2012 LINCOLN MKZ HYBRID Complaints

TL* TAKATA RECALL. THE CONTACT OWNS A 2012 LINCOLN MKZ HYBRID. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 17V024000 (AIR BAGS) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION IN MARCH OF 2017. THE DEALER (TED BRITT FORD SALES, 11165 FAIRFAX BLVD, FAIRFAX, VA, 22030) STATED THAT THE PARTS WERE UNAVAILABLE FOR THE REPAIR. THE MANUFACTURER WAS ALSO CONTACTED AND CONFIRMED THAT THE PARTS WERE UNAVAILABLE AND THAT THEY WERE NOT CERTAIN WHEN THEY WOULD BE AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

DRIVER'S DOOR DOES NOT OPEN FROM THE INSIDE. IT APPEARS THAT A WIRE HAS SNAPPED CAUSING THIS ISSUE. I HAVE TO ROLL THE WINDOW DOWN TO OPEN THE DOOR FROM THE OUTSIDE.

TRAVELING SOUTH ON CT15 IN STOP AND GO TRAFFIC. TRAFFIC WAS MOVING AT ABOUT 40 MPH AND STOPPED SUDDENLY. I APPLIED PRESUURE TO BRAKE PEDAL TO STOP. PEDAL WENT TO FLOOR. IT APPEARED THAT MINIMUAL REGENERATIVE BRAKING WAS ENGAGED BUT NO ADDITIONAL FRICTION BRAKING. CAR HAD PLENTY OF DISTANCE IN WHICH TO STOP [ MORE THAN 140 FEET]. CAR SLOWED FOR A TIME BUT WHEN SPEED WAS REDUCED TO ABOUT 10 MPH, THE REGENERATIVE BRAKING DISENGAGED AND CAR SURGED FORWARD AND REAR ENDED TRUCK CAUSING SUBSTANTIAL BODY DAMAGE. NO WARNING LIGHTS WERE LITE ON DASH. DEALERS HAD INSPECTED BRAKE BOTH BEFORE AND AFTER CRASH AND REPORTED NO PROBLEMS. SIMULATED BRAKE ASSIST DID NOT PROVIDE ANY RESISTANCE TO PRESSURE ON PEDAL. BRAKE PEDAL POSITION SENSOR DID NOT GENERATE BRAKE REQUEST OR ABS AND ECM DID NOT RECONGNIZE REQUEST FOR EXTRA BRAKING. EXTREME PRESSURE ON BRAKE PEDAL DID NOT ACTIVATE FAIL/SAFE MANUAL FRICTION BRAKING. CAR SHOULD STOP IN 140 FEET FROM 60 MPH. QUESTIONS - WHAT WAS THE CAUSE OF THE SBA NOT ACTIVATING? WHY DID THE ABS AND ECM IGNORE OR NOT PROPERLY RESPOND TO THE BRAKING REQUEST? WHY THE FAIL/SAFE FRICTION BRAKING MODE FAIL TO ACTIVATE? WHAT PEDAL PRESSURE IS REQUIRED TO ACTIVATE MODE? THERE ARE NUMEROUS PRIOR REPORTS OF SIMILAR SYMPTOMS CAUSING ACCIDENTS IN 2011/2012 LINCOLN/FORD HYBRIDS. WHAT IS THE STOPPING DISTANCE FROM 60 MPH IN FAIL/SAFE MODE. FORD LITERATURE ON THE HYBRID BRAKING SYSTEM DOES NOT SPEAK TO THIS ISSUE OR GIVE ANY WARNING TO CUSTOMERS. HOW IS THE FAIL/SAFE FRICTION BRAKING SYSTEM TESTED TO INSURE PROPER OPERATION IN AN EMERGENCY? WHY DOES THE BRAKE PEDAL GO TO THE FLOOR WHEN DRIVER IS ATTEMPTING A PANIC STOP?

CAR WAS PARKED. STARTED CAR AND PUT TRANSMISSION IN REVERSE AND NOTICED THERE WAS NO POWER STEERING. WARNING ON DASH "POWER STEERING ASSIST FAILURE". ONLY 37,777 MILES ON CAR. PREVIOUS SERVICE RECORDS ON CAR STATED FIELD SERVICE ACTION 15N01 BUT IGNORED BY DEALER AT LEAST TWICE DURING WARRANTY PERIOD. NOW OUT OF WARRANTY.

DRIVING ON INTERSTATE AT 70 MPH IN HEAVY TRAFFIC WITH CRUISE CONTROL ENGAGED. POWER CUT OUT AND CAR SLOWED DOWN RAPIDLY. THROTTLE PEDAL WAS INOPERATIVE WITH TOTAL LOSS OF POWER. COASTED TO SIDE OF ROAD WHILE DODGING SEMI-TRUCKS. SHUT CAR OFF AND POWER RESET. WAS ABLE TO CONTINUE TO DESTINATION. THE CAR LOST POWER PREVIOUSLY, 09/13/16, WHILE DRIVING IN TOWN, BUT AT THE LOWER SPEED IT WAS NOT LIFE THREATENING. THE ENGINE RESET AFTER RESTARTING THAT TIME ALSO. DEALER WAS NOTIFIED OF THAT INCIDENCE BUT NOT ABLE TO DUPLICATE PROBLEM.

TL* THE CONTACT OWNS A 2012 LINCOLN MKZ HYBRID. THE CONTACT STATED THAT WHILE PULLING ON THE DRIVERS SIDE FRONT DOOR HANDLE, THERE WAS A SNAP ON THE INSIDE OF THE DOOR AND IT WAS DIFFICULT TO OPEN THE DOOR. THE CONTACT ALSO STATED THAT WHEN THE DOOR WAS SECURED, IN ORDER TO EXIT THE LOCK BUTTON WAS PULLED UP AND THE HANDLE NEEDED TO BE PULLED AT THE SAME TIME. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE INTERIOR DOOR HANDLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 64,000.

ATTEMPTED TO GET OUT OF THE CAR AND THE DRIVERS SIDE DOOR WOULD NOT OPEN. SHUT THE CAR OFF, TURNED IT BACK ON. HIT THE LOCK AND UNLOCK BUTTON SEVERAL TIMES AND STILL COULD NOT GET OUT OF THE VEHICLE. EVENTUALLY HAD TO OPEN IT FROM THE OUTSIDE.

APPROXIMATELY MARCH OF 2013. I WAS DRIVING NORTH ON MOULTON BLVD, SUDDENLY THE CAR LOST SPEED AND A RED TRIANGLE SHAPED CAME ON AND STATED "DRIVE TO SIDE OF ROAD SAFELY AND SHUT OFF THE CAR ENGINE" I TOOK IT TO LINCOLN GARAGE AND THEY KEPT MY CAR FOR A WEEK, WAITING FOR DIRECTIONS OF PROCEDURE FROM DETROIT, THEY TOLD ME THEY HAD REPLACED THE HYBRID BATTERY. THE CAR RAN GREAT AGAIN. JUNE 15, 2015 IT SHUT DOWN AGAIN, LIKE BEFORE, I TOOK IT TO THE LINCOLN DEALER, THEY SAID THERE WERE NOT ANY CODES, BUT TOLD ME IT WAS A BAD THROTTLE BODY, OF WHICH THEY CHANGED. JUNE 24,2015, THE CAR SHUT DOWN AGAIN, THE RED TRIANGLE SHAPE LIGHT CAME ON, TOOK IT INTO LINCOLN DEALER THE SAME DAY, THEY TOLD ME THE COMPUTER SAID THE CAR SHUT DOWN, BUT NO COMPUTER CODES. THIS MAKES ME THINK THAT A NEW THROTTLE BODY WAS NOT NECESSARY. A LINCOLN TECHNICIAN HAS BEEN DRIVING MY AUTOMOBILE FOR THE LAST FEW DAYS AND WILL DO SO OVER THIS WEEK-END. HE HAS A COMPUTER ATTACHED TO THE AUTO ENGINE, LOOKING FOR THE CAUSE. WHEN THE CAR SHUTS DOWN, PRESSING THE ACCELERATOR GETS NO RESPONSE.

WHILE DRIVING 55 MPH ON HIGHWAY, RED TRIANGLE WITH "!" IN THE MIDDLE WITH TEXT "STOP SAFELY NOW" APPEARED ON DASHBOARD. AT THE SAME TIME THE ENGINE SHUT OFF (ALONG WITH THE AIR CONDITIONER AND RADIO). THE CAR WOULD NOT RESTART IN NEUTRAL. I HAD TO COAST TO THE SHOULDER OF THE HIGHWAY TO STOP, PUT THE CAR IN PARK, TURN THE KEY TO RESTART AND THEN DRIVE AGAIN. THIS HAPPENED 3 TIMES IN 45 MINUTES. I TOOK THE CAR TO A LINCOLN DEALERSHIP. THEY COULD NOT FIND ANYTHING WRONG OTHER THAN RECOMMENDING I PURCHASE A NEW BATTERY. I WAS SKEPTICAL, BUT DID SO JUST IN CASE. I PICKED UP THE CAR ON 6/16/15. ON 6/19/15 THE CAR TURNED OFF AGAIN WHILE DRIVING ON A HIGHWAY. THIS HAD HAPPENED PREVIOUSLY IN 2013 AND 2014. BOTH TIMES THE DEALERSHIP COULD NOT FIND ANYTHING WRONG WITH THE CAR. IT IS NOT SAFE FOR A CAR TO TURN OFF ON A HIGHWAY.

THIS HAPPENED TO ME ONCE BEFORE IN APRIL OF 2015, DON'T REMEMBER THE DATE. HOWEVER ALSO ON FRIDAY MAY 15TH, 2015, I WAS BACKING MY LINCOLN MKZ 2012 HYBRID OUT OF THE CHURCH PARKING LOT AND THE STEERING WHEEL WOULDN'T TURN. I DASHBOARD WARNING LIGHT SAID POWER STEERING NOT FUNCTIONING OR SOMETHING SIMILAR. IT HAPPENED ONCE BEFORE IN APRIL, AND AT THAT TIME, I WAS ALSO PARKED, STARTED UP THE CAR AND IT WOULDN'T STEER. I STOPPED THE CAR, STARTED IT UP AGAIN AND THAT TIME IT CORRECTED ITSELF. I READ A REPORT ON THE INTERNET ABOUT 508 CASES BEING REPORTED AND UNDER INVESTIGATION SO I THOUGHT I WOULD ALSO SUBMIT A COMPLAINT. LUCKY FOR ME ON FRIDAY MAY 15TH, 2015 I WAS ACROSS THE STREET FROM A LOCAL INDEPENDENT CAR REPAIR SERVICE STATION. THEY CALLED HUDSON FORD IN HUDSON, WISCONSIN AND THE SERVICE DEPARTMENT THERE SAID IT WAS UNDER WARRANTY AND TO BRING IT UP TO THEIR SERVICE DEPARTMENT. I CALLED AT THE END OF THE DAY AND THEY SAID THAT THEY COULDN'T REPLICATE THE PROBLEM AND THEREFORE COULDN'T FIX IT. THE INDEPENDENT SERVICE STATION WHERE IT FIRST ENDED UP, DID A COMPUTER DIAGNOSTIC ON IT AND SAID IT WAS THE STEERING BOARD, OR CHIP. I AM AFRAID TO DRIVE THE CAR IN THE EVENT THE POWER STEERING GOES OUT WHEN I AM DRIVING. IT COULD CAUSE A HORRIBLE CRASH!! I SENT THE ARTICLE I FOUND ON THIS ISSUE TO THE HUDSON FORD DEALERSHIP'S SERVICE MANAGER'S EMAIL, AND THEN TALKED TO HER ABOUT THE ARTICLE. SHE SAID SHE'D READ IT. AT THIS POINT THEY STILL HAVE MY CAR. I PRAY THEY FIX IT. *TR