2006 JEEP WRANGLER Complaints

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V22200 (POWER TRAIN); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

I PURCHASED THIS JEEP USED AND THE VERY FIRST TIME I FILLED THE FUEL TANK, GAS SPEWED PROFUSELY FROM THE TANK OPENING WITHOUT TRIGGERING THE NOZZLE TO STOP AS THE TANK WAS APPROACHING FULL. THIS CAUSES GASOLINE TO SPRAY ALL OVER THE VEHICLE, THE PUMP, THE OPERATOR, AND TO PUDDLE ON THE GROUND. THIS SAME SCENARIO HAS PLAYED OUT AT EVERY GAS STATION I HAVE VISITED SINCE. THE ONLY SOLUTION IS TO TRY TO GUESS WHEN THE TANK IS CLOSE TO FULL AND STOP THE PUMP PREMATURELY. THIS IS A SERIOUS SAFETY AND ENVIRONMENTAL ISSUE THAT WARRANTS IMMEDIATE CORRECTION FROM THE MANUFACTURER. I CONTACTED THE PREVIOUS OWNER OF THE VEHICLE AND SHE STATED THAT THE SAME FUEL OVERFLOW PROBLEM WAS PRESENT THE ENTIRE TIME SHE OWNED THE VEHICLE. IN SPEAKING WITH OTHER JEEP OWNERS, THIS IS A VERY COMMON PROBLEM WITH 2005-2006 JEEP WRANGLER MODELS AND HAS EVEN RESULTED IN AT LEAST ONE CLASS ACTION LAW SUIT. PLEASE HELP PREVENT A FUTURE CATASTROPHE AND TAKE ACTION ON BEHALF OF THE CONSUMER ASAP.

THE FILLER NECK DOESN'T CLOSE FAST ENOUGH WHEN FILLING THE GAS TANK, THUS RESULTING IN GAS SPEWING OUT ONTO THE JEEP (CONSEQUENTLY FADING ANY FENDER YOU HAVE INSTALLED) AND ONTO YOUR PERSON. AS PER SEVERAL CAR MECHANICS' CONSULTATIONS, THE ETHANOL IN GAS IS/HAS ERODED THE FILLER NECK AND IT CAN'T CLOSE IN TIME. APPARENTLY THE ISSUE WAS ADDRESSED IN LATER MODELS OF THE JEEP WRANGLER. IT IS A NEARLY $600 FIX (INCLUDING LABOR). TEMPORARY SOLUTION: ONLY PUT ABOUT $25 IN THE GAS TANK AT A TIME (WHICH IS INCONVENIENT IS YOU ARE CONSTANTLY TRAVELING).

WHEN FILLING THE FUEL TANK IT ALWAYS OVERFLOWS. IT DOES NOT MATTER THE STATION OR HOW THE PUMP IS IN THE TANK. IT ALWAYS SHOOTS GAS OUT BEFORE IT KICKS OFF. I THINK THIS IS A SERIOUS FIRE HAZARD AND I ALSO CAN SPRAY FUEL ON THE PERSON FILLING. IT SOUNDS LIKE THIS IS AN ONGOING ISSUE WITH THIS MODEL AND NOTHING HAS BEEN DONE???

EVERY TIME THE GAS IS FILLED, FUEL OVERFLOWS AND POURS ONTO THE VEHICLE, GROUND AND WHOMEVER IS STANDING NEAR IT. *TR

TANK OVERFLOWS WHEN FILLING UP WITH FUEL. PUMP AUTO SHUT OFF DOES NOT WORK ON THIS VEHICLE AT ANY STATION. ALWAYS GET FUEL OVERFLOW. *TR

I PURCHASED THE WRANGLER IN ABOUT OCTOBER OF 2009. SINCE THEN, THE FUEL TANK OVER-SPILLS WHEN IT IS FILLED AT THE GAS PUMPS. IT CAUSED DAMAGE TO THE PAINT AND TO THE PLASTIC WHEEL GUARD. OF GREATER CONCERN IS DEATH WOBBLE. THE FRONT END VIOLENTLY SHAKES AT HIGHWAY SPEEDS FROM TIME TO TIME. THE VEHICLE IS HARD TO CONTROL. I MADE ATTEMPTS IN 2013 AND 2014 TO FIX IT, ONLY TO HAVE THE PROBLEM RETURN. IN 2013 THE STEERING DAMPER AND STEERING STABILIZER BAR WAS REPLACED. IN 2014, THE TIRES WERE REPLACED AND ALIGNED. THE PROBLEM RETURNED THIS YEAR, AND IS AT ITS WORST. *TR

2006 JEEP WRANGLER UNLIMITED AFTER GETTING FUEL FILLED I PULL OUT OF STATION AND IT STARTS HESITATING AND THEN STALLS IN MIDDLE OF STREET. IT NEARLY CAUSED AN ACCIDENT FROM CAR BEHIND ME I HAD TO RESTART AND IT WOULD STALL AND BOG FEW MORE TIMES THEN RUN OK. TODAY I FUELED UP AND PULLED OUT OF STATION AT A 6 LANE DIVIDED ROAD WITH AN INTERSTATE WITH ON AND OFF RAMPS BOTH SIDES SO I HAD ONLY 100 FEET TO CROSS THREE LANES TO GET INTO LEFT TURN LANE FOR INTERSTATE AS THIS LANE GOES UNDER AND AT LIGHT TURNS LEFT TO ON RAMP, JUST TO GIVE YOU INSIGHT ON SITUATION, I FUEL UP PULL OUT AND IT SHUTS OFF CARS HAVE TO STOP I AM IN MIDDLE OF THREE LANE DEAD IN THE WATER IT STARTS BACK UP AND I PULL UP THANK GOD A SAFE DISTANCE TO CAR IN FRONT OF ME AND IT BOGS DOWN AND THE SURGES MAKING THE JEEP THRUST FORWARD HAD TO BRAKE HARD NO ACCIDENT WAS CAUSED BUT GOD FORBID IT COULD HAVE PLEASE RESEARCH THIS. *TR

WHEN REFUELING FUEL TANK ON THIS VEHICLE THE FUEL PUMP WILL NOT SHUT OFF WHEN FUEL ENTERS FILLING TUBE OF VEHICLE THUS CAUSING FUEL TO BE SPILLED OUT OF THE FILLING TUBE AND ONTO EXTERIOR OF VEHICLE, DRIVING SURFACE AND FUEL FILLING SYSTEM INCLUDING THE HOSES AND PUMP(S). THE FUEL FLOW HAS SUCH FORCE THAT THE PERSON OPERATING FILLING PUMP WILL ALSO BE SPRAYED WITH FUEL ON THEIR PERSON AND CLOTHES AS WELL AS AREAS MENTIONED PREVIOUSLY. THIS CAUSES A SEVERE EXPLOSIVE ENVIRONMENT IN THE PROXIMITY OF STATIC ENERGY. I HAVE NEVER REFUELED MY VEHICLE WITHOUT THE OVERFLOW HAPPENING UNLESS I ONLY PARTIALLY FILLED MY FUEL TANK, WHY HAVE A 19 GALLON TANK IF YOU CAN ONLY USE 2/3 OF IT? THERE IS A SEVER DANGER OF FIRE/EXPLOSION DUE TO THE AMOUNT OF FUEL THAT IS SPILLED BEFORE THE PUMP IS STOPPED. *TR

EVERY TIME I FILL THE TANK FULLY, SINCE NEW, THIS VEHICLE HAS OVERFILLED AND SPILLED APPROXIMATELY 0.3 GALLONS OF FUEL. I HAVE TWO FRIENDS WITH 05-06 JEEP WRANGLERS WITH THE SAME FUEL FILLER NECK, BOTH HAVE THE SAME PROBLEM. CHRYSLER IS UNWILLING TO REPAIR AT A REASONABLE COST, BUT IT IS A DESIGN FLAW THAT IS DANGEROUS TO THE OWNER OF THE VEHICLE AND THE ENVIRONMENT. *TR