2022 KIA CARNIVAL Complaints

When traveling on the highway, the vehicle would not shift into a higher gear limiting the control of the vehicle to accelerate to the flow of traffic. The transmission would not shift for approximately 1/4 of a mile and was stuck at a max speed of ~35 mph and it would not accelerate. This loss of control almost caused an accident and put my family and self at extreme risk. Eventually the vehicle did finally shift gears allowing us to accelerate with the flow of traffic (60mph) This issue with a delay in shifting gears has intermittently happened on prior occasion when accelerating from a full stop, however, this was the first time it happened at an accelerated speed. The vehicle is not safe to operate and was towed to a service center; however, the issue is intermittent and not easily reproducible -- making it even more dangerous as you do not know when it will happen next.

While driving my 2022 Kia Carnival Prestige, the engine started knocking and the vehicle started sounding like it was going to turn off. There was no alert or light on until we got to the service center where the check engine light came on. I took to the nearest dealer with service center for Kia for inspection and repair which the dealer's service center indicated it was an engine failure at 62,203 miles. This failure was hundreds of miles away from my home. I had to return to my state on a rental vehicle. The vehicle remained at the service center for 2 months for engine replacement. Prior to this event, I had serviced the vehicle at my home dealer's service center since I bought it. I performed all maintenance and my home dealer never alerted to an engine trouble before this event. Once I retrieved my vehicle, the vehicle was fine for few weeks and at 66,427 miles the vehicle started having issues with a check engine light on again. I took to my home dealer's service center and after inspection they indicated it was a bad fuel injector. The vehicle became unreliable and unsafe for my regular commute. Once I received the vehicle with the new engine the performance and sound was very different than my old engine had been since I bought the car. I believe the original engine has been faulty since I bought the vehicle.

My front windshield on my 2022 Kia Carnival has shattered in two places from a small hit. I have owned lots of cars and never had a windshield break in two places all the way across. There must be an issue or problem.

The contact owns a 2022 Kia Carnival. The contact stated while driving 50 MPH, the driver's side windshield exterior A-Pillar trim flew off and struck the vehicle behind, almost causing a crash. The contact pulled over to the side of the road temporarily. The vehicle was taken back to the dealer, and the vehicle was inspected. The dealer determined that the trim needed to be replaced; however, the repair was not covered under the bumper-to-bumper warranty. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer. The failure mileage was approximately 22,023.

My car was jerking between 1-2 rpm while driving on the highway, on other roads as well. It was very hard to accelerate and merge with traffic with this issue. Check engine light came on two days later and it’s says it’s the torque converter.

The passenger side sliding door would not respond to any button pushed to open the door. Once I get it manually opened, it will not latch upon closure resulting in a beeping and warning in my dash. I can turn off power doors and manually force it to shut and most of the time that works but this specific incident it was not working. I ensured that there was nothing blocking the door from shutting and finally got it to shut and latch. I drove out of the location I was at and the sliding door flew open at about 20mph.

On [XXX], my kids were getting into the vehicle to go to a playdate. My [XXX] got in the car and into his seat. I was on the driver's side buckling my [XXX] in her car seat and my [XXX] was climbing into the door/her seat on the passenger side. The passenger side sliding door shut on my [XXX] 's hand. I immediately tried to open the door with the button next to the steering column and it would not respond. I then ran around to the other side of the car and used the button on the handle, but the door did not respond to open. I had to manually pull on the handle to force it open off of her hand. No fingers were broken, but the door was shut on her hand completely and she had bruising. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driver side sliding door closed COMPLETELY on daughter's finger causing significant damage and laceration down to the bone. Required extensive laceration repair.

The sensor on the sliding doors failed to detect that my daughter’s hand was in the way. She hit the button to close the door, carefully was getting herself down, and did not get her tiny hand out of the way in time. The door slid closed and latched on my daughter’s thumb. It was stuck in between the drivers door and the sliding door. Attached you will find a photo of her hand and the instant bruising that it caused. It was not just a finger tip. It was her entire thumb that was stuck. I took her to the emergency dept at Children’s Hospital in Pittsburgh, to where she received X-rays. Thankfully her hand was as not fractured or broken. I posted this in my KIA carnival Facebook group and multiple families said that this is happening to their children as well.

I was driving down the highway, and I heard what sounded like a seal breaking. I thought that someone had put one of the windows down on accident. After pulling up on all the buttons, I determined no window was open. When I got out of the car, the plastic molding on the driver side A pillar had flown off. I don’t know if this would have caused damage to another vehicle. I didn’t know until I was several miles down the road what had caused that sound. It does affect my car in that the wind catches in those holes and will push my car around.