2024 KIA CARNIVAL Complaints

I was cleaning my van and my 2 year old daughter closed the opposite door and the sensors did not stop the door and she got her fingers smashed into the door and potentially broke her fingers, took her to the ER and we are to repeat X-rays in 7 to 10 days.

On 8/25/2026 I dropped the vehicle at Plaza Kia, 2699 Nostrand Ave, Brooklyn, NY 11210 (Kia Repair Facility #7119189) for four open recalls: PI2501, PI2602, SC320, and SC368. Brakes were functioning normally at drop-off. Per repair order [XXX] dated 8/26/2026, only PI2501 and PI2602 (second-row seat recalls) were performed; SC320 (EGR valve) and SC368 (high-pressure crossover fuel pipe) were not completed — parts on special order. The dealer's multi-point inspection sheet, printed 8/26/2026 12:36 PM, marked brake fluid level/condition and brake system components as OK/green. The technician time log on the RO shows 0.0 actual hours for that day. The brake lining inspection panels on the sheet are blank. The dealer returned the vehicle to my residence via valet on 8/26/2026. On first use, the brake pedal was extremely hard and stiff with the engine running; the vehicle would only slow with full-force pedal pressure. I nearly collided with a parked vehicle exiting the parking space. I parked and did not drive it further. A vacuum-assist test (pump pedal engine off, hold, start engine) showed the pedal sinking only slightly, and braking under drive felt like engine-off braking — partial or total loss of power assist. Kia Roadside Assistance towed the vehicle to Plaza Kia. Plaza Kia refused to tow it themselves. Plaza Kia has since diagnosed a brake master cylinder failure and stated parts are approximately two weeks out. Repair is under warranty; updated RO pending. Kia Consumer Affairs case #[XXX] has been opened. Summary: brake power-assist failure on a 2024 Carnival at ~33,000 miles, occurring in dealer custody or immediately upon return from recall service, on the same day the dealer's inspection cleared the brake system. No prior brake symptoms. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

For the past year I have taken my vechicle in due to a strong vinegar smell that comes from the AC in the summer upon start up. They have been unable to remedy this issue. However they have said there is mold in the system. This posses a health issue due to poor air quality especially for small children in the vehicle.

On our 2024 KIA Carnival, which my wife is the primary driver, the blind spot warning on the passenger side does not work all the time. Driver side is 100% okay. She drives on I40 and hwy111 to and from work daily, and when passing on the left, she looks for the red triangle to let her know it is clear to get back in the right lane. It only works about 50% of the time and the dealership has worked on it three times unsuccessfully, so we put in a complaint to KIA corporate in June and they have been very unresponsive. We keep the vehicle clean, so it is not that. She just wants it to be reliable for safety reasons and it is not. It probably just takes a different set of engineering eyes to look at it but KIA seems like a dead end so far. Please help us. Thanks. BTW, the people at the dealership have been very good to us, we just believe engineers at a higher level need to solve this problem.

Recall SC368 was performed. After the recall repair, I began smelling gasoline. The dealer has diagnosed a separate fuel-system issue requiring multiple parts including replacement of the fuel tank. More details: My vehicle underwent a safety recall for a fuel leak/fire risk. Following that repair, I developed a strong gasoline odor. My Kia dealer has now identified a separate fuel-system problem that requires replacement of multiple components, including the fuel tank. The dealer has informed me that multiple Carnivals in Arizona are experiencing the same problem and that a replacement fuel tank is currently unavailable nationwide. I do not have a repair date and I do not consider the vehicle safe to drive.

This specific van has 2 open recalls already: 1 on a rear seat issue and 1 on a fuel pipe issue which is why i submitted to KIA dealer in the first place after smelling gas inside the cabin of my car while driving for 3 days until the dealer opened. While at the dealer they found a manufacture defect of the gas tank expanding in the heat and releasing liquid fuel into the charcoal cannister meant to catch fumes. The fumes then go into the cabin of the car and smell and make passengers sick as well as create a fire safety hazard on the vehicle. After discovering this they have informed me that the parts for this defect as well as the fuel pipe recall are on national backorder and the solution was to siphon off 1/4 tank of brand new gas and told me not to fill past 3/4 fulls or smoke in the vehicle and they THINK it SHOULD be fine. Google disagrees with this and says once the cannister has had liquid fuel in it, it can cause more problems. They have no loaners to offer as there are too many KIA recalls and they have no ETA on the parts coming in. I have been offered no solutions that are safe besides hold on to the vehicle and maybe it will be ok.

Incident description: While driving, the vehicle’s dashboard illuminated all warning lights (ABS, traction control, battery, check engine, forward safety system) and the engine revved to approximately 8,000 RPM with unintended rapid acceleration. Driver had to apply hard braking to maintain control and avoid a collision. A nearly identical event occurred approximately one month earlier while driving on the highway, at which point the vehicle suddenly braked hard on its own. The vehicle has been at the dealership for repair a combined 38 days across two visits. The dealer initially attributed the first event to a failed alternator voltage regulator, replaced it, but the same warning codes and behavior returned on the second occasion. Crash/injury: No collision occurred; avoided through evasive braking. Speed: Highway speed (both instances). Incident description: While driving, the vehicle’s dashboard illuminated all warning lights (ABS, traction control, battery, check engine, forward safety system) and the engine revved to approximately 8,000 RPM with unintended rapid acceleration. Driver had to apply hard braking to maintain control and avoid a collision. A nearly identical event occurred approximately one month earlier while driving on the highway, at which point the vehicle suddenly braked hard on its own. The vehicle has been at the dealership for repair a combined 38 days across two visits. The dealer initially attributed the first event to a failed alternator voltage regulator, replaced it, but the same warning codes and behavior returned on the second occasion. Crash/injury: No collision occurred; avoided through evasive braking. Speed: Highway speed (both instances).

While stopped, the brake pedal drops to the floor and the vehicle begins to roll forward. I went to the dealership and told them what happened, they told me there is no recall on this, and it is a "normal part of driving". This is not a normal part of any braking system. The pedal should not drop to the floor while stopped with your foot on the pedal. No warning system lights that came on. This happens frequently. You have to start pumping the brake repeatedly to get the vehicle to stop. It will eventually raise off the floor.

The contact owns a 2024 Kia Carnival. The contact stated that while her husband was loading the child into the car seat. The rear button for the door was depressed by the child. The husband became stuck in between the sliding doors. No warning lights were illuminated. The contact sustained injuries to his previously injured rotary cuff, but medical attention was not provided. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 35,815.

Our 2024 Carnival has had a recurring engine oil leak that has required the vehicle to be left at the dealership 4 times for the same issue. Each time we get the van back the repair lasts about 1-3 weeks (depending on how often it's driven). Oil continues to leak from the engine area, creating risk of engine damage or a potential fire hazard if oil contacts hot components. The issue has not been resolved despite repeated repair attempts under warranty. The Carnival has 38,092 miles on it, and has been in the repair shop over 4 times. The 1st time it was put in the shop the van has 34,420 miles on it. Each time it has been left at the dealership for 9 - 17 days while the repairs were made. We have brought it to the same dealership each time and they have been very sympathetic and helpful. Not only does this issue cause the risks mentioned above, but it has ruined the concrete in my garage as well as added oil to the roadway which could cause an accident. I have all the repair orders from the first 3 repairs that I will attach. However I do not have thee current one because the vehicle is currently being repaired for the 4th time and I haven't received the finalized repair order documents. I can update this claim once the repairs are completed. I will be contacting Kia tomorrow and wanted to have a claim number started.