2003 LINCOLN AVIATOR Complaints

TL*THE CONTACT OWNS A 2003 LINCOLN AVIATOR. WHEN ACCELERATING TO 40 MPH FROM A COMPLETE STOP, THE VEHICLE'S TRANSMISSION SLIPS AND THE ENGINE'S RPM INCREASES TO 5,000 RPM FOR APPROXIMATELY FIVE TO SIX SECONDS. THE TRANSMISSION THEN SHIFTS ITSELF IN GEAR AND DRIVES FORWARD. WHEN THE CONTACT ATTEMPTS TO ACCELERATE AND CHANGE GEARS, THE TRANSMISSION JERKS AND SLIPS, PREVENTING THE VEHICLE FROM MOVING. THE ENGINE REVS UP AND THEN GETS WEAKER. THE CONTACT STATED THAT THE VEHICLE FEELS AS IF IT IS IN NEUTRAL FOR APPROXIMATELY SIX SECONDS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS KEPT OVERNIGHT. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE IS 62,500 AND FAILURE MILEAGE WAS 45,000.

MY 2003 LINCOLN AVIATOR HAD A ROUGH IDLE AND WAS A LITTLE SLUGGISH. WITH ONLY 92,000 MILES ON A $45,000 CAR, THIS SURPRISED ME. THIS IS A HIGH PERFORMANCE ENGINE. UPON ACCELERATING TO ENTER I-20 THE VEHICLE ALMOST DIED. LUCKILY ,THERE WERE NO VEHICLES COMING - HAD THIS BEEN DURING RUSH HOUR IT MIGHT NOT HAVE BEEN SO LUCKY. I TOOK THE VEHICLE TO CITY GARAGE TO HAVE IT CHECKED OUT, AND WAS TOLD IT HAD A MAJOR ENGINE PROBLEM. THE #8 CYLINDER HAD ON 70 LBS OF PRESSURE, AND THE VEHICLE NEEDED A VALVE JOB. I CALLED LINCOLN CUSTOMER SERVICE AFTER FIND ON THIS WEB SITE THAT MINE WAS NOT THE ONLY AVIATOR WITH THIS PROBLEM AND WITH THE EXACT SAME CYLINDER. I WAS TOLD BY LINCOLN TO TAKE IT TO THE DEALERSHIP WHERE I PAID ANOTHER $100 TO HAVE IT SCOPED AGAIN - ONLY TO BE TOLD BY LINCOLN THAT THEY DIDN'T INTEND TO DO ANYTHING ABOUT IT. THIS APPEARS TO BE ANOTHER ONE OF FORD'S MAJOR MISTAKES THAT THEY ARE NOT WILLING TO TAKE RESPONSIBILITY FOR UNTIL SOMEONE GETS KILLED. PEOPLE WHO OWN THESE VEHICLES DO NOT EXPECT THEM TO DIE ON ACCELERATION, AND IT IS JUST A MATTER OF TIME BEFORE SOMEONE GETS HURT. THAT - COUPLED WITH THE FACT THAT THIS IS COSTING PEOPLE WHO OWN THESE VEHICLES A GOOD DEAL OF MONEY AND FORD'S ATTITUDE WAS TOUGH.

TL* THE CONTACT OWNS A 2003 LINCOLN AVIATOR. WHILE DRIVING 30 MPH THE CONTACT TURNED THE VEHICLE TO AVOID HITTING ANOTHER VEHICLE AND HIT A TREE. THE WEATHER WAS NOT A FACTOR. THERE WERE NO FAILURES PRIOR TO THE CRASH. THE CONTACT WAS THROWN INTO THE WINDSHIELD ON THE PASSENGER'S SIDE, WHERE HE SUSTAINED BACK AND HEAD TRAUMA. THE CONTACTS VEHICLE WAS TOTALED. THE CURRENT AND FAILURE MILEAGE WERE 78000. THE CONTACT HAS A COPY OF THE POLICE REPORT. *AK THE CONSUMER PROVIDED THE DUSSALT AND ZATIR NUMBER 18005424529 TO OBTAIN A POLICE REPORT AND ALSO PROVIDED PICTURES OF THE VEHICLE AS WELL AS INJURIES. UPDATE 05/10/07*TR

2003 LINCOLN AVIATOR WARNING LIGHT "EMISSION". FOUND OUT IT IS A DESIGN FLAW WITH THE AUTOMATIC TRANSMISSION. WE CONTACTED NHTSA AND FOUND OUT THERE IS A RECALL. OUR VIN # IS NOT IN THIS RECALL. FORD/LINCOLN WILL ONLY GIVE US $850.00 OFF ON A $3000.00. THIS CAR HAS 72,000 MILES ON IT. FOUND OUT THIS IS WHEN THESE TRANSMISSIONS GO. WHEN WE TOOK IT TO THE DEALER THERE WAS ANOTHER THERE WITH 45,000 MILES SAME PROBLEM. THE WARRANTY ON THE 2003 IS 4 YEARS 50,000 MILES. THE DIAGNOSE IS GEAR 2 RATIO, GEAR 5 RATIO AND SOLENOID B. *NM

10/26/06 # 8 COIL FAILED 11/8/06 #6 COIL FAILED 12/15/06 # 7 COIL FAILED 1/24/07 CYLINDER HEAD CRACKED TOTAL COST $4,943.53 FOR REPAIRS. *NM

DT*: THE CONTACT STATED A WHINING NOISE WAS HEARD COMING FROM THE REAR OF THE VEHICLE WHILE DRIVING 55 MPH. THE VEHICLE WAS TAKEN TO THE SALES/SERVICE DEALER FOR REPAIRS. THE RIGHT REAR AXLE AND PINION WERE REPLACED AS WELL AS THE C B SHAFT ASSEMBLY AND GEAR AND PINION LOCKING PIN. THIS WAS THE THIRD TIME THE REAR END WAS REPLACED IN A TWO YEAR PERIOD. THE MANUFACTURER WAS NOTIFIED AND A TECHNICIAN WAS SENT TO INSPECT THE VEHICLE.*AK THE VEHICLE PULLED TO THE LEFT, THE DOOR LOCK SWITCH WAS INOPERATIVE, THE REAR SHOCK WAS LEAKING OIL, THE E POWER STEERING HOSE WAS REPLACED, THERE WAS A TICKING SOUND COMING FROM THE ENGINE COMPARTMENT. THE TIMING CHAIN AND GASKET WERE REPLACED. THE DOOR AJAR LIGHT CAME ON AFTER ALL THE DOORS WERE CLOSED. THE CONSUMER STATED THE SHIFTING OF THE GEARS WERE HARSH, THE DEALER REPLACED VARIOUS COMPONETS IN THE TRANSMISSION. THE RIGHT REAR BRAKE LIGHT BULB WAS REPLACED, THE MASTER CYLINDER WAS REPLACED. THE FRONT SEAT CLIMATE CONTROL WAS NOT COOLING. THE BATTERY WAS REPLACED, THE ACCELERATOR CABLE WAS STICKING. UPDATED 12/05/06. *JB

DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT ANY SPEED, THERE WAS AN INCREASED STOPPING DISTANCE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT REPAIR SHOP AND A DEALER WHO BOTH DETERMINED THE MASTER CYLINDER NEEDED TO BE REPLACED. AFTER THE DEALER REPLACED THE MASTER CYLINDER, THE PROBLEM PERSISTED. THE VEHICLE WAS RETURNED TO THE DEALER WHO DETERMINED THE MASTER CYLINDER NEEDED TO BE REPLACED AGAIN. THE MASTER CYLINDER PART NEEDED FOR REPAIR WAS ON BACK ORDER AND NOT AVAILABLE AT ANY AREA DEALERSHIPS. THE MANUFACTURER WAS ALERTED.

DT*: THE CONTACT STATED WHILE DRIVING 55MPH ON THE HIGHWAY WITH THE CRUISE CONTROL ENGAGED, THE VEHICLE SUDDENLY LURCHED FORWARD ACROSS THE ROADWAY AND CAREENED OFF A ROADWAY BRIDGE. THE VEHICLE ROLLED FIVE TIMES AND CAME TO A FINAL STOP AGAINST AN EMBANKMENT. MINOR INJURIES WERE SUSTAINED. DUE TO THE EXTENSIVE DAMAGE, THE VEHICLE WAS TOTALED. THE POLICE WERE ALERTED AND A REPORT WAS TAKEN. AFTERWARDS, THE VEHICLE WAS NOT INSPECTED FOR THE VEHICLE ACCELERATION. THE MANUFACTURER WAS NOT ALERTED.

'03 AVIATOR, SINCE PURCHASE FELT SOMETHING WASN'T RIGHT WITH THE CAR'S TRANSMISSION. CAR SEEMED TO HESITATE SHIFTING INTO NEXT GEAR I.E. STAYING IN GEAR TOO LONG. ALSO AT TIMES DURING STARTUP CAR CAN BE EXTREMELY LOUD, MAKING TRANSMISSION ISSUE MORE PRONOUNCED. CONCERNS MENTIONED DURING ROUTINE MAINTENANCE APPOINTMENTS BUT WAS ALWAYS TOLD THE CAR WAS FUNCTIONING NORMAL. WINTER '06 CAR BEGAN TO IDLE VERY ROUGH DURING STOPS AND IN NEUTRAL/PARK. 3/3/06 CAR SERVICED FOR ROUGH IDLE -GARAGE FOUND SSM 17478 WHICH SAID THE PCM NEEDED TO BE REPROGRAMMED. CAR STILL WASN'T RUNNING SMOOTHLY. 4/3/06 CAR BACK IN GARAGE FOR MAJOR ENGINE PROBLEM. #8 CYLINDER HEAD WAS REPLACED. I EXPRESSED MY CONCERNS AND WAS TOLD THAT THIS COULD HAVE BEEN CAUSING SOME OF THE ISSUES I WAS COMPLAINING ABOUT. WAS ALSO TOLD THEY HAD MULTIPLE '03 AVIATORS COME IN WITH THE SAME MAJOR ENGINE PROBLEM. OF COURSE CAR STILL DID NOT FEEL RIGHT. 5/8/06 AND ONLY 2,000 MILES TO GO ON MY WARRANTY THE TRANSMISSION FINALLY WENT. PULLED OUT FROM A RED LIGHT WHEN CAR WOULDN'T SHIFT AND BUCKED INTO NEXT GEAR. ENGINE LIGHT AND TRANSMISSION LIGHT WENT ON AND OVERDRIVE OFF LIGHT WAS FLASHING. TRANSMISSION SOLENOID REPLACED ALONG WITH MANY OTHER PARTS. NEEDLESS TO SAY THE CAR'S BEEN DRIVEN 2 OR 3 TIMES SINCE WE'VE PICKED IT UP FROM THE GARAGE AND IT IS STILL NOT RIGHT. CAR IS GOING BACK INTO THE GARAGE FOR SHIFTING PROBLEM AND EXCESSIVE LOUD ENGINE NOISE DURING STARTUP THAT DOESN'T DISSIPATE. TRANSMISSION PROBLEM IS HUGE SAFETY CONCERN. HAD CARS BEHIND ME BEEPING AND FLASHING THEIR LIGHTS AT ME BECAUSE I COULDN'T ACCELERATE THE CAR FAST ENOUGH. WITH COMPUTERS IN CARS MAKES ME WONDER WHERE THE VOICE OF THE CONSUMER HAS GONE. FELT AS THOUGH MY CONCERNS DIDN'T MATTER BECAUSE THE COMPUTER DIDN'T REGISTER ANYTHING WRONG. NOW WITH ONLY MILES FROM MY WARRANTY ENDING I'M FACED WITH ALL THESE MAJOR PROBLEMS OCCURRING WITH MY CAR. *JB

DT*: THE CONTACT STATED WHILE TRAVELING 60 MPH THE TRANSMISSION SUDDENLY LOST POWER. THE ENGINE REVVED, BUT THE TRANSMISSION DID NOT ENGAGE. THE CONTACT MOVED INTO THE SLOW LANE UNTIL THE VEHICLE RETURNED TO NORMAL OPERATION, WHICH TOOK ONLY A MINUTE OR TWO. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER FOR INSPECTION SEVERAL TIMES, BUT THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. *AK UPDATED 1/25/2006. THE CONSUMER RETURNED THE VEHICLE TO THE DEALER AND TRADED IT FOR A 2005 MODEL. *NM