2016 KIA OPTIMA Complaints

The body paint is cracking and falling down. Since five years ago this problem started.

All window regulators failed before 100K miles. This does not allow for windows to open in case of emergency, This problem has been personally confirmed by dealer and also in service bulletin SA418. This is a common problem in this car make/model/year. This component has been known to the manufacturer for defect. No warning lights, just instant lack of window use.

Engine sludge and failure. Engine part failure p0010 began happening within 1 year of Kia engine replacement. It is available for inspection. This creates a problem with acceleration in the vehicle, putting my family's and my safety at risk. This problem has been confirmed by the dealer. The check engine light is one. This part failure and engine sludge (despite consistent maintenance) has caused engine failure again, just 3 years after replacement.

I have a 2016 KIA Optima SX Turbo with 33,500 miles that the windows one by one are failing due to a defective regulator drum gear. This very flimsy gear fails and the window will not roll up. I have had 3 out of 4 fail in the last month. The only way to keep the window up is to shimmy them. This creates a huge safety risk in the event of an accident and also can impact the collision safety system including airbags. KIA is aware of this situation as outlined in their Technical Service Bulletin dated March 2021. I believe it's bulletin MC-10189544-0011. I've contacted the dealer who doesn't think there is a recall on this issue. This issue creates a safety issue that after only 33,500 miles should not exist.

The car is burning oil rapidly causing potential issues with the transmission and engine. The oil burns and does not leak after a few hundred miles and has to be refilled continuously causing alot of money and potential issues with other components of the car. I notice jerking when accelerating and smoke if dont fill every 1 to 2 weeks.

In 2024 the window regulator went in the drivers side back window costing me $700 and on 9/22/2025 the drivers side front window regulator just went costing me another $700. I see many are having this issue but no recall

The headlights and brake lights have been VERY dim for a while. I've had to replace both headlights and brake lights an excessive amount in the last several years. This year alone since December 2024, I've had to replace my headlights 3 separate times. I do not drive more than 10,000 miles per year, or use my vehicle on roads that would lead me to believe the issue is from road conditions.

Window regulator assembly failed twice within 20k miles. Attached is the first repair. Dealership only repaired motor but not full assembly and it failed again.

Engine Is knocking that happened when I took my car 3 times to emission test and my car didn't pass after that I took it to my mechanic for the diagnostic and he told me you have to take it to kia dealer but I was shocked the way how they treated me and they completely refuse to replace my engine they came up with too many excuses and I have recall repair active I have right to fix my car but they didn't with bad attitude

Engine began jumping during driving and loss power. No dashboard illumination warning lights and the temperature gage showed normal operating temperature. Car was not accelerating properly. Had to maneuver carefully to prevent being ran over. Engine light illuminated showing misfire. Replaced ignition coil pack and spark plugs. Driving again, car stalled. No dashboard warning lights. No high temperature on gauge. Narrowly missed being hit by a semi as there was absolutely no warning and we were on an Interstate bypass ramp with nowhere to pull over!! Towed car to dealership for diagnosis. Results: engine blown, turbos gone, and the catalytic converter is holding oil. Dealer is stating this is not covered under the extended warranty from Kia as its not connector rod bearing issues and that the piston rings failed. However, they stated the turbos got "too hot" and they failed. The gauges have never shown that the car was running hot. I have a sworn statement from my mechanic stating this is absurd and a valiant attempt to not pay for what would be the second warranty replacement of my engine. The piston rings failed as a result of the connector rod bearing failure. The "too hot" temperature that damaged the turbos was likely caused by the same bearing issue. The heat from the bearings unseated the piston rings and allowed the engine to dump its oil causing the engine to fail. I highly recommend that you open an investigation into these issues. The car not accelerating and losing power at interstate speeds is a very serious and dangerous issue.