2003 LINCOLN NAVIGATOR Complaints

THIS IS THE FIFTH (5TH) TIME IN 6 YEARS I HAVE BROUGHT MY CAR IN FOR REPAIR OF THE AIR SUSPENSION (COMPRESSOR, RIDE HEIGHT) , ALL BUT ONE OF THOSE TIMES WAS TO THE FORD LINCOLN DEALERSHIP. IT IS CLEAR THAT FORD IS AWARE OF THE PROBLEM AS THERE ARE 10 SERVICE BULLETINS ON THE 2003 AIR SUSPENSION ALONE, AS WELL AS HUNDREDS OF COMPLAINTS ON THE INTERNET (SEE COMPLAINTS ON EDMUNDS, EVEN FORDS WEBSITE AND SEVERAL CAR FORUMS. THESE ARE OF THE LINCOLN NAVIGATOR ONLY, NOT ITS EQUIVALENT FORD EXPEDITION, WHICH ALSO HAS HOSTS OF COMPLAINTS.) MANY OF THE COMPLAINTS STATE, MUCH LIKE MY EXPERIENCE, THAT THE DEALER CANNOT EVEN FIGURE OUT THE PROBLEM. IT IS IMPOSSIBLE TO DESCRIBE TO YOU THE DANGER INVOLVED WHEN THE SUSPENSION FAILS, ESPECIALLY AT HIGHWAY SPEEDS. THE CAR BOUNCES VIOLENTLY AND BECOMES TOTALLY UNCONTROLLABLE. *TR

MY ROOF-MOUNTED DVD PLAYER HAS NEVER WORKED BUT STILL MAKES NOISES WHEN CAR IS CRUNK UP OR SWITCHED OFF, MY BATTERY ALL OF A SUDDEN WENT DEAD (CAR WOULD NOT CRANK), HEADLIGHTS HAVE SHORTS IN THEM...AFTER REPLACING $100 BULBS, I FOUND OUT IF I TURN THE LIGHTS OFF AND BACK ON, THE BULB WILL COME BACK ON, CHECK PARK ASSIST LIGHT AND ALARMS COME ON EVERY TIME THE VEHICLE IS PUT IN REVERSE, AND MY SUSPENSION WILL NOT LET THE VEHICLE UP WHEN THE WEATHER IS COLD. *TR

I BOUGHT MY USED 2003 LINCOLN NAVIGATOR IN 2008. A YEAR LATER, AIR SUSPENSION FAILURE HAPPENED SEVERAL TIMES. BOTH IN CITY AND ON HIGHWAY - VARIOUS SPEEDS - BUT THE SCARIEST AND MOST DANGEROUS WAS WHEN IT HAPPENED ON THE HIGHWAYS. CAUSED VEHICLE TO LOSE ALL SUSPENSION AND DROP EXTREMELY LOW. THE NAVI BOUNCED DANGEROUSLY AND VIOLENTLY EVEN AT VERY REDUCED SPEEDS. IT ALSO CAUSED THE NAVI TO SCRAPE THE GROUND ON A FEW OCCASIONS. HAD IT REPAIRED THREE TIMES @ $500+ AND WAS FINALLY TOLD THAT I NEEDED TO REPLACE ALL FOUR @ APPX $2000+!! I WAS ALSO TOLD THAT THIS IS A KNOWN PROBLEM WITH NAVI'S. IN ORDER TO SAVE MY TIME, MONEY AND SANITY, I OPTED FOR SPRING-SUSPENSIONS AT A THIRD OF THE COST AND HAVE NOT HAD ANY PROBLEMS WITH THOSE IN OVER 4 YEARS! I HIGHLY RECOMMEND THE SPRING-SUSPENSIONS AND STOP THE INSANITY. *TR

TL* THE CONTACT OWNS 2003 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE STANDING OUTSIDE OF THE VEHICLE, THE VEHICLE STARTED TO ROLL BACKWARD. THE ENGINE WAS OFF AND THE TRANSMISSION WAS IN PARK. THE CONTACT RAN TO CATCH VEHICLE AND WAS INJURED FROM A FALL. DRIVER SUFFERED SPRAINED ANGLE, BODY BRUISING. THE VEHICLE CRASHED INTO ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, A LOUD ROARING NOISE WAS HEARD FROM THE FRONT PASSENGER'S SIDE OF THE VEHICLE. THE CONTACT INSPECTED UNDER THE HOOD AND DETECTED THAT THE NOISE WAS COMING FROM THE AIR LIFT COMPRESSOR. THE NOISE COULD ALSO BE HEARD WHEN THE VEHICLE WAS STATIONARY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 65,319.

TL* THE CONTACT OWNS A 2003 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE DRIVER'S SEAT FAILED TO ADJUST AND COULD NOT BE MOVED FORWARD. THE METAL BAR FOR THE DRIVER'S SEAT FRACTURED AND THE SEAT BECAME LOCKED IN PLACE, WHICH WAS ABNORMALLY FAR FROM THE STEERING WHEEL. AS A RESULT, THE CONTACT WAS UNABLE TO REACH THE STEERING WHEEL OR THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE METAL BAR ADJUSTER FOR THE DRIVER'S SEAT FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 81,000.

MY AIR SUSPENSION WENT OUT THE FIRST TIME IN MARCH OF 2008, IT JUST QUIT WORKING. I THEN PAID $500 TO GET IT REPLACED. THEN AGAIN IN 2011 IT WENT OUT 2 DIFFERENT TIME, IN WHICH THIS TIME I HAD THE COMPRESSOR REBUILT. AND AGAIN IT WENT OUT OF MAY OF 2012. THIS TIME I HAVE NOT HAD IT REPLACED, I ONLY DRIVE THE SUV WHEN I HAVE TO. THERE ARE SO MANY PROBLEMS WITH THE AIR SUSPENSIONS ON THE 2003 LINCOLN NAVIGATOR THAT FORD SHOULD MAKE THE PART GOOD. *TR

LOSS OF BRAKE FLUID, LEAKED THROUGH TO CRUISE DEACTIVATION SWITCH INTO CRUISE SYSTEMS AND ELECTRICAL COMPONENTS CAUSING CORROSION WHICH CAUSED A SHORT. HAD TROUBLE WITH CRUISE CONTROL WORKING OVER TIME LEAD TO HIGHER FLOW OF CURRENT THAT OVERHEATED AND CAUSED FIRE AT SWITCH UNDER HOOD. FORD SPEED CONTROL DEACTIVATION SWITCH FIRE. THE FIRE ORIGINATED IN THE AREA WHERE THE SPEED CONTROL DEACTIVATION SWITCH IS LOCATED (LEFT REAR CORNER OF THE ENGINE COMPARTMENT AT THE MASTER CYLINDER. THERE WAS EVIDENCE OF SPEED CONTROL DEACTIVATION SWITCH FAILURE PRIOR TO THE FIRE INCLUDING INOPERABLE SPEED CONTROL, REPEATED DIFFICULTY SHIFTING OUT OF PARK. *TR

TL* THE CONTACT OWNS A 2003 LINCOLN NAVIGATOR. THE CONTACT STATED THE AIR SUSPENSION SYSTEM DISENGAGED AND THE VEHICLE BEGAN TO SHAKE VIOLENTLY WHENEVER HE DROVE OVER A BUMP IN THE ROAD. THE FAILURE OCCURRED WHILE DRIVING AT VARIOUS SPEEDS. THE CONTACT NOTICED THAT THE SUSPENSION SYSTEM WAS DISENGAGED WHILE THE VEHICLE WAS PARKED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AT LEAST TEN TIMES TO BE REPAIRED. THE FAILURE CONTINUED TO OCCUR. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED MORE FREQUENTLY DURING COLD WEATHER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2003 LINCOLN AVIATOR. WHILE DRIVING 20 MPH, THE ACCELERATOR PEDAL REMAINED STUCK TO THE FLOOR. THE DEALER INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT THE ACCELERATOR CABLE WAS FRACTURED. THE CONTACT WAS AWAITING REPAIRS TO THE VEHICLE. THE CONTACT WAS ALSO AWAITING A RESPONSE FROM THE MANUFACTURER. THE APPROXIMATE FAILURE MILEAGE WAS 90,300. THE VIN WAS UNAVAILABLE.