2004 KIA OPTIMA Complaints

Had some noise coming from the front of the car, had my mechanic look at it, he said we needed a control arm. When he took off the cover to replace the control arm, he found the sub frame had rotten and was cracking. As I looked online, I saw that KIA had a recall for this issue. When I contacted KIA, their response was "as my car is not under warranty, they are not required to repair the car" The car in question has 70, 558 miles on it. We are the 2nd owner.

Door lock/unlock mechanism has failed. Unable to unlock and open door from outside or inside. This defect causes the door to stay locked and unable to open. This can trap people inside of the car if they are unable to crawl out a window or exit from another door. There are many reports of this on Kia forums and general Google search. There was no warning that this part was wearing out until it became impossible to open the door.

The contact owns a 2004 Kia Optima. The contact stated that after refueling, the vehicle would not start. The vehicle was not taken to a local dealer. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 04V180000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was informed of the failure and confirmed that the vehicle was not included in a recall. The failure mileage was approximately 145,000.

I WAS REPAIRING BRAKELINES, WHILE OBSERVING UNDER CARRIAGE I NOTICED SUSPENSION RUST, FRAME. LOOKED UP RECALLS AND THIS IS ONE. I INCLUDED SCREENSHOT OF PROOG

WHILE DRIVING ON A HIGHWAY WITH CRUISE CONTROL ACTIVE, I WAS UNABLE TO TURN OFF THE CRUISE CONTROL WITH THE STEERING WHEEL CONTROL BUTTONS. THE CANCEL AND SET BUTTONS HAD NO EFFECT WHEN PRESSED. THE CAR REMAINED TRAVELING AT THE SET SPEED. TAPPING ON THE BRAKE PEDAL DID CANCEL THE CRUISE CONTROL.

WHILE STATIONARY - DRIVER'S SIDE DOOR WILL NOT OPEN FROM INSIDE OR OUTSIDE WITH KEY, MANUAL LOCK OR ELECTRONIC LOCK CONTROLS (STUCK CLOSED). UNABLE TO EVACUATE CAR FROM DRIVER'S SIDE. SAFETY CONCERN - LACK OF EGRESS

TL* THE CONTACT OWNED A 2004 KIA OPTIMA. WHILE DRIVING 25 MPH, ANOTHER VEHICLE CRASHED INTO THE CONTACT'S VEHICLE FROM THE FRONT. THE PASSENGER SIDE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED STOMACH AND CHEST INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 57,000.

UNABLE TO OPEN PASSENGER DOOR DUE TO DOOR LOCK ACTUATOR STOPPED WORKING. UNSAFE TO DRIVE.

TL* THE CONTACT OWNS A 2004 KIA OPTIMA. WHEN THE VEHICLE WAS TAKEN TO BILL DORATY KIA (2925 MEDINA RD, MEDINA, OH 44256, (330) 721-9500) FOR ROUTINE BRAKE SERVICE, THE TECHNICIAN FOUND A CRACK IN THE FRONT FRAME. THE DEALER STATED THAT THE VEHICLE WAS SAFE TO DRIVE AT THAT TIME. THE CONTACT WAS INFORMED THAT THE FRAME WOULD NEED TO BE REPLACED, BUT NO REPAIRS WERE MADE. SINCE WINTER WAS APPROACHING, THE CONTACT WAS CONCERNED THAT THE FRAME WOULD COMPLETELY CRACK DUE TO THE WEATHER AND SALTED ROADWAYS IN HER STATE. THE CONTACT RECEIVED A MANUFACTURER RECALL AND EXTENDED WARRANTY NOTICES IN 2009. THE VEHICLE WAS TAKEN TO THE DEALER, BUT NO ISSUES WERE FOUND. THE DEALER SENT PICTURES OF THE CRACKED FRAME TO THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED AND ISSUED CASE NUMBER: 2560103. THE MANUFACTURER STATED THAT THEY WOULD CONTACT THE LOCAL DEALER. THE CONTACT WAS AWAITING A CALL BACK FROM THE MANUFACTURER AND DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 48,000.

DRIVER DOOR DOES NOT OPEN FROM INSIDE NOR FROM OUTSIDE. WHEN UNLOCKING THE DOORS, ALL DOORS WILL OPEN EXCEPT THE DRIVER'S DOOR. CENTER LOCK MECHANISM OR MANUAL USE OF KEYS DOES NOT HELP. THIS IS WITHOUT A DOUBT A SAFETY PROBLEM WHERE DRIVER CAN BE TRAPPED IN THE CAR IN CASE OF EMERGENCY. THIS IS VERY COMMON IN KIA OPTIMA MODELS.