2023 KIA NIRO Complaints

My 2023 Kia Niro Hybrid has a recurring intermittent electrical defect. Warnings appear together: Check Hybrid System, Check Engine, Forward Collision, Rear Cross-Traffic, Lane Keeping, Driver Attention, ESC, Brake, Auto Hold. They appear and persist while driving, during which stability control, automatic emergency braking, lane keeping, and related safety assists are disabled. Once, the vehicle would not start and was temporarily disabled, recovering after several minutes. This creates risk from loss of all electronic safety assists in traffic and from the vehicle failing to start when needed. Stored codes show lost CAN communication among multiple modules: U0101, C1611, C1693, U0111, U0164, U0293, U042B, U1341. Confirmed by two Kia dealerships over five warranty visits. V1–2 (Coughlin Kia, Dublin OH): software updates; warnings returned. V3 (Ricart Kia, Columbus OH): inspected, released OK; warnings returned. V4 (Ricart): Kia Techline case [XXX] opened; CAN signal confirmed out of spec at a passenger kick panel connector; dash harness replaced per Techline under warranty (~$2,800). V5 (current): same warnings returned within days, confirmed by the dealership; vehicle is in the dealer's possession for continued diagnosis and available for inspection. Warnings first appeared June 2026 at ~58,500 miles, recurring since. Current mileage ~59,700. No crash or injury. Kia Consumer Affairs case open. Note: attached RO [XXX] says no issues found after repair — outdated; warnings returned within days, vehicle back at dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When stopping for a traffic sign or light, the car announces that it is shifting into park and does so. The car then will not shift into drive or reverse and is essentially disabled. Turning off the car completely and turning it back on will not return it to "Ready to Drive" mode. Jump starting the car, provided it is jump started twice, will clear the problem and move the car to "Ready to Drive" mode. The car has been towed to dealers on three occasions with the technicians reporting they cannot reproduce the problem and no codes are being logged. On the third occasion, the dealer replaced the 12-volt battery. The failure occurred on the dealer's lot when I arrived to retrieve my car, but the technician reported that the problem went away and no codes were logged, so I should leave with my car. Subsequent to the battery replacement and including the failure on the dealer's lot, the problem has occurred 6 times in 7 days. Prior to the 12v battery replacement, the problem occurred once every 4 to six weeks. The problem has occurred a total of 9 times between April 25th and August 31st, 2026. This is an extremely dangerous problem as failures occur in traffic and require police assistance to safely tow or jump start the car. Should this failure occur during a left turn or on a highway, the outcome could be catastrophic. The car is available for inspection upon request. There are no warning lamps, messages or other symptoms of the problem prior to the failure other than the announcement that the parking brake is being automatically engaged. I have opened a case with KIA Customer Care.

After sitting 2 weeks at airport parking. 12 volt Battery dead . Unsafe to repeatedly have to take out emergency key and pull handle cover off and get in car hit 12v button to start. The dealer we took it to refuses to replace the 12 volt integrated battery. It has happened multiple times. They checked battery and said it was okay. Repeated having to push 12 volt button unacceptable and unsafe.

My 2023 Kia Niro Hybrid EX has experienced multiple warning messages and unresolved concerns after previous repairs. After the first recall repair, I began receiving intermittent warning messages while driving. The messages appeared briefly and disappeared before I could safely document them. After a second repair, the transmission was replaced. Shortly afterward, the vehicle displayed an overheating warning. I returned to the dealership, but they stated they could not find a problem. While traveling out of state, on July 6, 2026, the vehicle displayed warnings indicating that the 12V battery needed to be charged. On July 8, 2026, the vehicle would turn on, but the engine would not start or operate. Multiple attempts to jump-start the vehicle failed, including using a portable jump pack, another vehicle, and assistance from a tow truck driver. The vehicle displayed warnings stating that the 12V battery needed charging, the battery was draining, and that the hybrid system needed to be checked. Because the vehicle could not be operated and I was stranded away from home, I am concerned about the reliability and safety of the vehicle. The vehicle has undergone multiple repairs, including a transmission replacement, but I continue to experience warning messages and a loss of confidence in the vehicle's ability to operate reliably. I am requesting that this issue be reviewed for possible safety concerns.

There's a problem with the horn in my car. Either the high or low. The problem is intermittent and the horn will fail and it is not available in emergency situations. I brought this to the dealership and made them aware but they refuse to take this seriously and two adequately evaluate the car. They blew the horn and said it was working. It was not working and I said it was intermittent and they said well we could not find any problem. There were no warning lights. Nothing else. The horn is just intermittently failing.

The contact owns a 2023 Kia Niro. The contact stated that while her husband was driving at 40 MPH, the vehicle hydroplaned and pulled to the left unexpectedly. The contact initially contacted the dealer and was informed of the headlamp replacement and general inspection. Additionally, while the contact's husband was driving, the driver-side front tire experienced a blowout near a service station; the technician advised that the tire exhibited steel tread. An independent mechanic attempted a wheel alignment but discovered a rusted, bent tie rod, preventing the service. Following dealer instructions, the vehicle was towed to the dealer, where the wheels, both hub bearings, tie rods, and brake calipers were replaced. Despite the repairs, the owner refused to reclaim the vehicle due to the recurring mechanical defects. The manufacturer was not notified of the failure. The failure mileage was approximately 71,000.

Check electric vehicle system warning light indicator illuminates and car stops driving on highway! A/C and defrost won't work properly and when turned on causes the above warning light and malfunction. Car will not charge at "fast" charging stations and will leave you stranded on highway. I live in [XXX] and the vehicle only does it when humidity is high outside. Issue also causes problems with the 12V battery. SEVERE SAFETY ISSUE WHEN CAR SHUTS DOWN IN THE MIDDLE OF THE HIGHWAY DRIVING AT ANY SPEED. It is the system ICCU (Integrate Charge Control Unit) that KIA has a limited warranty coverage on and should be reviewed for recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car seat lower hip straps frayed on both sides. Had we been in an accident I have no doubt the strap would have ripped. I have 3 personal friends who checked their same Evenflo Revolve 350 car seat to find fraying in the exact same spots. And dozens of posts online with pictures showing the exact issues as well. The integrity of that straps in these seats are obviously compromised for so many people to be having them fray in the exact location. Evenflo is telling us all it's due to "external factors such as a mouse" but it would not all be the same car seat it happens to, in the exact same place on the seat, to people who drive their vehicles daily and have no other wings of rodents in their vehicle or issues with the other car seats installed in the vehicle.Baby/children's car seat safety is SO important and the strength of these straps needs investigated before someone is in a crash and their child's harness rips! Uploading my own personal photos-but I have many screenshots of pictures and posts from others having the same issue that I can provide upon request.

The contact owns a 2023 Kia Niro. The contact stated that while driving at 25 MPH, the vehicle independently accelerated. The contact constantly depressed the brake pedal to stop the vehicle. The contact was able to coast the vehicle to the residence while depressing the brake pedal to prevent the unintended acceleration. Neither a dealer nor an independent mechanic was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 11,000.

The vehicle is a rental vehicle. It experienced two incidents of sudden loss of propulsion within the first two days of operation. During both events, the vehicle became completely unresponsive to accelerator pedal input and would not move despite being placed in Drive. I attempted to shift the vehicle into Park and then back into Drive, but propulsion was not restored. No warning lights, malfunction indicators, or system messages were displayed before or during the failure. The first incident occurred while exiting a car wash. The vehicle became immobilized in an active traffic lane and would not respond to throttle input, creating an immediate risk of rear-end collision. Vehicles were approaching from behind and I narrowly avoided being struck. The second incident occurred later the same day in a parking lot while the vehicle was charging. Again, the vehicle became unresponsive without warning and would not move. The intermittent and unpredictable loss of motive power presents a serious safety hazard because it prevents the driver from maintaining control and safely operating the vehicle in traffic conditions.