2006 JEEP WRANGLER Complaints

FUEL SPILLS FROM FILLER NECK UPON COMPLETION OF REFUELING IN MY 2006 JEEP WRANGLER. PLEASE EXPAND CURRENT INVESTIGATION TO EARLIER MODEL YEAR JEEP WRANGLER VEHICLES. *TR

I HAVE A 2006 JEEP WRANGLER AND EVERYTIME I FILL UP THE FUEL TANK IT OVERFLOWS AND SPILLS EVERYWHERE. THIS COULD BE A MAJOR CAUSE FOR FIRE OR EXPLOSION. *TR

I HAVE A 2006 JEEP WRANGLER AND EVERYTIME I FILL UP THE FUEL TANK IT OVERFLOWS AND SPILLS EVERYWHERE. THIS COULD BE A MAJOR CAUSE FOR FIRE OR EXPLOSION. *TR

2006 JEEP WRANGLER X I RECENTLY PURCHASED THIS VEHICLE USED WITH 58,000 MILES. I DISCOVERED A VERY DANGEROUS CONDITION WHEN FILLING UP WITH GAS. THE GAS FLOW TO THE TANK DOES NOT PROPERLY TURN OFF WHEN THE TANK BECOMES FULL. THE FIRST TIME THIS HAPPENED TO ME I WAS SPRAYED WITH GASOLINE ON MY CHEST ... NEARLY MISSING MY FACE. I THOUGHT THIS WAS A FLUKE BUT IT HAPPENED AGAIN THE NEXT TIME I FILLED UP. I'VE LEARNED TO ONLY FILL UP THE TANK HALF WAY. I DID AN INTERNET SEARCH AND FOUND THAT THIS IS A VERY COMMON PROBLEM WITH NEWER JEEP WRANGLERS. IT IS ALSO AN ENVIRONMENTAL ISSUE AS WELL BECAUSE GASOLINE JUST TRAVELS DOWN THE JEEP AND INTO THE GROUND. I HAVE LEARNED THROUGH JEEP INTERNET FORUMS THAT THIS IS A VERY COMMON ISSUE WITH JEEP WRANGLERS. THIS ISSUE MUST BE ADDRESSED BY CHRYSLER THROUGH A VEHICLE RECALL. THERE WILL DEFINITELY BE DEATHS/INJURIES FROM THIS IF IT IS NOT PROPERLY ADDRESSED BY CHRYSLER. *TR

WHEN FILLING GAS TANK ON 2006 JEEP WRANGLER THE GAS OVER FLOWS AND SPRAYS OUT WHEN FULL. ON NUMEROUS OCCASIONS IT HAS SPRAYED GAS IN MY FACE. *TR

TL*THE CONTACT OWNS A 2006 JEEP WRANGLER UNLIMITED. THE CONTACT STATED THAT WHEN FILLING THE FUEL TANK, THE FUEL SPILLED BACK OUT. THE VEHICLE WAS INSPECTED BY AN AUTHORIZED DEALER WHO STATED THAT THE BALL FLAP WAS STUCK IN THE OPEN POSITION. THE VEHICLE WAS REPAIRED BUT THE FAILURE CONTINUED. THE VEHICLE HAD NOT BEEN REPAIRED AGAIN. THE FAILURE MILEAGE WAS 20,232.

2006 JEEP WRANGLER RUBICON - PROBLEM STARTED TO OCCUR AT 49K MILES(COULD HAVE BEEN EARLIER-I BOUGHT THE CAR AT THIS MILEAGE, 2ND OWNER). GAS WOULD SPIT/FLOW OUT OF THE FILL PORT BEFORE THE PUMP CLICKS OFF FOR FULL. IT ALWAYS GOES ON YOUR HANDS, CLOTHES, FLOOR AND DOWN THE SIDE OF THE JEEP. AT 52K(CURRENTLY HAVE 84K) IT HAPPENS EVERY TIME NOW. SO NOW YOU HAVE TO PUT YOUR EAR CLOSE TO THE GAS TANK AND LISTEN FOR IT TO BECOME ALMOST FULL, AND STOP PUMPING QUICKLY BEFORE IT OVERFILLS AND SPITS OUT.(THIS IS THE ONLY WAY TO GET A FULL TANK) ON SEVERAL OCCASIONS, IF THERE IS A LOT OF AMBIENT NOISE, YOU WILL MISS THE "ALMOST FULL" SOUNDS AND IT'LL SPRAY GASOLINE ON YOUR FACE/CLOTHES. I'M SICK OF DEALING WITH THIS ISSUE, IM OUT OF WARRANTY, SO DEALER IS NO HELP. ALSO WHEN TRAVELING TO NJ, THE GAS ATTENDANTS ARE FULL SERVE ONLY BY LAW, AND THEY COMPLAIN TO ME EVERY TIME I NEED TO GET GAS IN NJ. IT SPITS GAS ALL OVER THE ATTENDANT. THIS IS A SERIOUS SAFETY ISSUE, I GET GAS ON MY SKIN ALMOST EVERY TIME I'M REFUELING THE JEEP. CHRYSLER/JEEP NEEDS TO DO A RECALL. THERE ARE THOUSANDS+ OF THESE COMPLAINTS. *TR

I'VE BEEN DEALING WITH THIS PROBLEM FOR 4 YEARS. WHILE FUELING, GASOLINE WILL OVERFLOW WITHOUT CUTTING OFF. ALSO, IT IS VERY DIFFICULT TO PUMP A FULL TANK WITH ALL OF THE BACK PRESSURE CAUSED THE NECK AND GAS TANK PROBLEMS. THIS IS VERY DANGEROUS AND NEEDS TO BE INVESTIGATED ON MODELS LATER THAT 2007. *TR

EVERY TIME WE FILL OUR GAS TANK IT SPRAYS OUT ALL OVER WHEN FULL. DEALERSHIP SAYS WE MUST PAY FOR A NEW FUEL TANK TO REPAIR THIS ISSUE. THIS IS A FAULTY FLAP INSIDE TANK. WE WILL NOT PAY FOR A NEW TANK SINCE THEY HAVE THE SAME FLAP DESIGN. THIS SHOULD BE RECALLED. *TR

FILLING UP GAS TANK ON 06 JEEP WRANGLER GAS SPILLING OUT OF FILL NOZZLE EVERYTIME I FILL UP, WASTING FUEL DEP ENVIRONMENTAL PROBLEMS WE NEED RECALL TO GET THIS FIXED. *TR