2022 KIA CARNIVAL Complaints

The power sliding door on my Kia Carnival has repeatedly failed to reopen when an occupant was caught in the doorway. On multiple occasions, my young child has become trapped by the sliding door after it began closing. Instead of consistently detecting the obstruction and reversing as expected, the door continued to close and pinned my child until an adult intervened. This creates a serious safety hazard because children can become trapped or injured by the power sliding door. The issue has happened several times, making me concerned that the anti-pinch/obstacle detection system is not functioning properly or consistently. The problem appears intermittent but has occurred often enough that I no longer trust the safety feature. The vehicle is available for inspection upon request. I am submitting this complaint because I believe this is a widespread safety defect affecting Kia Carnival sliding doors and understand other owners have reported similar incidents. I am concerned that a child could suffer a serious injury if this defect is not addressed.

The contact owns a 2022 Kia Carnival. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 21V908000 (Latches/Locks/Linkages, Structure); however, the failure persisted. The contact stated that the rear passenger’s side power sliding door failed to latch securely. The contact used force while pushing the rear passenger’s side sliding door from the outside to latch the sliding door properly. The dealer was made aware of the failure and informed the contact that it was unrelated to the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

I am writing to formally complain about the delay in repairing my vehicle under an active recall involving the fuel system/crossover fuel pump. I have been informed that the required part is on backorder and that the repair may not be available until the end of July. My concern is that I am experiencing strong fuel fumes in and around the vehicle. The odor is severe enough that it is causing headaches, and I do not feel it is safe for me or my children to ride in the vehicle. Given that this recall involves a fuel-related component, I am extremely concerned about both the health effects of continued exposure to the fumes and the potential risk of fire. At this time, I do not believe the vehicle is safe to operate. I am requesting that Kia provide an immediate solution, including one or more of the following: A loaner vehicle until the recall repair can be completed; Rental vehicle reimbursement; Expedited repair assistance; or Any other reasonable accommodation that ensures my family's safety.

Fuel leak at pipe connection between the fuel pipe and fuel rail. Nuts securing the high-pressure crossover fuel pipe to the fuel rail loosened, leaking raw fuel, leading to risk of fire. This has been reported and confirmed by Ron Bouchard Kia, of Lancaster, MA, USA. It is a part of Kia Recall SC368 (NHTSA ID: 26V232). We noticed the vehicle was leaking a substance in April 2025. After receiving recall notice in April 2026, we brought the vehicle in to be check on XXX. We were informed on XXX by phone that our vehicle was affected and fell under this recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2022 Kia Carnival, approximately 80,000 miles, had intermittent dashboard warning lights and grinding brake noise for a few weeks. I brought the vehicle to Tasca Kia White Plains first time on 4/14/26 then again on 5/8/26. The dealership initially could not reproduce the issue, then later suspected an ABS sensor issue and ordered the part. On 5/12/26, before the repair was completed, I was driving downhill with my children in the vehicle when the brakes failed to respond properly. I had to steer off the roadway and go over rocks/boulders to stop the vehicle. At that time, the brakes would not respond normally, and I could not immediately shift the vehicle into Park. Police and towing services were involved. The dealership later replaced an ABS sensor. However, when I reviewed the codes with the service manager, I was told the ABS sensor code did not appear on the date of the brake incident. I was also told that an ABS sensor failure itself would not typically cause hydraulic brake failure. I am concerned that the sensor replacement does not explain the brake failure and that this may involve a brake/ABS/electronic stability control safety issue.

The contact owns a 2022 Kia Carnival. The contact received notification of NHTSA Campaign Number: 26V320000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Engine light turns on every couple months. The Kia either stops accelerating and goes into “limp mode” or gives code for misfiring cylinders. Took to dealership several times, they did nothing but reset battery so light goes off. Unsafe when driving my family around and has turned into an unreliable vehicle. SO frustrating for a new vehicle to have these issues.

I am submitting this complaint regarding the failure of the Kia Connect telematics system and the cessation of critical navigation support for my vehicle. Despite opening a formal support case with Kia (Ticket #25923650), the following issues remain unresolved: Loss of Trip History (Since January 2026): The Trip History feature within the Kia Connect suite has been completely non-functional since January 2026. This prevents the tracking of vehicle usage, mileage, and driving behavior data, which are core features of the paid subscription service. Failure of Connected Routing & Software Obsolescence: The "Connected Routing" feature is no longer operational. Kia support has stated this is due to the vehicle requiring a navigation update; however, Kia has ceased providing all navigation and software updates for this model as of April 2025. Safety Concern: The lack of software support and the failure of "Connected Routing" forces the vehicle to rely on navigation data that is nearly a year out of date. This creates a safety risk when the vehicle provides incorrect guidance on one-way streets, closed roads, or altered traffic patterns. Furthermore, the persistent failure of these telematics services raises serious concerns about the reliability of the vehicle's emergency communication systems, such as Automatic Collision Notification and the SOS Emergency Assistance button, which utilize the same underlying cellular module and software framework. Corrective Action Requested: I am seeking a mandatory software update from Kia that restores full functionality to the Kia Connect suite (specifically Trip History and Connected Routing) or a final navigation map update to ensure the vehicle’s guidance systems remain safe and accurate for the remainder of the service's lifecycle.

My engine smells like fire and fuel my can will not start or do anything. There was smoke coming out of it. The van has had several issues since buying it. Now it’s completely disabled I heard a popping noise as I was driving and then it died and has not started since.

The driver side passenger door will open by itself when the key fob is near. Today it injured me while pumping gas and almost knocked the gas tank door off and gas pump out. I locked my vehicle to go inside to pay for gas. When I came back to my car to open the gas tank door and inserted the gas pump, the sliding door opened and smashed my wrist in between it and the gas tank cover door. It almost knocked the tank door off but I was able to keep fighting it and pushing it back and it closed. I have deep indents in my wrist and it scuffed the gas tank cover. The sliding doors do not stop when someone is going in or out. It is a safety hazard and should function like a garage door. Stop when it senses something there. I almost lost my wrist today!!!