2015 KIA SOUL Complaints

The contact owns a 2015 Kia Soul. The contact stated that while driving at various speeds there was heat emerging from underneath the dashboard. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the catalytic convertor needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The contact stated that the failure was related to NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The failure mileage was approximately 18,000.

The subject vehicle was take to dealer to address recall SC176. In this recall there is a flow chart instructing the dealer on how to repair the subject vehicle. This flow chart was clearly not followed. The dealer only performed the ECU Logic improvement and did not replace the catalytic converter. The subject vehicle had trouble code P0420 before it arrived. The code was cleared while in the dealers care but returned 6 miles after the vehicle was picked up. Service manager Nick was contacted, He said there were no stored codes however I provided documentation show the code was there and the check engine light was on when dropped off at the dealership. I believe this is a violation of NHTSA. Because the subject vehicle still has a defective Catalytic converter that is manufacture defect.

Engine rod bearing failure. Engine failure. Vehicle was consuming more oil than expected and engine just shut off. Vehicle would not shift into gear. Battery was not charged. When fine finally came on after charging there was a knocking sound. Engine would not accelerate and knocking sound became loud. Vehicle would not even stop.

Catalytic converter failed. Car can over heat and catch on fire. Took to dealership and has been confirmed catalytic converter failed. Vehicle only has 83,000 miles. No warning engine start rattling really bad and vehicle was struggling to go up bridges and speed up.

The engine is leaking oil and got so hot that it melted the inside of the Catalytic converter. This is a recall on 2015 Kia Soul 1.7 liter and not on my 2015 Kia Soul 2.0 liter. I had the car towed to the Kia dealership, Larry Stovesand-Carbondale IL, 5/7/21 to perform 3 recalls: PI2002B (knock sensor), SC200PS (engine inspect/bearing clearance test) and SC155B (pinion gear). The dealership service dept. told me that they had to do the knock sensor and pinion gear recall before they could do the engine inspect bearing clearance test. They kept my car for 3 months, until 8/4/21 and told me about the melted catalytic converter, but still had not performed the engine inspect. I marked the tire with a rock on top to make sure that they did the test. After a week, I went to the dealership. They told me the car passed the engine test. I asked if the test was performed in the garage and I was told yes. I told the service personnel that my car had not been moved because I had marked it with a rock and that the rock was still in the same place on the tire. He said he was going to get the tech and immediately walked out, came back with a tech person that said that he had performed the test but that he had not put it into the system yet. I got the keys to my car and called my local mechanic and had him tow my car to his garage to replace the catalytic converter. The car had the same problems with knocking, hesitation, top speed of 60 mph, and using oil. My local mechanic said the pistons are leaking. I finally got the recalled documentation in the mail from the dealership and it showed they only performed PI 2002B & SC200PS recalls. They did not perform the SC155B recall even though they had the car for 3 months. The car stalled on the highway with my daughter driving. That was terrifying! Now the car is back at Kia for the engine test that I don’t think they did the first time. Now they said it passed the engine test again and only needs a knock sensor. That will not fix it!

The contact owns a 2015 Kia Soul. The contact stated that a month after an oil change an abnormal noise was heard coming from the engine compartment. The vehicle was taken to an independent mechanic who added oil to the engine and stated that no oil leaks were present. The failure would occur several times after oil changes. The contact stated while driving at 30 MPH the check engine warning light illuminated while the engine was misfiring. The vehicle was taken to the dealer however, no diagnostic was completed due to the diagnostic fees. The dealer also informed the contact that the vehicle was not included in a recall. The vehicle was then taken to an independent mechanic who diagnosed the failure as solenoid 1 and 3 misfirings. The independent mechanic recommended an engine replacement. The vehicle was not repaired. The contact researched the failure online and found NHTSA Campaign Number: 19V120000 (ENGINE, ENGINE AND ENGINE COOLING) and NHTSA Campaign Number: 20V750000 (ENGINE) the VIN was not included in the recalls. The manufacturer was notified of the failure and a case was opened. The contact also stated that the manufacturer informed her that her Kia was not manufactured at the same plant as the vehicles included in the recalls. The approximate failure mileage was 98,000.

Driving the car up the 101 Cuesta Grade and lost acceleration. The speedometer went to zero and as the car died I pulled to the right side of the freeway / grade. Smoke started to enter my vehicle. A car stopped in front of me and one behind and the people ran from their cars to tell me to get out of my car as my front engine underneath was on fire. I got out of the car and opened the back hatch to remove my belongings as the engine burst into flames. This car has been maintained by KIA and by a personal mechanic and we were up to date on all recalls. We were NOT included in the most recent engine fire recall. The car is completely destroyed.

The contact owns a 2015 Kia Soul. The contact stated while driving 35 MPH, the vehicle began to hesitate. The contact stated that the battery and the oil warning lights were illuminated. The contact was able to park on the side of the road. The vehicle was not drivable. The contact towed the vehicle to the local dealer and was informed that since she did not have an extended warranty, they would not service NHTSA Campaign Number: 20V750000 (Engine) that was associated with the VIN. The vehicle was diagnosed and repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 104,000.

I purchased a new 2015 Kia Soul in the summer of 2015. Since then I have had to replace the engine TWICE and the catalytic converter at my expense. Now the engine has failed again! I asked the mechanic at the dealership why this keeps happening with a brand new vehicle. He shrugged his shoulders and responded that Kia had problems with that particular engine. Never in all this time did the dealership EVER mention this and now that the third engine needs to be replaced, they are refusing to cover it under the warranty or recall because it is at 152,000 miles and the warranty extension was up to 150,000 miles. Never mind that they should have replaced the first two engines because it was under the 150k... or that the third engine itself doesn't have 150k miles on it. They also never made me aware of the recall on the catalytic converter when it failed and I paid to replace it. The first time the engine seized was approx August of 2019, the second time was March 2020, and the third was June 2021. I've contacted Kia Customer Service - they tell me to contact the dealership. I've had it inspected by an independent third party mechanic and he is convinced that this should be covered by the recall/extended warranty

The contact owns a 2015 Kia Soul. The contact stated while driving 70 MPH, the vehicle stalled with the check engine warning light illuminated. The contact was able to coast the roadside as the vehicle failed to restart. The vehicle was towed to an independent mechanic who determined the failure as complete engine failure. The mechanic advised of an open recall. The vehicle was towed to the dealer where the recall was confirmed however, the contact was advised that the repairs would not be covered under the recall. The vehicle was included in NHTSA Campaign Number: 20V750000 (ENGINE). The manufacturer was contacted, and a case was opened. The manufacturer confirmed that the recall repair was not covered. The contact stated that the recall repair was denied by the manufacturer as the vehicle was not brought to a dealer for repair in a timely manner. The approximate failure mileage was 120,000. Vehicle has been diagnosed by Pep Boys.