2021 JEEP WRANGLER Complaints

The contact owns a 2021 JEEP Wrangler. The contact stated that while opening the vehicle's rear swing gate, they noticed that the rear windshield defroster grid was completely burnt and melted, with a scorched power wire leading directly to the glass terminal. The contact referenced NHTSA Campaign Number: (24V111000 (VISIBILITY) however, the VIN was not included in the recall repair. The vehicle was taken to a dealer where it was diagnosed to have a failure on the defroster. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 57,140.

Paint bubbling and aluminum body panel corrosion on hood and front doors of my 2021 Jeep Wrangler Unlimited (VIN [XXX] ), currently at 63,000 miles. This is a well-documented manufacturing defect affecting 2018-2021 JL Wrangler and 2020-2021 JT Gladiator vehicles with aluminum body panels. Stellantis has issued multiple Technical Service Bulletins addressing this exact condition: TSB 31-001-18 (March 2018), TSB 31-001-19 (July 2019), TSB 31-002-20 (October 2020), TSB 31-002-22 (December 2022), and most recently TSB 31-001-26 Revision A (February 2026), all titled "Aluminum Body Panel Corrosion Repair." The corrosion presents as paint bubbling along the leading edge of the hood and on the door panels. Filiform corrosion develops under the paint over many months before becoming visible. My corrosion warranty expired in January 2026, just one month before the latest TSB was issued. I am reporting this defect for federal documentation. The manufacturer has been aware of this defect for over 8 years (since 2018) and continues to issue revised TSBs rather than implementing a recall. A class action lawsuit ([XXX] et al. v. FCA US LLC) has been filed regarding this same defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was on [XXX] . Going about 55 when I went over a bump in the road and my jeep started shaking out of control going into the other lane almost causing an accident. It a jeep wrangler rubicon 2021 with 23000 miles on it and garage keep. Jeep should stand behind this problem due to the fact it involves many jeeps and can kill someone. It’s a well known problem that they are not stand behind. How many accidents or people killed does it take to have this safety hazard addressed by this corporation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Instrument cluster failure. I completed a short trip wherein it was working fine. Went back out several hours later to return home at midnight. The instrument cluster had no power and did not function. I am currently driving with no speedometer, no tachometer, no fuel gauge. I am flying blind because of a known defect in Jeep instrument clusters (NHTSA report 24V652000) between 2020-and 2024. Recall 30b was used to narrowly target other jeeps...but mine somehow does not qualify meaning it is my problem...though it is a well enough known issue that they have a recall on other instrument clusters just failing. As we know from Fight Club they have no intent to do recalls on anything other than the least cost to themselves: “Wherever I'm going, I'll be there to apply the formula. I'll keep the secret intact. It's simple arithmetic. It's a story problem. If a new car built by my company leaves Chicago traveling west at 60 miles per hour, and the rear differential locks up, and the car crashes and burns with everyone trapped inside, does my company initiate a recall? You take the population of vehicles in the field (A) and multiple it by the probable rate of failure (B), then multiply the result by the average cost of an out-of-court settlement (C). A times B times C equals X. This is what it will cost if we don't initiate a recall. If X is greater than the cost of a recall, we recall the cars and no one gets hurt. If X is less than the cost of a recall, then we don't recall.” ? [XXX] lub [XXX] I [XXX] (B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The primary component involved is the high-voltage charging system, specifically the charging port and connector interface. The vehicle previously experienced a confirmed failure involving a scorched charging port and a melted pin, which required replacement. The same symptoms have since returned, including heat at the charging interface and a burning odor. The vehicle is currently located at an authorized dealership and is available for inspection upon request. This condition presents a safety risk due to the potential for electrical overheating and possible fire hazard. In addition, the vehicle has experienced repeated loss of power while driving, which creates a risk in traffic conditions and could impact driver control and safety. The issue has been previously confirmed by the dealership, which replaced the charging port due to thermal damage. However, upon recurrence of similar symptoms, the dealership has refused to diagnose or service the vehicle, preventing further confirmation at this time. The vehicle has been inspected by an authorized dealership on multiple occasions for related issues, including the prior charging system failure. The manufacturer has not directly inspected the vehicle but has been contacted for assistance. Prior to the charging system failure, symptoms included heat at the charging connector and a burning odor. The vehicle has also exhibited electrical system irregularities and repeated loss of power while driving beginning after recall-related service in or around August 2024.

I have had a brake problem since September 2025. The symptom is a hard brake pedal that does not stop the vehicle at low speeds. There is a similar problem with other Wrangler models that do have a recall issued. It was related to a software update around the same time my problem started. I have had it back to the dealer (Hoover CDJR in Summerville, SC) at least 3 times. At the last visit, they said that they acknowledge there is an issue but Stellantis does not know root cause or have a repair. The problem does not cause a diagnostic code. Not being able to stop reliably in low speed situations include dangers in parking lots, my driveway, stop signs and lights. I have been lucky that I have not made contact with another vehicle or pedestrian yet but it has been close a few times. I fear it is a matter of time before the luck runs out.

Vehicle has gone through the 68C update and the car sometimes hesitates in stop and go traffic. Also the vehicle hesitates on acceleration almost causing an accidents more times than I can count.

Driving on the highway smoke came from under the hood in the right hand side forcing my family out on the highway keep ingulfed in flames and burnt to a crisp

The car which is barely driven, suddenly caught on fire while parked in my home driveway after sitting there for close to 8 hours. so the car wasn't in use at the time. It's completely gone.

The engine is overheating at idle speed and there's a phamtom coolant leak. We just bought this in January and are already having major issues. Seems to be a problem with the plastic coolant reservoir being near a very hot engine.