2006 JEEP WRANGLER Complaints

BETWEEN THE SPEED 50 AND 60 MPH WHEN THE BRAKES ARE USED THE WHOLE FRONT END OF THE CAR SHAKES VIOLENTLY. I HAVE HAD 2 NEW SETS OF ROTORS PUT ON THE CAR AND THE ROTORS RE-CUT TWICE, BUT THE PROBLEM STILL EXISTS. *JB

THREE MONTH OLD JEEP WRANGLER WITH 6 SPEED. AFTER VEHICLE HAS BEEN SITTING FOR A FEW HOURS, REGARDLESS OF OUTSIDE TEMPERATURE, THE FIRST SEVERAL 1-2 SHIFTS UPON DRIVING IT AGAIN EXHIBIT A LOUD GRINDING SOUND WHICH CAN ALSO BE FELT THROUGH THE SHIFTER. THE TRANSMISSION IS RELUCTANT TO COME OUT OF FIRST GEAR. IT HAS TO BE PULLED OUT OF GEAR INSTEAD OF JUST SLIDING OUT. IT THEN FEELS LIKE IT BOUNCES OFF OF SECOND GEAR, REQUIRING ANOTHER ATTEMPT TO ENGAGE SECOND. WHEN I FIRST GOT THE VEHICLE, IT ACTUALLY FELT LIKE THERE WAS NO FLUID IN THE TRANSMISSION. SHIFTING BECOMES MUCH SMOOTHER, I.E. NORMAL, ONCE IT HAS BEEN RUN FOR A FEW MILES, ALTHOUGH I DO FEEL IT OCCASIONALLY EVEN AFTER DRIVING FOR A WHILE. DEALER ROAD TESTED THE VEHICLE AND SAYS IT IS "O.K. AT THIS TIME." THIS CONDITION MAY HAVE SOME SAFETY RAMIFICATIONS IN ADDITION TO THE TRANSMISSION LONGEVITY ISSUES. FIRST GEAR IN THIS VEHICLE IS VERY LOW. I ONLY USE IT TO START ROLLING A LITTLE BIT AND THEN QUICKLY TRY TO ENGAGE SECOND. HOWEVER, I AM SO CONSCIOUS OF THE DIFFICULTY OF THIS 1-2 SHIFT THAT I EXECUTE IT VERY SLOWLY, ALL THE WHILE CRINGING AT HE THOUGHT OF THE DAMAGE I AM DOING TO THE TRANSMISSION. THE PROBLEM IS THAT THE RPM'S DROP OFF SO MUCH DURING THE TIME OF THIS SHIFT THAT THERE IS LITTLE POWER AVAILABLE ONCE I ACTUALLY ENGAGE SECOND, RESULTING IN LEISURELY ACCELERATION AT BEST. ON TWO OCCASIONS ALREADY, THE PEOPLE BEHIND ME HAVE BLOWN THEIR HORNS AND NEARLY RUN UP MY BACK BECAUSE, I BELIEVE, THEY MUST HAVE THOUGHT I WAS GOING TO STOP INSTEAD OF CONTINUING TO ACCELERATE. IT IS GETTING TO THE POINT WHERE, IF THE ROAD IS LEVEL, I TAKE OFF USING SECOND GEAR INSTEAD OF FIRST UNTIL I HAVE TRAVELED SEVERAL MILES AND THE TRANSMISSION BEGINS TO BEHAVE NORMALLY. I HAVE DRIVEN MANUAL TRANSMISSIONS FOR 20 YEARS AND HAVE NEVER EXPERIENCED THIS TYPE OF BEHAVIOR. *JB

DT: THE CONTACT STATED WHILE DRIVING IN TALL GRASS THE VEHICLE CAUGHT ON FIRE. UPON INSPECTION THE EXHAUST HEADERS WERE OBSERVED HANGING DOWN TOO LOW. AS A MECHANIC, THE CONTACT RECOMMENDED THAT A PROTECTIVE PLATE BE INSTALL TO COVER THE EXHAUST. THIS VEHICLE IS AN OFF THE ROAD VEHICLE. THE MODEL NAME IS RUBICON. *NM

DT*: THE CONTACT STATED THAT ON 06/01/06 THE VEHICLE'S DASH LIGHTS WENT OUT, WHILE TRAVELING 30 MPH ON A CLEAR NIGHT. THE CONTACT INSPECTED THE FUSE IMMEDIATELY AND TOOK THE VEHICLE TO THE DEALERSHIP TO BE INSPECTED. THE DEALERSHIP DETERMINED THAT THE WHOLE INSTRUMENT CLUSTER WAS DEFECTIVE AND NEEDED TO BE REPLACED HOWEVER THE REPLACEMENT PARTS WOULD NEED TO BE ORDERED. ON 06/21/06, THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR THE REPLACEMENT HOWEVER THE REPLACEMENT INSTRUMENT CLUSTER HAD NOT BEEN ORDERED. THE DEALER ALERTED THE CONTACT THAT THE MANUFACTURER WAS CONDUCTING MORE TESTS ON THE INSTRUMENT CLUSTERS BECAUSE THERE WERE SEVERAL VEHICLES OF THE SAME MODEL WITH THE SAME PROBLEM.

TOOK MY 2006 JEEP WRANGLER SPORT RIGHT-HAND DRIVE TO AN INDEPENDENT SERVICE GARAGE FOR ROUTINE OIL CHANGE AT APPROX. 6900 MILES. THEY TESTED ALL THE LIGHTS AND FOUND THAT BOTH MAIN BRAKE LIGHTS WERE NOT FUNCTIONING, AND NOT DUE TO BULB FAILURE. THE THIRD LIGHT, ABOVE THE SPARE TIRE, WAS WORKING PROPERLY. I TOOK IT TO THE DEALER UNDER WARRANTY, WHERE THEY DETERMINED THE PROBLEM WAS A FAULTY STEERING COLUMN ELECTRICAL STALK SYSTEM ASSEMBLY. NO ACCIDENT OCCURRED, THOUGH SUCH A BRAKE LIGHT FAILURE COULD POTENTIALLY CAUSE A VERY SERIOUS CRASH. THE DEALERSHIP REPLACED THE FAULTY STEERING COLUMN STOCK ASSEMBLY UNDER WARRANTY, AND THE DEFECTIVE PART WAS NOT SAVED. *NM

DT*: THE CONTACT STATED WHILE HITTING A POT HOLE AT 7 MPH THE PASSENGER SIDE SEATBELT ANCHOR CAME LOOSE FROM THE VEHICLE FLOOR. THE DEALER AND MANUFACTURER HAVE NOT BEEN ALERTED AND NO INSPECTIONS HAVE BEEN MADE.

DT*: THE CONTACT STATED A RECALL WAS ISSUED REGARDING THE CLUTCH ASSEMBLY HOWEVER, DAIMLER CHRYSLER HAS NOT PROVIDED A RECALL NOTIFICATION SCHEDULE NOR WILL THEY PROVIDE ANY INFORMATION ABOUT THE RECALL. THE CONTACT IS CONCERNED THE VEHICLE IS HAVING THE PROBLEMS ASSOCIATED WITH THE RECALL BECAUSE THERE IS A LOUD NOISE IN THE LINKAGE WHILE DEPRESSING THE CLUTCH. THE CONTACT HAS PREVIOUSLY OWNED THE SAME MAKE AND MODEL VEHICLE AND HAS NEVER HEARD THE NOISE BEFORE. THE DEALERSHIP AND MANUFACTURER HAVE BEEN ALERTED WHO EXPLAINED THEY HAVE NO INFORMATION ABOUT RECALL, NHTSA 06V147000 CONCERNING THE POWER TRAIN: CLUTCH ASSEMBLY OR DAIMLER CHRYSLER NO. F22. UPDATED 6/19/2006 - *NM

MODEL: 2006 JEEP WRANGLER RUBICON WITH 6 SPEED TRANSMISSION. AFTER BACKING OUT OF A PARKING STALL AND DURING THE TRANSITION FROM REVERSE TO 1ST GEAR THE CLUTCH PEDAL LOST ITS CONNECTION TO THE CLUTCH MECHANISM. THE PEDAL WAS FREE TO SWING WITH NO RESISTANCE AT ALL. THERE WAS A LOUD "POP" FROM UNDER THE DASH. I WAS ABLE TO DRIVE THE VEHICLE TO THE DEALERSHIP BY BY-PASSING THE CLUTCH INTERLOCK SWITCH AND STARTING THE VEHICLE IN GEAR. THE VEHICLE HAD EXACTLY 74 MILES ON THE ODOMETER. THE DEALERSHIP REPAIRED THE VEHICLE UNDER WARRANTY. *NM

NEW JEEP WRANGLER WITH 6-SPEED MANUAL TRANSMISSION GRINDS WHEN OPERATOR UPSHIFTS FROM 1ST TO 2ND GEARS, NECESSITATING AN UNUSUALLY SLOW SHIFT AND CONSEQUENT POOR LOW-SPEED ACCELERATION FROM A STOP. CONDITION IS WORSE WHEN VEHICLE IS COLD AND INTERMITTENT WHEN WARM. TOOK VEHICLE TO DEALERSHIP FOR WARRANTY REPAIRS. JEEP REPRESENTATIVES STATE CONDITION IS "NORMAL" FOR THIS VEHICLE. NO REPAIR PERFORMED. *JB

TOXIC NOXIOUS FUMES EMITTING FROM UNDERNEATH BRAND NEW VEHICLE AFTER PICK UP FROM DEALER. TAKEN TO TWO DIFFERENT DEALERSHIPS AND IT WAS DETERMINED THAT IT WAS THE UNDER COATING THAT WOULD BURN OFF WITH TIME. *JB