2022 KIA NIRO Complaints

I park the car, lock it and then later on can’t open it. I use the emergency key to enter it but then can’t start it even with a new battery in the key fob. It happened twice. It is an issue that needs to be fixed as soon as possible because in case of emergency you’re stuck outside your car and can’t use it to escape a danger or respond to an emergency. You’re a sitting duck in the open, going nowhere.

2022 Kia Niro EX Premium Hybrid was sold as Kia Certified Pre-Owned on August 12 2026 with an active check engine light present at time of purchase. Dealer Calavan Kia West in Lithia Springs GA represented the vehicle as passing a 165-point CPO inspection. Dealer attributed the light to a gas cap issue and cleared the code to complete the sale. Six days later approximately August 18 2026 the check engine light returned. Dealer attempted one repair which failed. As of August 25 2026 the defect remains active and undiagnosed. On a hybrid vehicle an undiagnosed engine or propulsion system fault represents a potential safety concern. The CPO certification process failed to identify this defect prior to sale.”

The contact owns a 2022 Kia Niro. The contact stated that while his wife was driving at various speeds, the vehicle made an abnormally loud grinding sound. The vehicle was taken to an independent mechanic, and the brake pads and rotors were replaced. While replacing the brake pads and rotors, the mechanic became aware that the parking brake cable housing was at an improper angle on the rear wheels, causing friction to damage the parking brake housing and exterior rubber. The mechanic determined that the parking brake cable assembly needed to be replaced. The vehicle had not received any additional repairs. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000.

Component or system that failed: High-Voltage Electrical System / High-Voltage Battery Safety Plug Assembly (specifically covered under Recall SC314 / NHTSA Campaign 24V-358). It is NOT wear and tear as falsely claimed by the dealer. The vehicle is available for inspection upon request at the owner's residence. How safety was put at risk: The vehicle triggers an active "Check EV System" master warning while driving, creating a severe risk of sudden loss of motive power (stalling) on public roads. The high-voltage charging system is also completely disabled, leaving an elderly driver stranded without transportation. Has the problem been reproduced or confirmed by a dealer?: Yes. Rick Case Kia (Duluth, GA) inspected the vehicle from July 20–22, 2026. Instead of resolving the recall defect at $0.00, they falsely mischaracterized the electrical failure as "wear and tear / customer declined repair" and demanded $1,617 out-of-pocket before releasing the unsafe vehicle. Has the vehicle/component been inspected by others?: Inspected by [XXX] Case Kia service department. Opened active corporate case with Kia America (Case #XXX). Independent mechanics have confirmed this is not simple “wear and tear”, but deeper electrical issues that were touched during the recall. Warning lamps, messages, or symptoms: "Check EV System" master warning light and total failure of the high-voltage charging port. Symptoms first appeared shortly after initial Recall SC314 service was performed on June 15, 2026, and worsened prior to returning the car on XXX. Kia claims to have completed Recall SC314 on June 15, 2026. However, the recall work directly triggered immediate secondary failures in the high-voltage charging system. The dealership is now attempting to evade liability for recall-induced damage by labeling it 'wear and tear' and demanding $1,617 to fix a failure caused by their own recall service. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Kia Niro. The contact stated that a hardwired kill switch was installed in the vehicle, and the switch overheated to the point that the vehicle was unable to operate. An investigation was conducted by the contact, who touched a big box underneath the dashboard. The contact's hand was burned on the fingertips because the box was extremely hot. Water was run over the hand by the contact to heal the injuries, but outside medical attention was not sought. The dealer was notified of the failure and a callback was promised. A diagnostic test and the repair were not yet performed. The manufacturer was not made aware of the failure. The failure mileage was approximately 92,000.

COMPONENT/SYSTEM: The 12-volt auxiliary battery system, the interior fuse box (Total Integrated Power Module) containing an auto-cutoff relay, and the high voltage battery system. All components are available for inspection. SAFETY RISK: The vehicle has lost power and died while being driven, and has left occupants stranded on multiple occasions. A sudden loss of motive power in traffic creates a serious risk of collision to occupants and to other motorists. The vehicle has failed to start dozens of times. FAILURE DESCRIPTION: The 12-volt battery in my 2022 Kia Niro EV has repeatedly discharged, leaving the vehicle dead and unable to start. ~Six 12V batteries have been installed between January 2025 and February 2026, between 60,431 and 77,130 miles. CONFIRMED BY DEALER: Yes. The condition has been reproduced and documented by the dealer across five separate repair orders. On 1/21/2025 at 60,431 miles, the technician found the 12V battery completely dead after sitting, jump-started the vehicle, and reported no abnormal draw on the electrical system. On 11/05/2025 at 74,355 miles the vehicle again required a jump start to be brought into the shop; the battery was replaced, and the technician reported the vehicle was operating as designed. On 1/22/2026 at 77,124 miles, a technician performed a parasitic draw test and measured 0.185 amps, exceeding the specification of below 50 milliamps by approximately 3.7 times. The technician documented that the auto-cutoff relay was remaining closed, continuously supplying current to 21 modules, and that the interior fuse box required replacement at a quoted cost of $2,048.48. This defect was present during the two prior visits but was not identified. On 2/13/2026 at 77,130 miles, the vehicle would not start when we came to pick up the car. The shop had to provide a loaner, and then another battery was installed, and the TIPM was replaced.

The contact owns a 2022 Kia Niro. The contact stated that while driving from a complete stop at 5 MPH, the vehicle was T-boned on the passenger's side by a Jeep Grand Cherokee driving at high speed. Due to the impact, the contact's head struck the dashboard. The other vehicle fled the scene of the crash. The airbag deployed on the passenger side but did not deploy on the driver's side. No warning light illuminated. There was no reported fire. A police report was filed. The vehicle was towed to a tow lot, where the contact was informed that the vehicle would be destroyed. The contact sustained an eye and face injury, body aches, and a detached ear. Medical attention was received at the hospital, where the contact was stabilized and referred to the Primary Care Physician for future care. The contact called both an unknown local dealer and an independent mechanic, but there was no response. The manufacturer was not contacted. The contact called the auto finance company and was referred to the insurance company. The failure mileage was unknown.

Problem 1, Check Engine Light: I purchased the used car on Jan 9 2025, around 23,400 miles from Kia Dealership, capitol Expy in San Jose. Today 05/27/2026, the odometer reads 26, 407 miles. My car is used only twice a week - 20 miles on Fridays, 12 miles on Wednesdays. My car has less than minimum wear and tear and is barely used. I completed my 25K service after Thanksgiving in Nov 2025. I have not even driven 1500 miles and the car is back in for service. Prior to this, within a month of purchasing my car Kia replaced the battery in my car. Around Mar 15, 2026, the Check Engine Light displayed. I called the Kia Dealership on Capitol Expy in San Jose 3-4 times, but they Kia dealership don't call back. On 05/15/2026, for the first time I drove about 50 miles return trip. While driving North on I-280 from [XXX] to [XXX] , over rolling hills that had some incline, the Check Engine Light came on.I scheduled service. I experienced that the vehicle struggle to climb the incline of rolling hills, after the battery charge was exhausted and the engine was running only on gas. The gas was 3/4 full. This is a safety hazard for me to be interrupted by Check Engine Light twice while driving and that too when my car has not even completed 30K miles. My car is sin Service on 05/26/2026 and in the shop for 3 days diagnosis. The Kia Dealership has yet to determine the problem. I have had to rent my own rental car even though I purchased Extended Warranty on the car. Problem 2, Blind Spot Warning Light on right side mirror: On 05/13/2026 and on 05/22/2026, the Blind Spot warning light on right side mirror does not display oncoming traffic when my car is parallel to the lane markings. On 05/13/2026, I was driving at 30mph and on 05/22/2026 I was stationary in the center divider. In both instances, the passing driver had to honk at me really loud -- to avert an accident. Both problems are severe safety hazards. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Kia Niro. The contact stated while driving at an undisclosed speed, the vehicle intermittently entered limp mode and loss automotive power while the vehicle was still at full battery. No warning lights were illuminated. The failure occurred on several different occasions. The vehicle was taken to a dealer to get a diagnosis however, the dealer stated that the failure was not duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 36,000.

am writing to formally request assistance regarding my Kia vehicle which I purchased used at approximately 38,000 miles. Shortly after purchase, the vehicle became undrivable and has since required repeated repairs without resolution. To date, the vehicle has been presented for repair on six separate occasions for the same issue and has remained out of service for a significant period of time. Based on these repeated failures and lack of resolution, the vehicle may reasonably be considered defective at this point. Despite being unable to use the vehicle, I have continued to make monthly payments, resulting in considerable financial hardship. In an effort to resolve this matter, I consulted with a Maryland MVA investigator, who advised me to contact Kia directly and report that the vehicle appears to have been sold with a pre-existing defect. I have also communicated with the selling dealership, Eastern Motors; however, I was informed that due to changes in management, they are unable to provide further assistance and consider the matter outside of their control. Additionally, I have previously reached out regarding this issue and have not received a response. Given the timing of the failure, the repeated unsuccessful repair attempts, and the extended period the vehicle has been out of service, I respectfully request that Kia conduct a thorough review of this matter. I am respectfully requesting Kia’s assistance in resolving this matter. Specifically, I would like to explore options such as a replacement vehicle, repurchase (buyback), reimbursement of payments made, or other goodwill support. I remain open to a fair and reasonable resolution. Please advise what documentation or additional information is required to proceed. I am prepared to provide all relevant records, including purchase documentation and complete service history. Thank you for your prompt attention to this matter. I look forward to your response.