KIA Complaints

There is no incident that lead to this part breaking. My sunroof broke when it was opened. A part fell out of the assembly into the car. The sunroof will now not open fully or close fully. It's a hazard because I'm not sure if the glass is properly attached to my car and can fly off. I took this to a dealership the other day and was told this was common and not covered under warranty, costing owners thousands of dollars and days of repairs.

I am reporting a life-safety defect incident and an illegal vehicle delivery. I purchased a 2027 Kia Telluride HEV subject to Recall SC366 (NHTSA Campaign 26V173000). The dealership delivered the vehicle on April 22, 2026, explicitly stating that the recall service was complete and the vehicle was safe. This was a material misrepresentation. Shortly after delivery, I suffered a physical entrapment incident where the second-row power seat mechanism failed to detect my leg as an obstruction and continued to fold with force, pinning my leg. This is the exact failure described in the recall notice. Following this incident, the dealership called to admit that they never actually performed the required safety fix. By delivering this vehicle, the dealership violated 49 U.S.C. § 30112, which prohibits the delivery of a new vehicle with an open safety recall. The defect is active and dangerous. I am requesting a federal compliance investigation into the dealership’s actions

The contact owned a 2021 Kia Forte. The contact stated that while driving at 45 MPH, the steering wheel locked independently, causing the vehicle to veer off the road into a construction site. The contact stated that the air bags did deploy. The contact stated that she sustained noise and neck injuries, including placenta rupture, causing early labor. Medical attention was required. The contact stated that a police report was filed. The vehicle was towed to an impound lot. The vehicle was deemed a total loss. The manufacturer was not notified of the failure. The approximate failure mileage was 150,000.

Intermittent warning to "Refill Inverter Coolant" displays on the dash screen. This is a known issue pursuant to SA512 (ELE 270 Rev 3) due to faulty coolant that crystallizes and interferes with the sensor. However, per Kia, it is only covered under standard warranty (5 years/60k miles) and while my vehicle is within the year warranty, it is over the mileage. Quote was to replace "Chiller, water pump and flush coolant system" at a cost of $2369.02 including parts and labor. Dealership will not perform recommended maintenance of coolant flush (every 37k miles) without replacing these parts. If this was a known defect why is there a limitation to the SA? It should be covered as a recall, not a voluntary service alert. I am unable to properly monitor the in-dash warnings regarding coolant levels until this problem is fixed

Driving under normal conditions April 20,2026, on the way to school. Got off the freeway and the vehicle immediately shut-off and the check engine light came on. Vehicle was stuck partially in the roadway and would not move. Vehicle was towed to Kia dealership and they found that there was no oil in the engine and that the oil drain plug was completely missing. This problem caused catastrophic engine failure resulting in the need for a full engine replacement. A routine oil change had been conducted approx. 2,000 miles prior to this on January 12, 2026. The vehicle had been driven daily since that oil change with no noticeable oil leak or problems preceding this event. Had this event occurred at freeway speeds, it could have caused serious injury to the driver and other motorists on the roadway at that time. It appears that the drain plug fell out since there was no other additional or noticeable damage to the oil pan or surrounding the drain plug itself. This information was confirmed by a photograph taken by the dealership conducting the repairs.

Sometimes when I’m driving the steering wheel just jerks to the left sometimes causing me to swerve into incoming traffic. It’s very scary. Luckily I’m holding tight to the steering wheel to keep myself from hitting someone.

On [XXX], the check engine light illuminated. No other warning indicators activated — no low oil pressure warning, no low oil level warning, no driver alert of any kind regarding engine condition. On [XXX], at approximately 53,845 miles, the vehicle began running rough. I checked the engine oil and found the dipstick registered empty — no measurable oil in the engine. No low oil level or low oil pressure warning had been provided by the vehicle at any point prior to this discovery. I added two quarts of oil. The vehicle stalled while being driven to obtain the oil, and stalled again after the oil was added. I drove the vehicle to Jiffy Lube and had a full oil change performed. Mileage at the oil change was 53,852. I then scheduled an appointment with Gervais Kia in Lowell, Massachusetts, the nearest Kia dealer, less than one mile from my home. The earliest available appointment was approximately one week later. Because the vehicle stalled repeatedly at idle, I drove it to the dealer using both feet — keeping engine revs elevated with the accelerator while braking — to prevent stalling at stops. The vehicle is currently at Gervais Kia for diagnostic inspection. The symptoms match the failure mode documented in NHTSA recall campaign 25V-099 (Kia recall for 2021-2023 Soul and Seltos with 2.0L Nu MPI engines, piston oil ring manufacturing defect). My vehicle has the 2.0L Nu MPI engine and was manufactured at the Kia Autoland Hwaseong plant identified in the recall filing. However, my VIN does not appear in the current recall population per NHTSA VIN lookup and Kia’s recall lookup. The recall remedy includes installation of Piston-ring Noise Sensing System (PNSS) software specifically because the defect provides no driver warning before failure — consistent with my experience, in which the engine ran empty of oil with no warning whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2013 Kia Soul. The contact stated that the vehicle spontaneously caught fire while parked unattended at 3 am. All the warning lights were illuminated prior to the failure, and the vehicle was undrivable. The contact had received the recall notification letter for NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). There were no reported injuries, police report, or crash. The fire department was called and extinguished the fire. The vehicle was towed to the scrap yard. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 265,000.

The contact owns a 2014 Kia Sorento. The contact stated that while driving at various speeds, the vehicle would jerk. The check engine warning lights illuminated. The vehicle was taken to a local independent dealer, where it was diagnosed with an unknown engine failure. The vehicle was not repaired due to cost. In addition, the contact stated that while driving at approximately 60 MPH, black smoke was seen coming from under the hood, and the contact managed to pull over to the shoulder of the road, safely exit the vehicle, right before the engine caught on fire. The local fire department arrived on scene to extinguish the fire. The contact sustained PTSD; however, no medical attention was sought. A police report was filed. The vehicle was towed to a local tow yard and deemed a total loss by the insurance provider. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact related the failure to an unknown NHTSA Campaign; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.

The contact owns a 2023 Kia Telluride. The contact stated that while driving at an undisclosed speed, the front windshield started to crack on the upper passenger’s side of the windshield. The vehicle was taken to the dealer, but was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 38,200.