2021 JEEP GLADIATOR Complaints

I was exiting the freeway with a speed limit of 75 mph. On the off-ramp I lost control of the Gladiator. The front end wobble was so bad that I could not hold onto the steering wheel for fear of breaking my wrist. Instead I had to wrap my arms about the wheel in an attempt to stop the wobble. I was unable to keep the vehicle in my lane, and finally ended up in a large ditch next to the off ramp. What happened appears to be a problem with the Mopar 1.5" lift kit installed by the dealer. The kit was installed 8/17/2021. This incident occurred in Jan 2022, about 4,000 miles later. I had the kit installed and then inspected about a month later specifically to check for any loose bolts, and to double check the torque for the bolts. The CV bar in the front lost a the bolt on the passenger side, dropping the cross bar and resulting in total loss of control of the passenger side front tire. I felt very lucky not to have been injured, and not to roll the jeep. It took about 150 feet to stop the vehicle in the ditch. I am attaching a photo of the bar held in place after the accident using bungie cords. This was done just to get the bar off the road and allow for moving the vehicle. The mechanic was able to secure the cross bar with a new bolt. The original bolt and nut were not found. We speculate that either the bolt was not torqued correctly or might have been missing a lock washer. At any rate, potentially this could have resulting in much worse. If this happened just a few seconds earlier on the freeway, the damage and injuries could have been much worse. Now the vehicle is driving like new, after new bolt and alignment. However, I will be checking those bolts more frequently, particularly if I notice any extra play in the steering. Before this happened, the play in the steering had increased. I thought I just needed an alignment, but it was much worse than that. Really I would think this cross bar needs redesign to ensure it can't break loose.

Driving at approx. 70 mph the vehicle steering became very difficult to control. I was unable to turn the steering wheel ( it felt like a vehicle without power steering at low speed). I slowed the vehicle down, I could feel the steering get easy as I neared a stop. After stopping at a stoplight and resuming the vehicle drove normally. The vehicle was never shut off.

Transmission is very clunky and jerky especially at low speed or when little input is applied to the gas and or if you are switching between brakes and gas in traffic. Transmission feels very hesitant. The steering isn’t terrible at low speeds but at highway speeds the vehicle wanders left and right at random. I have to put it a lot of micro movements with the steering wheel in order to keep it straight.

The "death wobble." When driving over 55mph even the slightest bump will set off a violent chain reaction of vibrations. This causes unsafe driving conditions and loss of control. The only way to regain control is to quickly slow down to less than 55mph and at highway speeds this is extremely dangerous. Jeep has failed to fix this and wont even acknowledge that it is an issue.

In January 2021, my 2021 Jeep Gladiator Overland became unstable at normal freeway speeds (60-75 mph) on many occasions. The slightest bump or surface irregularity stimulates a violent and sustaining side-to-side vehicle shudder/vibration from the front suspension that was very extreme that lasted for over 2 minutes or until the vehicle slowed to around 60 mph; where stable vehicle behavior restored. This extreme instability and needed hard braking creates a serious driving hazard. I have taken it to 2 separate dealers who cannot find any issue and are unwilling to investigate unless it happens in their presence even with video proof. I have also taken to a tire shop and had the tires re-balanced and put on a road force machine. The tire shop found no issues with the tires or balancing. This started at about 23,000 miles and occurs more as the temperatures drop. This failure mode is severe, occurs without warning, is not detectable until it occurs and is very frightening. My Jeep has stock, factory wheels and factory tires in good balance with no visible or abnormal tread wear. This is a dangerous condition that needs immediate correction. A 1 year old vehicle with 23,000 miles in excellent condition, no accident history and no modifications should not be doing this. Side note; I did have to have the engine replaced after 11 months of ownership and the Jeep came from the factory with cracked spark plugs and had the spark plugs replaced after 1 week of ownership. This is an ongoing issue with no resolution.

In December, 2021, my 2021 Jeep Willys Gladiator became unstable at normal freeway speeds (70-75 mph) on ~8 occasions. At these speeds, the slightest bump or surface irregularity stimulates a violent and sustaining side-to-side vehicle shudder from the front suspension that was so extreme that it splashed my cola and ice from the center cup holder to the dashboard and doors. R-L-R Steering inputs had no effect and hard braking had no effect until the vehicle slowed to around 60 mph; where stable vehicle behavior restored. This extreme instability and needed hard braking creates a serious driving hazard. The dealer is installing a new steering damper. The engineer in me says there is a bearing, bushing or ball joint as root cause. This defect manifested at ~23,000 miles and occurs more readily as the temperatures drop below 20 deg F. This failure mode is severe, occurs without warning, is not detectable until it occurs and its effect is panic-inducing. My Jeep has stock, factory aluminum wheels and normal sized Michelin All-Season radial tires in good balance with no visible or abnormal tread wear. I ordered this vehicle new on 3/1/2021. The 'Gladiator forum' calls this condition "death wobble". Anecdotally, the condition appears to be associated with vehicles having "lift kits" as well as stock vehicles. My 'Willys Jeep is built by FCA with a modest suspension lift relative to the base Gladiator models. Other (anecdotal) owner information has identified loose ball joints, defective drag link bushings and steering free play as root causes in other new, low mileage vehicles. I am a retired engineer with vehicle development, professional driving and prototype vehicle experience. This is a dangerous condition that needs immediate correction. A 7-month old vehicle with 25,000 miles in excellent condition, no accident history and no modifications SHOULD NEVER DO THIS. A steering damper may reduce this death wobble but there is a more likely root cause.

My jeep has bottomed out multiple times on normal road bumps. I've owned 4 other jeeps and have never experienced this before I've noticed there is one 3" of travel allotted between the front axle and the bump stops and I under stand that the diesel motor weight more than the 3.6l but to not compensate for the extra weight and running the same suspension setup as the 3.6l is not even right.... To spend 57,000$ on a vehicle that I can't just drive down the road without having to watch for bumps or manhole cover because I don't want to jar my back is no peace of mind.

The contact owns a 2021 Jeep Gladiator. The contact stated while driving 75 MPH, the vehicle inadvertently lost power steering assist. There were no warning lights illuminated. The contact continued to drive the vehicle with manual steering functionality. The contact stated that one and a half miles later the vehicle regained power steering functionality. The contact pulled to the nearest parking lot and notified the dealer of the failure. The vehicle was taken to the dealer who diagnosed that the steering pump needed to be replaced. The manufacturer was notified of the failure and a case was opened. The vehicle was not repaired. The failure mileage was approximately 2,900.

The vehicle auto starts when the AC is turned on with the Auto HAVC set to off. The owner’s manual states that “the engine will start automatically when” the “Actual cabin temperature is significantly different than temperature set on Auto HVAC.” The vehicle is operating in direct conflict with owner’s manual. This auto start issue poses a serious safety hazard as the vehicle will unexpectedly start and may begin to roll when the driver is not ready. Additionally, if someone is operating on or under the vehicle, it will result in a serious injury or the loss of a finger when the vehicle auto starts in violation of the driver’s intent. The unexpected / wanted start could cause a collision with another vehicle or pedestrian leading to serious injury or death. The malfunction was reproduced and confirmed by multiple service personnel, who expressed safety concerns. The malfunction was also recreated by 4 independent mechanic shops and documented as a safety concern. However, an FCA Technical Advisor (TA) claimed that the vehicle is “operating as designed“. This portion of the vehicle’s Auto Start / Stop System is NOT operating as designed and documented in the owner’s manual. I feel unsafe driving the vehicle, as this is one of numerous hardware / software malfunctions plaguing the vehicle. The vehicle is available for inspection upon request.

The vehicle auto starts when the fan is turned on without the AC. The owner’s manual does not list this as one of the “Conditions that will cause the engine to start automatically”. The vehicle is operating in direct conflict with owner’s manual. This auto start issue poses a serious safety hazard as the vehicle will unexpectedly start and may begin to roll when the driver is not ready. Additionally, if someone is operating on or under the vehicle, it will result in a serious injury or the loss of a finger when the vehicle auto starts in violation of the driver’s intent. The unexpected / wanted start could cause a collision with another vehicle or pedestrian leading to serious injury or death. The malfunction was reproduced and confirmed by multiple service personnel, who expressed safety concerns. The malfunction was also recreated by 4 independent mechanic shops and documented as a safety concern. However, an FCA Technical Advisor (TA) claimed that the vehicle is “operating as designed“. This portion of the vehicle’s Auto Start / Stop System is NOT operating as designed and documented in the owner’s manual. I feel unsafe driving the vehicle, as this is one of numerous hardware / software malfunctions plaguing the vehicle. The vehicle is available for inspection upon request.