2012 KIA SOUL Complaints

I purchased Dorman part #74015 Brake Pedal Stopper from AutoZone Altamonte after an employee recommended it for my 2012 Kia Soul without checking system compatibility. I installed it that night. On, while driving on a busy road in Orlando, FL, my brake pedal locked completely solid and could not be depressed. I had complete loss of braking and could not shift out of park. I was stranded in live traffic with cars swerving around me. I discovered the Dorman part is ~10mm thick. The correct OEM Kia part 32876-2H000 is 8.0mm. The 2mm extra thickness caused my brake light switch to jam, which physically blocked the brake pedal arm. I had to pry the part out on the roadside to regain pedal movement. This created an extremely dangerous situation. I am now anxious to drive due to fear of brake failure. The part is sold as compatible with 2010-2016 Kia Souls but is too thick and disables the braking system. Vehicle repaired with correct OEM 8.0mm part. Issue has not recurred. I have photos of the failed part and installation.

The contact owns a 2012 Kia Soul. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. No warning lights were illuminated. The vehicle was driven to the residence. The contact stated that the following day, while attempting to start the vehicle, the vehicle started, and the check engine warning light was off. The vehicle was taken to the dealer, where the contact was informed that the recall repair failure code was not illuminated. In addition, the contact was informed that the failure was not covered under a recall. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received a recall notification, NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 156,310.

The brake lines on my car failed. I had to use the parking brake to get the car to stop. Typically, a brake failure leaves you with partial braking power, however, I had no brakes whatsoever. Upon inspection, it appears that all the brake lines failed in the same area, where the brakes are over the gas tank. For them all to fail at the same time in an area that is not accessible seems like the this must be prone to corrosion. Note that I regularly wash the car with undercarriage wash in the winters, as they salt extensively around here. I was going to sell the car, and the brakes failed on the test-drive. They had been working immediately before the test drive, as i had driven it around to make sure everything was in working order.

When I turn my steering wheel left or right there is a very large margin before the tires turn it rattles back and forth back and forth as I'm driving down the street no control for at least three degrees and either direction, also my front of the vehicle turn signals pop out and fall out to the road and I would drive with no turn signals on the front of my vehicle?

The contact owns a 2012 Kia Soul. The contact stated that while driving at 60 MPH, the vehicle unexpectedly stalled and failed to accelerate with the low oil warning light illuminated. The contact stated that the failure occurred after the contact’s spouse had added oil to the vehicle. The vehicle was able to restart, and additional oil had to be delivered to the contact to refill the vehicle. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to have the vehicle diagnosed by a dealer for further assistance. The approximate failure mileage was 84,213.

Check engine light came on. Car starts to shutter upon acceleration as well when its idling. Changed spark plugs 3 times since Jan 2025 and coils twice. Code for engine misfire in cylinder 3. Also have to add oil every 2 weeks.

I have a used kia soul 2012 which I bought 3 years ago. It's steering column has started making strange clicking noises when I turn the wheel left and right. I went to KIA dealership, they inspected the steering column and said it's gonna cost me $1200. They said it's not covered under "recall" policy. I don't have the money to fix it and I drive Uber every day. This problem can cause accident or collision if the wheel column stops working on the road.

On Oct. 14, 2025, this vehicle experienced a sudden catastrophic engine failure while driving approx. 70 mph on a highway. While in the passing lane, the vehicle began to lose power, shake, and wouldn’t accelerate. The check engine light came on just moments before a loud explosive noise came from the engine, and a burning smell came through the vents - the engine completely shut down. This failure occurred with other vehicles on the roadway, creating a serious safety risk. I was forced to quickly maneuver the disabled vehicle across multiple lanes of traffic to reach the right shoulder, where I called for roadside assistance. The vehicle was inoperable from that point forward, it would not turn on, and was towed from the scene. There were no warning signs prior to this event. The vehicle had been operating normally before the incident - I had recently checked the oil levels, there were no warning lights, no drivability issues, and no known mechanical problems before the sudden failure. This led me to find the vehicle was subject to an open safety recall addressing engine damage consistent with this failure; NHTSA Recall 19V120000. On Oct. 27th, the vehicle was towed to an authorized Kia dealership in Prescott Valley, AZ for recall inspection. The dealership advised the connecting rods failed and blew 3 holes through the engine block, confirming catastrophic internal engine damage. The manufacturer required a recall-related software update be performed before reviewing the engine failure under the recall. The software update was completed in Nov., but the manufacturer later declined to repair or replace the engine. Kia Corp. refuses to address the safety recall entirely, and instead repeatedly mischaracterizes the issue as a warranty matter - they are unwilling to provide a written explanation of how the failure falls outside the scope of the safety recall 19V120000, despite the failure matching the recall’s described defect & consequences.

I am submitting this complaint regarding a known defect with the steering wheel coupler in my 2012 Kia vehicle. The steering coupler is a component that has been subject to recall concerns due to premature wear. When this part becomes worn, it can result in looseness or failure in the steering system, creating a serious safety risk for the driver and others on the road. Despite this being a known and widely reported defect, Kia has not adequately addressed the issue for all affected vehicles. Instead, owners are being charged significant out-of-pocket costs to replace a part that is defective by design and poses a safety hazard. I believe Kia should be required to fully acknowledge this defect and provide repairs or replacement of the steering coupler at no cost to consumers. Charging customers to correct a known safety-related defect is inappropriate and places an unfair financial burden on vehicle owners while leaving a critical safety issue unresolved.

On 12/ 22/ 2025 I went to start the 2012 KIA Soul and it would act like it would start but, it would not turn over. Battery was fine checked it. Let it set a moment and tried it again would not start. Called a wrecker and towed it in. The service guy tried and couldn't get it to start either. He ran a diagnostic on it, there were not type of codes, no check engine light nothing. He had it for until 1/5/2026 and when they went to check it it started right up. They drove it for 20 miles to check to see if it would cut off while driving, it didn't. It starts now but for how long. Here's the strange thing, I drove it 20 minutes away and I noticed that the counter for when You fill up with gas states how many miles you have left to go before fill up was counting UP not DOWN. So I think it could be the computer or electrical, I thought it was the fuel pump at first. Still no warning signals nothing.