2016 KIA OPTIMA Complaints

Vehicle was purchased in 2023. AC blower failure occurred for the first time in June 2024 and was repaired by PepBoys. On 4/2/2025 the ve3hicle had an active recall event when the engine seized on the highway because of a faulty oil pump/filter, Engine was replaced 4/17/2025 under that recall. Kia advised at the time that the wiring harness should be replaced due to electrical issues at the time but said that there was no recall for that work. At the time, there were no electrical failures of steering, brakes, all power etc. Nor did we know that those were a possibility. The wiring harness quote was $7,000, over the cost of the vehicle. It was decided to continue repairing the electrical issues as they came up, it was assumed that the fuses would blow before there because a safety or total vehicle failure, as automobiles are designed that way. 8/4/2026 the vehicle experienced a complete and total loss of power resulting in a traffic crash into another vehicle as the brakes felt like you were trying to push a wall rather than a pedal. There was minimal physical damage to the other car and the kia, the other driver got my husband's insurance information and then drove off. The car did startup after ~30 minutes or so and was driven home, but taken to the Kia dealership the next day. It was said that the blower motor overheated and melted a portion of the electrical junction box under the hood and that it was unsafe and dangerous to drive. Kia said that there were no active recalls for this work. NHTSA SC351 seems very similar to this issue that has plagued this car since the beginning. We would ask that Kia incorporate this vehicle and others outside of the year/model ranges in SC351 that have similar failure mechanisms as this seems common.

While driving at highway speeds on the freeway in San Diego, the engine of my 2016 Kia Optima catastrophically seized without warning. I instantly lost all power steering, brake assist, and electrical power, creating an immediate life-threatening emergency. The vehicle was towed to a Kia dealer. Corporate Techline and the dealership are refusing to perform the mandated settlement rod bearing test and are falsifying paperwork to deny the safety remedy.

Blower motor is drawing excessive electricity, which in turn burns the fuse and junction pin, which in turn can start a fire in the car. Kia of Irvine suggested redoing all electrical wiring in the car, but that will not solve the issue. As soon as you turn on the AC, the blower motor will use so much electricity and amperage, so the blower motor fuse and junction pins on the fuse box starting to burn. Wanting to charge almost $7000 to fix this issue, which is double the price value of the car, and risking to end up in this situation again, as soon as you turn on the AC, does not make sense. KIA should do recall on this model and fix the root cause, which is excessive electricity and amperage usage by the blower motor.

Window falls into the door. The rear two windows have been repaired 3 times. They are currently both broken again along with the front drivers side. I currently have three windows being help up by tape. They are taped to the frame of the door to stop the window from falling into the door. I don't know why this wasn't a recall. I see there is a TSB BOD300. The dealership repaired once but never informed me about the known defect.

The engine assembly completely seized and the vehicle is currently stored at an independent repair shop . While traveling at high speed on Interstate 4 on July 24, 2026, the vehicle suffered a sudden, catastrophic loss of power and stalled in live traffic, creating an immediate threat of a high speed rear end collision. An independent service center officially confirmed the engine seizure after a dealership failed to perform an inspection during an eight hour wait, and no law enforcement or insurance inspections have occurred. Prior symptoms included severe, recurring oil loss requiring constant manual additions of oil between regular service intervals (most recently serviced in June 2026 at a kia dealership), and eventually the car completely shutoff on July24.

engine failure, i was driving home from work and i went to accelerate from 0 to 20 miles and the car hesitated and didn't want to move. I took the car to the dealer three days later and it was confirmed that i needed a new engine. I was told by the dealership i was outside of my warranty but i just found out that i was covered up to 120k miles. No lights came on at the time and there wasn't any prior warnings to this happening. I had just put oil into the car two days earlier as i know in between oil changes that i have to put oil into the car and or check the oil to see if it is low.

NHTSA Bulletin TSB BOD300 My KIA 2016 Optima Turbo has all four windows impacted by the defective gear. I've opened a case with KIA and it's case number 25563361. None of my windows roll up or down. This presents several very serious safety issues. The dealer has had my vehicle for over 2 weeks. Why has KIA not been forced to issue a recall on these defective gears?

Code was on and off for a cylinder 2 misfire was off at this point (intermittent misfire) ecl was off car stalled out at 3rpms while driving, tiny puff of smoke once came from between the air intake and the engine, and also no crank no start but car has power. I’ve kept up with the oil changes every 3000 miles car had fluids in it and nothing looked bad all 4 spark plugs were burnt and i replaced them and still no success.

I had just stopped at stop sign and I turned right. My speed was approximately 40 mph and there was a LOUD POP. I immediately hit the brakes and had NO BRAKES. I got car off road and smoke was already coming from under hood. It caught fire immediately and burned up. Total loss . About 6 months prior to it burning I had a good bit of front end work done on it with bearing issues. Also put a new set of tires at same time . The coils and plugs were changed often because it would misfire. I purchased car July 2025. All my documents were burnt also .

The contact owns a 2016 Kia Optima. The contact stated that while driving 10 MPH, the front driver’s and passenger’s side windows lowered unintendedly. Neither the dealer nor an independent was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The rear driver’s and passenger’s side windows were replaced, and the vehicle was repaired. The manufacturer was notified of the failure but offered no assistance since the VIN was not under recall. The failure mileage was 107,000.