2013 KIA OPTIMA Complaints

The contact owns a 2013 Kia Optima. The contact stated that while driving 70 MPH, the speedometer started malfunctioning, and the check engine warning light was flashing. There was an abnormal burning odor, and there was smoke coming from under the hood. The contact pulled over to the side of the road and allowed the vehicle to cool down for an hour. While attempting to restart the vehicle, several unknown warning lights were flashing, and the vehicle failed to restart. The contact was picked up by her daughter, and the vehicle was later towed to the dealer to be diagnosed. The dealer later informed the contact that the warning lights had turned off. Additionally, the dealer informed the contact that the tires, the oil, and the oil filter needed to be replaced. The contact declined to pay for the parts replacement because the oil and the oil filter had been replaced two weeks prior to the failure. The dealer informed the contact that the vehicle was ready for pick up. The contact stated that after a family member picked up the vehicle, the failure recurred while driving, and the vehicle stalled. The driver was able to pull into a parking lot. The contact stated that the dealer had informed them that an arrangement had been made for the vehicle to be towed to their location; however, no further update was provided. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The manufacturer was not notified of the failure. The failure mileage was approximately 300,000.

The engine on my 2013 Kia Optima (VIN [XXX] ) failed catastrophically less than one mile after purchase. This vehicle is subject to Kia Safety Recall SC147, which addresses a manufacturing defect involving engine bearing wear caused by factory machining debris and identifies engine replacement as the remedy when failure occurs. A Kia dealership inspected the vehicle and confirmed the failure was denied under warranty. I then requested that the dealership pursue recall compliance under Safety Recall SC147. After consultation with Kia Techline and a Kia service representative, the dealership declined to submit or pursue recall compliance for this engine failure. I am submitting this complaint for recall non-compliance and request that this matter be reviewed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2013 Kia Optima SXL experienced engine knock and shutdown after completion of recall SC147 (KSDS software update). The recall did not repair the known Theta II rod bearing defect and now the engine is failing as detected by the software. Kia corporate and Kia of Merced (Merced, CA) are refusing repair, citing auction purchase and PI1803, despite the engine being covered under the Theta II engine warranty extension. The vehicle is unsafe to operate and shuts down unexpectedly.

The contact owns a 2013 Kia Optima. The contact stated that while driving approximately 30–35 MPH, the engine started knocking. The check engine warning light illuminated once the knock started in the engine. The vehicle was not repaired. The vehicle was driven to the dealer. The contact stated that there was an open recall associated with the VIN; however, the dealer declined to repair the vehicle because the engine was knocking. The manufacturer was made aware of the failure. The failure mileage was approximately 88,000.

The engine began exhibiting symptoms consistent with the known bearing wear defect covered under the manufacturer’s safety recall, including knocking noises, loss of power, and engine malfunction. The condition worsened to the point that the vehicle became unsafe to operate due to the risk of engine seizure and sudden loss of propulsion while driving. The vehicle was inspected by a Kia dealership, which confirmed engine damage consistent with the recall defect. The engine remains available for inspection. Despite an active, unrepaired safety recall for engine bearing wear that increases the risk of engine seizure and crash, the manufacturer and dealership have refused to perform the recall remedy unless the owner first replaces the engine at personal expense. The manufacturer has stated that the recall cannot be performed due to the current condition of the engine. This refusal leaves the vehicle with an open safety recall and no manufacturer-provided remedy, creating an ongoing safety risk due to potential engine seizure and loss of power while driving.

Steering flexible coupler worn in the Motor Driven Power Steering (MDPS) syste causing clicking noise and jittery steering

Bushing related to steering wheel was a safety issue that causes steering wheel play and possible loss of control. I was never informed of the issue and Kia said it would not repair it since the warranty expired.

My 2013 Kia Optima caught fire while my [XXX] son and his friends were driving it. The car burnt up. Some truck drivers flagged my son down to let him know the car was on fire. They could have been killed if it wasn’t for the truck drivers warning him that the car was on fire while driving down the highway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Steering wheel very loose, crackling noise and shaking going over bumps or uneven roads.

My vehicle has the factory Snow White pearl paint. It is always parked in a garage. Since may 2025 the paint has been bubbling and cracking causing it to peel completely off of the car.