2016 KIA OPTIMA Complaints

Odometer Fraud. The contact purchased a 2016 Kia Optima. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 56,276. and at the time of registration, it was discovered that the mileage was 114,000.

Engine issue, it’s knocking loud and misfires. Engine light flashing and Car went into limp mode , will not go over 60 mph . I have changed the spark plugs, knock sensor, and had an oil change nothing has fixed my issue.

1) Rear passenger window failed a couple months ago. I believe it was regulator, not 100% sure. Cost me a couple hundred to fix. Now, few months later, the driver side rear window has failed. I rarely use the windows so I believe the failing parts are Kia known manufacturing defect. The dealer acknowledged that it’s a known problem with the vehicles like mine and even suggested the other one is going to fail soon. Now it has. If the dealership is aware then it’s likely a Kia flaw. If it’s a know manufacturing flaw, shouldn’t Kia should be fixing them instead of making customers spend upwards of $1k+ to fix both windows? 2) cruise control cuts off or doesn’t set and menus won’t go back to speedometer. While trying to set cruise control, it gets into the menu and won’t go back to the speedometer. Sometimes I have to pull over and stop to get the cruise control to work again. It gets stuck in the menu and can’t see the speedometer. Might get stuck on the trip screen, or the range. This has been happening since about 75k miles. It also doesn’t work with the pedal to set sometimes. Messing with it while driving can be a real hazard and sometimes I need to have cruise control to work. It’s deforming more than just inconvenient

Several safety-critical systems failed on this vehicle. The engine (Theta II 2.4L GDI) failed due to rod bearing wear, causing sudden power loss on the highway. The vehicle entered limp mode, once at 50 mph in 2018 and again at 70 mph in 2025, and had to be pulled over quickly to avoid collision. Additional issues: all four windows failed at different times, leaving them stuck open and creating safety risks in weather or emergencies. The trunk latch failed, causing unsecured cargo risk. ABS, TPMS, and traction control warning lights illuminated repeatedly, indicating possible loss of critical safety systems. A loose wiring harness caused the turn signal bulb to burn out repeatedly, reducing visibility and signaling. The dealership performed the KSDS software update after I reported engine trouble but did not resolve the issue. The engine soon failed completely while driving. Other issues, such as the fuse box blowing fuses from a standard USB charger have also been documented by a Kia dealership but not always fully repaired. The most recent engine failure and electrical defects are being inspected by a Kia dealership, and Kia Consumer Affairs is reviewing the warranty claim. Prior to the engine failure, I smelled burning oil and topped it off monthly due to excessive consumption. The oil level light and check engine light only appeared during limp mode right before the failure. These repeated safety-critical defects, particularly sudden engine failure at highway speed, created a significant safety hazard for myself and others on the road. At the time of this report, I am in the process of seeking warranty coverage for the catastrophic engine failure through Kia. The failure behavior (limp mode, flashing check engine light, and rod knock) is consistent with the safety defect described in the Theta II engine settlement. I am concerned that despite this being a known issue, there may be delays or denials in honoring the safety-related warranty repair.

I own a 2016 Kia Optima EX with VIN [XXX] . The engine failed at 85,763 miles due to a rod bearing seizure. This matches the known defect in Kia’s 2.4L GDI engines, which has been the subject of recalls and service campaigns in the past. Despite being covered under Kia’s extended engine warranty, Kia America denied my engine replacement claim. They cited "vehicle reconditioning" and "multiple ownership" as reasons — neither of which are valid grounds to void warranty coverage, especially for a known defect. A certified Kia dealership (Mark Kia in Scottsdale, AZ) approved my vehicle for warranty replacement, and submitted the request. Kia corporate denied it. This creates a serious safety concern and shows that Kia may be wrongfully avoiding responsibility for this defect. Please investigate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Kia Optima. The contact stated that while driving in inclement weather on several occasions, all four windows of the vehicle became intermittently inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure. The failure mileage was approximately 130,000.

My paint has begun bubbling up and feeling out of nowhere. I’ve always taken good care of my car yet spots are beginning to pop up along the passanger side. The paint continues to peel more as time goes on. I’ve found many complaints online of people saying they’ve had the same issue with their kia in the Snow White Pearl color I have, but there’s no recall and kia refuses to pay for it.

A month in after purchasing the check engine light came on. My car did not want to accelerate, started shaking and having jerking movement while driving on the freeway with my newborn and 3 other children in the car with me. Got stranded 3 hours away from home. Car has been in the shop going on 30 days. Spark plugs changed, coolant thermostat changed and now the engine was reported that it has failed. Still in the shop currently.

MDPS failing when driving randomly. Steering locks up and vehicle is uncontrollable, while the vehicle is moving. This has occurred at varying speeds, while turning and while driving straight. Dealer has unsuccessfully got the issue to replicate, but independent service center was able to replicate it and found the extended warranty and recommended dealership visit since issue is covered. Vehicle has been inspected by dealership and the first recommended battery replacement, but this did not remedy the issue. EPS warning light is illuminated while issue is occurring but due to safety, car needs to be restarted to gain control of the vehicle and light turns off.

All 4 of the window regulator motors blew in my windows at the same time, only about 9 years into the vehicle's life. The little plastic pulleys that move the cables degrade over time and then ruin the rest of the window motor when they break, and since they decided not to make this an easily repairable part it requires the entire window regulator assembly which is half of the door to be replaced, not just this plastic part. I had to replace all 4 of them out of my own money, KIA REFUSED to replace something that is completely 100% their fault and it cost me over $3,500 to repair all four windows that went out pretty much at the same time. It's insane silly that anyone's windows can just break at anytime and be stuck in the down position. I can't just put up trash bags and then not be able to see a thing while I wait to get it fixed if it happens again. I was lucky enough to be in a position to get it looked at quickly, but it is absolutely insane that KIA would refuse to cover such a defect. There is already a class-action lawsuit over this I believe but they haven't even attempted to remedy the situation. Not everyone has time to wait for a lawsuit to settle. There should absolutely be some kind of recall/extended warranty on their windows. My engine blew at 57,400 miles only a few months later which is separate and was replaced but it's just insane that I was promised a car but got a piece of trash that consistently breaks while all I can get is a replacement engine with the same exact problem and no confirmation that the same thing won't just happen again while they continue to use the same defective engine over 10 model years. I want them to fix their issues not slap a band-aid over them and hope for the best. This company has been knowingly selling cars built to end up in a landfill within 10 years and they don't care.