2004 JEEP WRANGLER Complaints

WHEN TRAVELING WEST BOUND ON I-10 THROUGH PHOENIX, AFTER HITTING SLIGHT BUMP IN THE HIGHWAY, MY STEERING WHEEL BEGAN TO SHAKE VIOLENTLY FOR APPROXIMATELY 5 TO 10 SECONDS. I IMMEDIATELY BEGAN TO SLOW DOWN AND THE POWERFUL WOBBLE SUBSIDED. I HAD AN ADDITIONAL INCIDENT WITH POWERFUL SHAKING IN MY STEERING WHEEL ABOUT A MONTH LATER, AGAIN TRAVELING AT APPROXIMATELY 50 MPH ON AN INTERSTATE HIGHWAY. THIS SUDDEN AND UNEXPECTED SHAKING OF THE JEEP'S FRONT END IS SCARY.

I HAVE A 2004 WRANGLER RUBICON - ALL STOCK, AND HAVE BEEN EXPERIENCING WHAT I'VE JUST COME TO REALIZE IS THE DEATH WOBBLE FOR THE PAST 8+ MONTHS. I'VE REPLACED ALL 4 TIRES, HAD ALIGNMENT AND BALANCING, JUST TODAY HAD STEERING STABILIZER REPLACED TO NO AVAIL. THE WOBBLING CONTINUED ON THE WAY HOME FROM THE SHOP. ANYTIME I HIT A BUMP, THE FRONT END STARTS TO SHAKE VIOLENTLY AND I HAVE TO SLOW DOWN TO A NEAR STOP BEFORE I CAN PROCEED. THIS IS VERY UNSAFE AND SHOULD BE ADDRESSED BY JEEP. THIS IS MY DAILY RIDE TO WORK AND IT IS NOT SAFE! *TR

BOUGHT A 2004 JEEP WRANGLER OF AUGUST OF 2010. THE JEEP HAD ABOUT 50,000 MILES. ON FEBRUARY 17 I WAS COMING HOME AT ABOUT 52 MPH. WHEN I GOT TO 55 HAD A TERRIBLE WOBBLE IN THE FRONT END. TALKED TO SEVERAL PEOPLE WHO OWN JEEPS AND THEY REFERRED TO IT AS THE DEATH WOBBLE. *TR

FRONT TIRE SHIMMY SO BAD THAT IT CAN CAUSE THE CAR TO GO OUT OF CONTROL. WHEN A BUMP, POTHOLE OR RAILROAD TRACK IS DRIVEN OVER THAT FRONT TIRES WOBBLE AND SHIMMY SO BAD THAT IT IS DIFFICULT TO MAINTAIN CONTROL OF THE CAR. THERE HAVE BEEN NEW TIRES, WHEELS, ALIGNMENTS AND STEERING STABILIZERS INSTALLED BUT THAT HAS NOT STOPPED THE SHIMMY. THE CAR HAS 30,000 MILES ON IT. *TR

2004 JEEP WRANGLER SPORT HAS AN EXTREME VIOLENT SHAKE CAUSING ENTIRE FRONT OF VEHICLE TO BOUNCE OFF THE GROUND AT SPEEDS BETWEEN 45 - 60 MPH. *TR

TL*THE CONTACT OWNS A 2004 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE FRONT END OF THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT PULLED OVER AND THE SHAKING STOPPED, BUT WHEN SHE CONTINUED ON, THE SHAKING BEGAN AGAIN. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE FRONT STEERING BOX, BUSHINGS, AND CONTROL ARMS NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 22,000.

I HAVE A 2004 JEEP WRANGLER COLUMBIA EDITION. I EXPERIENCE THE "DEATH WOBBLE" PHENOMENA THAT OTHERS IN THE COMPLAINT SECTION HAVE POSTED ABOUT. I CAN NOT DRIVE MY VEHICLE BETWEEN 51-60 MPH WITHOUT IT OCCURRING. WHEN IT OCCURS I MUST EITHER QUICKLY ACCELERATE ABOVE THIS RANGE OR SLOW DOWN BELOW IT (DEPENDING ON SPEED LIMIT IN AREA OF COURSE). JEEP DID REPLACE THE STEERING STABILIZER, WHICH FIXED THE PROBLEM, BUT ONLY FOR ABOUT 2-3 WEEKS. JEEP REALLY NEEDS TO RECALL THIS AND APPLY A PERMANENT FIX. THIS IS EXTREMELY DANGEROUS, WHEN IT HAPPENS THE VEHICLE FEELS LIKE THE FRONT TIRES WILL FLY OFF AT ANY MOMENT. I AM ENTERING TODAY'S DATE AS THE INCIDENT DATE AS THIS IS ONGOING, BUT HAS BEEN GOING ON FOR A LONG TIME NOW. *TR

MY 2004 JEEP WRANGLER UNLIMITED HAS 94,000 MILES AND RECENTLY STARTED TO SPILL FUEL DURING REFUELING. WILE PUMPING GAS THE PUMP AUTO SHUT OFF WONT KICK IN . *TR

I HAVE WHAT IS CALLED DEATH WOBBLE IN MY 2004 JEEP WRANGLER. AFTER READING ABOUT THIS PROBLEM IN VARIOUS FORUMS, I BELIEVE IT NEEDS TO BE ADRESSED. I HAVE DONE EVERYTHING THAT HAS BEEN SUGGESTED BY EXPERTS BUT STILL HAVE THE PROBLEM. THE JEEP HAS AROUND 30,000 MILES,AND IT HAS BEEN OFF ROAD,BUT SOME PEOPLE HAVE NOT BEEN OFFROAD AT ALL AND HAVE THE SAME PROBLEM. WITH MILEAGE I DON'T THINK THIS JEEP SHOULD BE CONSIDERED WARNOUT. THE PROBLEM IS STILL ONGOING. *TR

WHILE MOVING ROCKS IN MY YARD, I PUT THE TRANSFER CASE IN LOW AND LOCKED THE AXLES, BOTH FRONT AND REAR. THE FRONT DRIVER SIDE U-JOINT EXPLODED, DAMAGING THE INNER AND OUTER AXLES. THE VEHICLE WAS UNDRIVABLE. I DO FAILURE ASSESSMENT FOR MY WORK AND HAVE DETERMINED INCORRECT HEAT TREATING OF THE CRITICAL DRIVE TRAIN COMPONENTS TO BE SUSPECT. THIS IS SUPPOSE TO BE A HEAVY DUTY VEHICLE. MOVING ROCKS IS HARDLY HEAVY DUTY. THERE ARE ALSO A LOT OF "REPLACEMENT" AXLES AVAILABLE ON THE AFTERMARKET THAT STATE THEY ARE "MORE" HEAVY DUTY THAN STOCK. A NEIGHBOR DOWN THE STREET EXPERIENCED THE SAME FAILURE PRIOR TO ME. MY VEHICLE MISSED THE WARRANTY BY 2,700 MILES BUT IS 2 YEARS UNDER. REPAIRS ARE EXPECTED TO BE $1,000 PLUS LABOR. *TR