2017 JEEP WRANGLER Complaints

Oil cooler assembly cracked and warped (also k own as oil filter housing) this led to a large oil leak and depleted all oil from engine. Repair was over $1,000. All mechanics are saying this is a known issue and becomes expensive because both intake manifolds need to be removed to replace

This event occurred on 12/16/2022. The temperature was 30 degrees Fahrenheit and was snowing in Chicago. Upon turning on the defrost setting in the vehicle, the windshield began to crack and put the safety of the passengers at risk. Upon keeping the defrost on, the crack on the windshield contend to grow (larger than 6"). There were no previous cracks or damage to the windshield. There were no warning lights or messages indicating any issues with the windshield.

Oil cooler warp/crack because the bottom is made of plastic stored inside engine where extreme heat causes warp/crack on the cooler. Ultimately leaks out oil, causing saftey hazards to the community and owner. A known defect/issue with all penstar engines (other vehicles with this engine are affected). There should be a recall for this issue/defect. I hope NHTSA do a thorough investigation on this issue. Thanks!

The Front brake calibers ( both ) right and left have completely frozen and locked up under normal operation, twice, since the vehicle was bought new. It created direct emergent highway conditions as the vehicle became uncontrollable and created extremely high heat conditions to the rims/brake pads and bearings. Totaling over 2 thousand dollars in repairs

The contact owns a 2017 Jeep Wrangler. The contact stated that the odor of fuel was present inside and outside of the vehicle. Upon inspection, it was discovered that fuel had leaked underneath the vehicle. The vehicle was taken to the local mechanic who diagnosed that the fuel tank control valve had cracked causing fuel to leak from the fuel tank. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The contact was informed that the vehicle was not included in the NHTSA Campaign Number 16V849000 (Fuel System, Gasoline). The contact indicated that the vehicle had experienced the same failure listed in the recall. The local dealer was not contacted regarding the failure. The failure mileage was 86,000. The contact stated that the defective fuel tank was replaced by the local mechanic.

My 2017 Jeep Wranger Sahara Unlimited has 36,000 miles on it and the front right brake caliper seized up. It should not already be faulty with that low of miles. I have done researched and found numerous other people have had the same problem with the same year jeep as mine. I replaced the pads, rotor and caliper on it at my expense but it shouldnt have gone bad already. A definate recall should be done

In November 2019, 47,000 miles I began experiencing issues with the vehicle popping out of reverse and grinding gears. A shift fork was replaced under warranty. Now, at 68,000 miles I am experiencing the exact same issue. The part is now out of 2 year warranty.

My rear calipers are frozen. My car has 41,000 miles on it now and at 21,427 miles my rear calipers were frozen I paid and got them replaced and now again there frozen something doesn’t make sense

After driving vehicle, strong burning smell Took to dealership - diagnose is new calipers - 5 year old vehicle with 52,000 plus miles. Asked Chrysler to recognize through phone call to customer service??? Inquiring about warranty first then asking for them to recognize defect in same phone call - third party warranty is helping with costs - brake calipers and lines should not be failing on this vehicle at 5 years old 52,000 plus miles and unmodified

This jeep has 60,000 miles and is 5 years old and has had all 4 calipers seized and rotators brakes replaced and cylinders misfired in the engine that has been replaced. All this on a new vehicle is insane and a safety hazard for a vehicle this young AND with this low of mileage. I took ownership of this jeep in March of 2020 with 33k miles. Then in January 2021 with about 40k miles on the car being 3 1/2 years old the back calipers seized causing smoke and burning smell and was a fire hazard and unsafe to drive. Fast forward another year and a few months later on May 13th I was driving the vehicle and the BACK calipers siezed while in operation and now both rear sides had to be replaced, rotators, calipers, brakes and hoses. A year and 1/2 later only 15,000 more miles. So now all 4 calipers siezed and were replaced, motors, brakes, hoses. This most recent time it was to the cost of $1427.15. I googled this issue and it is a common issue and a known issue in jeeps especially in 2017s. A complaint from 2017 shows a gentleman was reimbursed for this exact issue by FCA after his complaint and I am looking for the same. I have also had the engine cylinders misfire and go up in this jeep as well that occurred 2 months ago!