2006 LINCOLN ZEPHYR Complaints

I HAVE HAD MY 2006 LINCOLN ZEPHYR FOR 1 1/2 YEARS. I NOTICED WITHIN ALMOST A MONTH THAT MY FRONT DRIVER TIRE WAS HAVING A SLOW LEAK. SHORTLY AFTER ALL MY TIRES WERE SLOWLY LEAKING AND I WOULD FILL THE TIRES TO 33PSI'S AS RECOMMENDED, BUT BY TWO DAYS THE PSI'S WOULD BE DOWN TO 8PSI. MY FIRST INCIDENT THAT OCCURRED WAS DRIVING ON THE INTERSTATE AND MY BACK PASSENGER TIRE BLEW OUT. I HAVE BOUGHT ALL NEW TIRES AND WITHIN ALMOST 3 MONTHS THE SLOW LEAK OCCURRED AGAIN IN ALL THE TIRES. I HAVE HAD MY TIRES RESEALED NUMEROUS TIMES ( THE RESEAL HOLDS FOR ALMOST 3 MONTHS) AND THE LEAK IS COMING FROM THE BACK OF THE RIM WHERE THE RIM AND TIRE MEETS. I HAVE BEEN TOLD BY MECHANICS THAT THE LEAKS ARE DAMAGING THE WALLS OF MY TIRE AND THE MECHANIC HAS PUT NEW VALVES ON AND THE TIRES STILL LEAKS. I HAVE INVESTED IN A AIR PUMP THAT PLUGS UP TO THE CIGARETTE LIGHTER BECAUSE I NEVER KNOW WHEN THE TIRES MIGHT BE FLAT. I HAVE CONTACTED LINCOLN/FORD AND THERE IS NO RECALL ON THIS VEHICLE. I HAVE DONE RESEARCH ON THE INTERNET AND FOUND SEVERAL ARTICLES/PAGES WITH SIMILAR PEOPLE TO MY SITUATION. I DO NOT FEEL SAFE, BECAUSE I NEVER WHEN A TIRE BLOW OUT MAY OCCUR AND WITH THE LEAK DAMAGING MY TIRES, IT LOOKS LIKE I MIGHT BE BUYING NEW TIRES QUIT OFTEN. WILL YOU PLEASE HELP MY AND OTHER 2006 LINCOLN ZEPHYR OWNERS. THANKS *TR

TL* THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, ALL OF THE INSTRUMENT PANEL WARNING INDICATORS BEGAN TO ILLUMINATE CONTINUOUSLY UNTIL THE ENGINE WAS TURNED OFF. IN ADDITION, THE GEAR LEVER FAILED TO SHIFT INTO REVERSE UNTIL AFTER SEVERAL ATTEMPTS WERE MADE BY THE CONTACT. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.

IN NOVEMBER OF 2011, THE CAR BEGAN TO STUTTER AND STALL WITHOUT WARNING. THE ENGINE LIGHT CAME ON AND THE CAR INSTANTLY CUT OFF. THE PCM AND IGNITION COILS WERE REPLACED AT THE FORD DEALERSHIP. IN JULY OF 2013 WHILE DRIVING ON THE HIGHWAY, THE CAR BEGAN TO STUTTER AND IT CUT OFF. THE CAR WAS TAKEN BACK TO THE DEALERSHIP AND GIVEN THE SAME DIAGNOSIS. *TR

TL* THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED ALL FOUR CHROME RIMS FLAKED AND THE TIRE PRESSURE DECREASED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE TIRES WERE LOSING PRESSURE. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. *TR

TL* THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, SHE WAS STRUCK BY ANOTHER VEHICLE FROM THE FRONT AND REAR PASSENGER SIDES, CAUSING THE CONTACT TO CRASH INTO A POLE. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE CHIN, HANDS, AND FINGERS AND A PASSENGER SUSTAINED MINOR KNEE AND SHOULDER INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND WAS NOT DIAGNOSED FOR THE AIR BAG FAILURE. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 93,000.

DRIVING DOWN INTERSTATE AND CHECK ENGINE LIGHT STARTED FLASHING AND CAR LOST POWER. CALLED DEALER AND THEY SAID THE LIGHT WAS AN ENGINE MALFUNCTION. STATED NOT TO DRIVE IT. GOT IT TOWED TO REPAIR SHOP. WHEN THEY DIAGNOSED CAR THEY STATED THE PCM MODULE WENT OUT AND WAS SENDING UNINTERRUPTED ELECTRICITY TO ENGINE COILS AND SURPRISED THE CAR DIDN'T START ON FIRE. THEY ALSO STATED THE PCM MODULE WAS IN ITS 13TH DESIGN AS THEY HAVE HAD PROBLEMS WITH THIS BEFORE AND LINCOLN HAD A TECHNICAL SERVICE BULLETIN AS IT HAS BEEN COMMON. *TR

HAD A FLAT TIRE GOING DOWN THE HIGHWAY. DIDN'T THINK MUCH ABOUT IT...IT HAPPENS. GOT A COUPLE OF NEW TIRES PUT ON AND A FEW MONTHS LATER IT HAPPENS AGAIN. RUINING THE $250 TIRE AGAIN. MY MECHANIC SAYS THE CHROME IS PEELING OFF MY RIMS AND THAT IS WHAT IS CAUSING ME TO LOSE AIR PRESSURE IN THE TIRE,AND THAT I SHOULD REPLACE THE RIMS. THEY ARE ABOUT $550 A PIECE SO THATS NOT GOING TO HAPPEN. THESE CARS THAT HAVE LOW PROFILE TIRES NEED TO HAVE TIRE PRESSURE MONITORING SYSTEMS BECAUSE YOU CAN'T LOOK AT THE TIRE AND TELL ITS LOW. IF FORD DOESN'T FEEL THIS IS A SAFETY ISSUE THEY ARE WRONG.I WORK AT A FORD DEALERSHIP AND I SEE STUPID RECALLS FOR THINGS THAT MIGHT HAPPEN ONE TIME IN A THOUSAND. BUT I BET THIS IS HAPPENING TO ALL THE ZEPHYR,FUSIONS,MILANS, OR ANYTHING THEY ARE PUTTING THESE JUNK RIMS ON. *TR

2006 LINCOLN ZEPHYR. CONSUMER WRITES IN REGARDS TO DEFECTIVE WHEEL RIMS. *SMD THE CONSUMER STATED FOR THE LAST YEAR-AND-A-HALF, HE HAS BEEN LOSING AIR IN AT LEAST ONE OF HIS TIRES. APPROXIMATELY SIX MONTHS AGO, HE NOTICED HE HAD BEEN LOSING AIR IN THREE TIRES. AN INDEPENDENT DEALER INFORM HIM THAT THE LOSS OF AIR WAS DUE TO CORROSION AND CHROME FLAKING OFF THE WHEEL RIM. HE RECOMMENDED THAT THE CONSUMER REPLACE ALL FOUR OF THE WHEELS RIMS. BECAUSE OF THE HIGH COST OF THE WHEEL RIMS, THE CONSUMER DECIDED TO MONITOR THE AIR LOSS AND ADD AIR AS NEEDED. OVER THE LAST FEW MONTHS, IN THREE TIRES, HE BEGAN LOSING BETWEEN 10-20 POUNDS OF AIR OVER A FOUR OR FIVE DAY PERIOD. THE OTHER TIRE MAINTAINED AIR PRESSURE. THE MANUFACTURER AGREED TO REPLACE TWO OF THE RIMS. *JB

TL* THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY HESITATED TO ACCELERATE. THE FAILURE RECURRED INTERMITTENTLY. THE CONTACT LATER NOTICED SMOKE COMING FROM UNDER THE VEHICLE WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC ADVISED THE CONTACT THAT THE FIFTH ENGINE COIL HAD MELTED AND CAUSED A SMALL ENGINE FIRE. THE MECHANIC REPLACED THE SPARK PLUG AND THE COIL. AFTER THE REPAIR THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE PCM WAS DAMAGED DURING THE FIRE AND WOULD HAVE TO BE REPLACED AND RECALIBRATED. ALL OF THE COILS WOULD HAVE TO BE REPLACED AS WELL. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 93,000. ... UPDATED 02/28/13 *BF

THE 2006 LINCOLN ZEPHYR WAS TRAVELING AT A SPEED OF 40 AND THE REAR PASSENGER TIRE SUDDENLY BLEW UP. THE MECHANIC INSPECTED THE CAUSE AND CONCLUDED THAT THE ORIGINAL ALUMINUM LINCOLN-FACTORY WHEEL WAS DEFECTIVE. THE MECHANIC ALSO INSPECTED THE OTHER THREE WHEELS AND THE SAME PROBLEM IS CONTINUING TO OCCUR WITH ALL THE 2006 LINCOLN ZEPHYR WHEELS. THE MANUFACTURING DEFECT WAS DESCRIBED BY THE MECHANIC AS FOLLOWS: THE CHROME IS PEELING OFF THE WHEEL, WHICH PREVENTS A GOOD SEAL BETWEEN THE WHEEL AND THE TIRE, RESULTING IN THE LOSS OF AIR PRESSURE. THE SUDDEN LOSS OF AIR PRESSURE MAY CAUSE SERIOUS INJURY OR DEATH. *TR