KIA Complaints

A. Safety Defect and Failure Sequence I am filing this complaint because my Kia Soul, which is subject to the widespread engine defect and extended warranty under the Hyundai/Kia Class Action Settlement, suffered a catastrophic failure immediately following dealership intervention. Responsible Action: I brought the vehicle to the authorized Kia dealership on September 25th the instant the Check Engine Light illuminated for the very first time. The vehicle was driven to the dealership under its own power. Triggering Event: The dealership performed the required engine-related software update (Knock Sensor Detection System, KSDS) and routine service. Immediately following this service, the engine went into limp mode and ceased functioning, requiring a complete engine replacement. This sequence strongly suggests the failure was either caused by the known defect covered by the recall or was triggered by the software update itself. Manufacturer Denial: Kia is denying the claim under the Class Action Extended Warranty (which provides a lifetime or 15-year/150,000-mile warranty) using the unsubstantiated and unjustifiable excuse of "damage done prior to bringing the car in." B. Manager Misconduct and Manufacturer Bad Faith The Service Manager, Braden Anaya, has demonstrated calculated deception and bad faith, resulting in severe financial and logistical harm: Fraudulent Promise: The manager explicitly promised me the engine replacement would be approved if I titled, registered, and insured the vehicle. Relying on his direct word, I incurred a financial loss of $800 in fees for an unusable vehicle. Documented Deception: After a long delay, Mr. Anaya sent a formal denial email on December 5th confirming Kia would not cover the engine replacement. Despite this formal denial, he then contacted me and demanded "trust and patience," claiming he was actively fighting the claim for the following three weeks. This was an intentional stall and clear act of deception. Logistical Negli

The contact owns a 2023 Kia Telluride. The contact stated that while the vehicle was parked, the instrument cluster went blank. The speedometer and fuel gauge failed to display as needed. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact related the failure to NHTSA Campaign Number: 23V298000 (Electrical System); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

The contact owns a 2022 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact experienced the failure, causing the check engine warning light to remain illuminated, and the vehicle hesitated while accelerating. The vehicle was taken to the local mechanic, who diagnosed the vehicle and determined that the check valve was faulty and needed to be replaced. The vehicle was not repaired. Additionally, the contact stated that while the AC was activated, one vent was blowing hot air while the other vent was blowing cold air. No further information was available. The failure mileage was 103,000.

On December 16, 2025 at approximately 0830 hrs. EST my wife attempted to start the above vehicle. There was an "odd" odor in the garage by the vehicle at the time. She was unable to start the vehicle, there were not functional lights and no other accessories were functional. I perfomed a test on the battery later in the afternoon using a battery testing probe, it indicated the battery was non-functional. At approximately 1515 hrs. EST I replaced the battery in the above vehicle. Upon replacement of the battery the vehicle was started and run for approximately 3 minutes to ensure all systems checked alright and there was no damage from the loss of the. I then was standing at the back of the vehicle and noted smoke coming from the tail lights and from under the liftgate. I opened the rear liftgate and felt heat and saw smoke. As I was removing the trim from around the vehicle to access the area of origin for the smoke, the rear bumper cover melted and flames were visible where the bumper cover had melted. I used a fire extinguisher to extinguish the visible fire then accessed the area under the bumper to ensure the fire had been fully extinguished. Visible under the bumper was the tow wiring whch was visibly damaged by fire. I reported the fire to Kia of Muncie from where the vehicle was purchased new in December 2018 and to the Kia Care Line. Pictures of the damage were sent to both. The vehicle had been checked and cleared of all recalls associated with the tow wiring recall.

My 2013 Kia Optima caught fire while my [XXX] son and his friends were driving it. The car burnt up. Some truck drivers flagged my son down to let him know the car was on fire. They could have been killed if it wasn’t for the truck drivers warning him that the car was on fire while driving down the highway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vechile is burning oil and knock sensor came on which indicated rod bearing. While driving the car lost power the check engine came on was abl to pull over and turned off the car. Did not drive it was tow home.

The vehicle experiences severe stalling and loss of power while driving. When attempting to accelerate, the vehicle hesitates, shakes violently, and will not accelerate beyond approximately 10–20 mph. The vehicle then stalls completely and shuts off. These failures occur both after the vehicle has been parked and while actively driving. When placed in drive, the vehicle shakes aggressively and stalls. The check engine light is illuminated. The stalling has occurred multiple times in the middle of freeway traffic, creating an extreme safety hazard. My child has been in the vehicle during every occurrence. On one occasion, the vehicle shut off completely while on the freeway, placing our lives at risk and nearly resulting in a serious collision. This issue is unpredictable, persistent, and prevents safe operation of the vehicle. The vehicle has been inspected and worked on by Southwest Kia and A-Z Auto, but the defect continues to occur. I believe this is a manufacturing or design defect related to the engine or powertrain that poses a serious safety risk and should be investigated to determine whether other vehicles are affected.

Ever since I bought my car in July of 2025 cash I’ve been having issues. Shortly after purchasing my car began to stall , lose power repeatedly. I then took to southwest kia in Dallas they told me I had contaminated gas. They charged me $2,000 to clean my fuel lines , replace spark plugs & replace a fuel pressure sensor. Shortly after i got my car I had the same issues. I explained my concerns and they replaced my fuel tank free of charge. A week later same issue so I went to a local mechanic and he replaced another fuel pressure sensor a month passed same issues occurred at least 3 more times on 3 different occasions. I’ve had to get my car towed off the middle of the free way or road numerous of times. This has been a financial nightmare

This 2021 Kia Seltos car’s engine has randomly seized up 4 times over the last year causing very serious safety concern. Fortunately, these 4 seize-ups happened when the powerless Seltos car could be safely directed to the shoulder of the road while driving in slower paced traffic. Each time this occurred, our 2021 Kia Seltos had to be towed; towed twice to a mechanic shop and twice to directly to the dealer. The mechanic diagnosed the problem as the vehicle using excessive oil resulting in the vehicle safety sensors shutting the engine down. However, in those instances when we towed the vehicle to the dealer, the dealership always obfuscated and gave us the impression that they were not taking our safety concerns seriously. They never adequately addressed our concerns and often conducted some minor repairs seemingly to placate us to get us down the road. None of their minor repairs worked or solved the problem. In each instance after their repair the problem repeated. We expressed our extreme frustration and concern for our life safety. We communicated to them that this vehicle’s engine has proven unsafe and that has randomly seize-up several times We have researched the 2021 Seltos and found that these Kia models have many serious recalls for multiple items including the problem that we have experiences with excess oil usage. It is our experience that our KIA dealership will not adequately address our concerns and will not take necessary measures to adequately address our very serious safety issues. We believe that our 2021 Seltos is a "Lemmon" and needs to be replaced, or at least its engine replaced. We hope this complaint results in serious action and that I'm not writing again indicating that this 2021 Seltos “Lemmon" vehicle has again seized up and has resulted in a life-threatening safety issue.

Fuel door will not open, there is no manual override, vehicle cannot be refueled and since there is no emergency release it caused me to be stranded at a gas station at night with my 4 kids which is a huge safety concern and should be taken seriously as this is a safety and drivability issue that I should not be held responsible to pay for when it is at no fault to me it is a design/system failure.