2020 Jeep Cherokee only has 72k miles and a has a major known failure already.