2022 JEEP GLADIATOR Complaints

The contact owns a 2022 Jeep Gladiator. The contact stated while driving approximately 65 MPH, the vehicle independently shifted to neutral(N), with the engine still running. The contact pulled off the roadway and was able to stop and shift into park(P). The contact stated that several unknown warning lights were illuminated. The contact turned off and restarted the vehicle and shifted to drive(D) and continued driving to the residence. The contact stated that the failure was intermittent but was a recurring failure. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the CAN-C BUSS had tripped due to loosened connections, causing the transmission to shift to neutral(N). The dealer advised that replacing the CAN-C BUSS connections would loosen again and the failure would reoccur. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 36,000.

Component Affected: Engine – Camshaft and Rocker Arms Summary of the Problem: My 2022 Jeep Gladiator experienced a failure of the camshaft and rocker arms due to scoring on the camshaft. This issue occurred at approximately 52,000 miles. The vehicle is currently inoperable (on and off flashing check engine light) Dealership gave me the vehicle back to drive while awating parts for repair. The required components are on national backorder with an estimated delay of over 4 weeks, leaving me without a functioning/safe vehicle. Safety Concern: This failure occurred without warning and could have led to a dangerous situation if it had happened while towing. I use this vehicle to tow a 3,500 lb camper, which is well within its rated towing capacity (6,500 lbs). The sudden loss of engine performance could pose a serious safety risk, especially on highways or in remote areas. Additional Notes: I am reporting this issue because I have learned that other Jeep Gladiator owners have experienced similar camshaft and rocker arm failures. This may indicate a broader defect in the engine design or materials. I believe this issue warrants investigation for potential recall or manufacturer accountability.

The contact owns a 2022 Jeep Gladiator. The contact stated that while an independent mechanic was driving 60 MPH, the vehicle drove over a pothole, and the steering wheel and the front end of the vehicle shuddered violently. The contact stated that the vehicle experienced the "Death Wobble". The mechanic diagnosed that the steering column and other unknown parts needed to be replaced. The vehicle was taken to the dealer, where it was diagnosed that unknown parts of the front end of the vehicle needed to be replaced. The vehicle was repaired. Additionally, the vehicle remained at the dealer for the recall repair of NHTSA Campaign Number: 24V652000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 21,800. Parts distribution disconnect.

I am filing a safety complaint concerning my [Year] Jeep Gladiator (VIN: [Insert VIN]), which has experienced two high-pressure fuel pump (HPFP) failures—the latest occurring on [XXX]. This issue is directly related to the Jeep HPFP recall previously issued in 2023. After the first HPFP failure, the fuel system—including the pump, injectors, fuel lines, rails, filter, and tank—was replaced under warranty using Jeep’s reengineered HPFP component. The vehicle then sat at the dealership for five months awaiting parts and repair. Jeep also issued a compensation check, which I accepted based on the belief that the reengineered pump was a permanent fix. However, the same failure occurred again on [XXX], requiring a nearly identical replacement of the full fuel system. The recurrence of this failure, even after the “fix” Jeep implemented through the recall, raises serious concerns about the reliability and safety of the reengineered HPFP. I am concerned this is a systemic design flaw that has not been resolved. To date, my vehicle has been out of service for extended periods, and these failures could result in engine stalling, fuel leakage, or loss of power, increasing the risk of a crash or injury. Jeep has not provided adequate assurance that the reengineered part will prevent future failures. I am requesting that NHTSA investigate whether the reengineered HPFP provided through the recall is effective and whether additional action is needed to protect consumers. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine began making a ticking noise and quickly began misfiring and displaying error messages. Dealership diagnosed issue as a camshaft failure, and which is a very common issue on the 3.6L V6. Issue happened on a rural road at night, but could've been a serious safety issue if it had happened in a different setting.

At highway speed the front suspension and steering wheel begin to shake violently after hitting a bump. This happens between 65 and 75 mph and I must slow to around 45 for it to stop. This is a well known problem with these jeeps and is referred to as "the jeep death wobble". I took it to the dealership for inspection under warranty and they found nothing wrong. 2 weeks later it did it 3 times on a short trip down expressway.

Jeep caught on fire in engine bay while parked in a parking lot. Vehicle was not running at the time. Vehicle had not been running for 20 minutes.

The contact owns a 2022 Jeep Gladiator. The contact stated that while the vehicle was occupied and driven at 5 MPH in the residential driveway, smoke started to be emitted from under the hood. The contact opened the hood and discovered fire primarily emitting from the top of the battery. No warning lights illuminated. The contact then used a broom to try to turn off the fire, and the contact then used water to turn off the fire. There were no injuries sustained. The contact did not file a fire report, and a police report was not filed. The fire was extinguished by the contact with water to certain the fire was extinguished. The vehicle had damage due to the fire, however, it was not destroyed. The dealer was informed of the failure, and the contact was informed that the vehicle was no longer under warranty; however, due to costs was taken back to the residence and remained in the contact's possession. The contact took the vehicle to an independent mechanic the vehicle was inspected; however, the vehicle was not diagnosed. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The contact referenced Investigation ID: PE24024 for Subject: Underhood fires. The failure mileage was approximately 4,000.

Violent side-to-side movement of the front end “Death wobble” when driving over a bump at a certain speed. This is my 2nd Jeep, but my 2013 Wrangler also had the same issue. From my experience, this is a consistent issue with Wranglers / Gladiators that should be investigated and / or addressed with free repairs or extended warranties.

Third brake light on tailgate continues to malfunction. It has been replaced once. This seems to be a common issue reported among Gladiator owners.