2004 LINCOLN TOWN CAR Complaints

TL* THE CONTACT OWNS A 2004 LINCOLN TOWN CAR. THE CONTACT STATED THAT THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE KNUCKLE WAS RUSTED AND THE STEERING SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 245,000.

WHILE TRAVELING IN TRAFFIC SOUTHBOUND ON I-95 @ 75 MPH IN PALM BEACH COUNTY THERE WAS A SHIFT OF THE RIGHT REAR TO THE RIGHT. I ADJUSTED TO MAINTAIN CONTROL PRESUMING POSSIBLE HIGH WINDS ON THE ROAD. UPON ACCELERATING THERE WAS NO POWER, THEREFORE I APPLIED BRAKES TO COAST TO THE RIGHT SHOULDER AND PUT THE CAR IN PARK (AUTOMOBILE WAS STILL MOVING UNTIL IT CAME TO A COMPLETE STOP). LOOKING AROUND THE VEHICLE, EVERYTHING SEEMED NORMAL; NO LEAKAGE OF LIQUIDS/FLUIDS, NO SKID MARKS, NO FOREIGN DEBRIS, ETC. WHILE AUTO WAS BEING PUT UPON THE FLAT BED FOR TOW, THERE WAS A CYLINDER-SHAPED PIECE LOCATED ON THE GROUND NEAR THE TOW TRUCK. I NOTICED THE ITEM, BUT DIDN'T THINK MUCH OF IT AT THE TIME. AFTER THE CAR WAS TOWED TO MY RESIDENCE 40 MILES AWAY FROM THE INCIDENT AND BEFORE BEING RELEASED FROM FLAT BED TOW TRUCK; THE RIGHT REAR WHEEL/TIRE WAS PROJECTING ABOUT 45 DEGREES OUT FROM REAR FENDER WELD. THE CAR HAD TO BE JACKED UP AND THE WHEEL/TIRE HAD TO BE HELD IN PLACE BY HAND AND ROTATED SLOWLY OFF THE RAMP . UPON FURTHER INVESTIGATION, IT IS NOTICED THAT ONLY THE TOP PORTION OF THE BRAKE CALIPHER ASSEMBLY WAS HOLDING THE WHEEL ALL ALONG. THE JACK HAD TO BE LEFT IN PLACE BECAUSE THE WHEEL/TIRE WAS NOT STABLE. ALSO, GREASE WAS SPREAD THROUGHOUT THE INTERIOR WHEEL; 3 WHEEL BEARINGS SEEMED MISSING, THE AXLE WAS COMPLETELY DISENGAGED (CLEAN-CUT THROUGH) FROM THE PORTION OF THE WHEEL/TIRE ASSEMBLY, INCLUDING THE WHEEL BREAK CYLINDER AND THE OTHER PORTION OF THE AXEL WAS LODGED IN THE AXLE/DIFFERENTIAL HOUSING UNIT. THE AREA AROUND THE RING SHELVE HAD A RUST-LIKE COLOR (THEREFORE, ASSUMING THAT A HIGH DEGREE OF HEAT WAS A FACTOR IN THE STRUCTURAL/MATERIAL BREAKDOWN), PORTIONS OF THE WHEEL WERE MAGNETIZED WITH METAL SHAVINGS WITHIN GREASE UPON THE WHEEL DRUM HOUSING; BROKEN/CRUSHED BEARINGS PARTS AND THE AXEL COMPLETELY CUT OFF AT THE WHEEL ASSEMBLY AREA. MECHANICS WERE PUZZLED. *JS

TL* THE CONTACT OWNS A 2004 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH , THE POWER STEERING ASSIST SUDDENLY MALFUNCTIONED AND MADE IT VERY DIFFICULT TO TURN THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE LOWER INTERMEDIATE STEERING SHAFT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 78,300.

TL* THE CONTACT OWNS A 2004 LINCOLN TOWN CAR. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH , THERE WAS AN IMMEDIATE LOSS OF STEERING CONTROL. THE CONTACT WAS ABLE TO REGAIN CONTROL AND MANEUVERED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO REPLACED TWO STEERING COLUMN SHAFT ASSEMBLIES. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 37,847. UPDATED 06/27/14*LJ THE CONSUMER STATED THIS VEHICLE'S MODEL AND MODEL YEAR WERE EXCLUDED FROM THE STEERING RECALL. UPDATED 07/2/2014 *JS

PULLING INTO A SPACE IN A PARKING LOT, UPON APPLICATION OF THE FOOT BRAKE, THE CAR EXPERIENCED SUDDEN UNEXPECTED ACCELERATION, JUMPED THE CURB, AND STRUCK A TREE IN FRONT OF THE PARKING SPACE. ACCELERATION STOPPED WHEN THE CAR WAS SHIFTED OUT OF D INTO P. FRONT BUMPER OF THE CAR WAS DAMAGED, AND A WRECKER HAD TO BE CALLED TO PULL THE CAR OVER THE CURB, WHICH WAS PREVENTING BACKING UP THE CAR. FORTUNATELY NO ONE WAS INJURED, BUT THIS SUDDEN ACCELERATION IS VERY SIMILAR TO WHAT OTHER COMPLAINTS ABOUT THIS CAR DESCRIBE. IT WAS LIKE THE CRUISE CONTROL CAME ON AND STARTED TO ACCELERATE THE CAR. *TR

ON JUNE 20 2012 I PURCHASED 4 GOODYEAR VIVA AUTHORITY TIRES 225/70/16.ON APRIL 24 2014 I NOTICED I WAS LOSING AIR ON MY FRONT LEFT TIRE! I WENT TO WALMART# 01698 IN HOOKSETT,N.H.,AND WAS TOLD MY TIRE HAD DRY ROTTED,THE OUTSIDE SIDEWALL LOOKED FINE, THE INSIDE SIDEWALL HOWEVER LOOKED LIKE IT WAS ABOUT TO SPLIT IN TWO,THE MANAGER SAID THERE WAS NO EVIDENCE OF AN IMPACT AND THE TIRE WAS PRO-RATED. THE MANAGER ALSO INFORMED ME THE OTHER TIRES,ALL BOUGHT ON 6/20/12,SHOWED EVIDENCE OF DRY ROT,BUT SINCE THEY HAD NOT YET FAILED,THERE WAS NOTHING THEY COULD DO. *TR

2010 LINCOLN TOWN CAR. CONSUMER WRITES IN REGARDS TO STEERING LINKAGE SHAFT DUE TO CORROSION RECALL. CONSUMER STATES 2004 LINCOLN TOWN CAR WITH SAME ISSUE IS NOT UNDER RECALL. *SMD THE CONSUMER STATED HE HAD DIFFICULTY TURNING THE STEERING WHEEL DUE TO CORROSION OF THE LINKAGE SHAFT BEING VERY CORRODED. THE COST OF THE REPAIR WAS $ 296.80. IT HAD RUSTED OUT AND MADE THE VEHICLE NEARLY IMPOSSIBLE TO TURN. *JB

TL* THE CONTACT OWNS A 2004 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE POWER STEERING ASSIST SUDDENLY MALFUNCTIONED, MAKING IT VERY DIFFICULT TO TURN THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE LOWER STEERING SHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 96,000.

OPENING THE DRIVER'S DOOR NORMALLY, THE DOOR HANDLE BROKE OFF WITH A PIECE OF THE DOOR PANEL. THE WHOLE DOOR ASSEMBLY USED TO OPEN/CLOSE THE DOOR IS NO LONGER AVAILABLE AND HAS BEEN DISCONTINUED. THE ONLY WAY TO OPEN THE DOOR NOW IS TO ROLL THE WINDOW DOWN AND REACH OUTSIDE TO OPEN THE DOOR FROM THE OUTSIDE. THIS IS PARTICULARLY UNSAFE AS IT IS THE DRIVER'S MAIN ESCAPE.

THE INTERIOR DOOR LOCK WITHIN THE PANEL BROKE OFF ON THE DRIVERS SIDE & THE CLIPS BROKE OFF ON THE PASSENGERS SIDE. PER LINCOLN WE WILL NEED TO REPLACE THE WHOLE PANEL. THEY NO LONGER MAKE THE PANEL NOR CAN WE FIND IT AT ANYWHERE ELSE. LINCOLN OFFERED TWO SITES TO TRY AND LOCATE HOWEVER THEY DO NOT HAVE THIS PART EITHER. THE CAR HASN'T EVEN HIT 10 YEARS FOR US AND LINCOLN OFFERS NO SOLUTION. THE CAR RUNS OK BUT IT'S A BIT EMBARRASSING THAT WE CANNOT OPEN THE DOOR WITHOUT THE PANEL FALLING DOWN. I BELIEVE THIS IS A BAD BUSINESS TRANSACTION FROM THE MANUFACTURER AND HAD WE KNOWN WE WOULD GET THIS TYPE OF SERVICE WE WOULDN'T OF BOUGHT THIS MAKE OF CAR. *TR