2006 LINCOLN ZEPHYR Complaints

THE FRONT LCA BALL JOINT DRIES UP IN THE SOCKET AND MAKE THE CAR SQUEAK, AND WOBBLE OVER THE ROAD. THE AUTO SHOW STATED IT WAS A POOR DESIGN SINCE YOU ARE UNABLE TO ADD LUBRICATION INTO THE BALL JOINT. THERE IS A NATIONAL BACK ORDER TILL MAY, SO I HAVE TO DRIVE MY CAR UNSAFELY UNTIL ONE IS AVAILABLE. *LN

TL*THE CONTACT OWNS A 2006 LINCOLN ZEPHYR EQUIPPED WITH MICHELIN ENERGY TIRES, SIZE P225/50/R17. WHILE THE VEHICLE WAS BEING SERVICED, THE CONTACT WAS INFORMED THAT ALL FOUR TIRES (ORIGINAL) NEEDED TO BE REPLACED DUE TO DRY ROTTING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO CONFIRMED. THE TIRES HAD NOT BEEN REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000 AND THE CURRENT MILEAGE WAS 20,320. UPDATED 03/16/11 *BF UPDATED 11/16/11

2006 LINCOLN ZEPHYR. 22K MILES. ALL 4 RIMS CORRODE CAUSING TIRES TO LOOSE AIR. TIRE SHOP BROKE DOWN TIRES AND CLEANED RIMS. APPLIED SEALANT AROUND LIP AND REMOUNTED TIRES. TIRE SHOP OWNER INDICATED HE HAS CLEANED AND RESEALED A NUMBER OF 2006 LINCOLN ZEPHYR ALUMINUM WHEELS. AT 35K MILES ALL 4 TIRES WERE REPLACED AT LINCOLN DEALER. TWO WEEKS AFTER NEW TIRES INSTALLED FRONT DRIVER SIDE TIRE CAME OFF RIM DUE TO LOW AIR PRESSURE. I COMPLAINED TO DEALER THAT THE TIRES ARE LEAKING AIR. DEALER ACKNOWLEDGED PROBLEM WITH RIMS AND REPLACED TIRE FREE OF CHARGE. DEALER ALSO INDICATED ALL FOUR RIMS WERE CLEANED AND RESEALED. *TR

2006 LINCOLN ZEPHYR: TRANSMISSION BEGAN FAILING AT 35,000 MILES. EXTREMELY HARSH SHIFTING FROM SECOND TO THIRD GEAR. NO ACCELERATION WHEN DRIVING UPHILL CAUSES SAFETY HAZARD AS SPEED CANNOT BE MAINTAINED. EXTREMELY HARSH SHIFTING AND SOMETIMES UNABLE TO SHIFT GEARS AT ALL. FOUND A TECHNICAL SERVICE BULLETIN PINPOINTING THE PROBLEM TO A MAIN VALVE BODY DEFECT. FORD/LINCOLN DEALER IS REQUESTING A TOTAL TRANSMISSION REPLACEMENT WHICH COSTS OVER $4,000. *TR

TL* THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED THAT WHEN UP SHIFTING, THE VEHICLE WOULD NOT RESPOND TO HIGHER GEARS AND WOULD BEGIN JERKING ABNORMALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION WAS DEFECTIVE AND WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 24,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 26,500.

WHILE THE VEHICLE WAS RUNNING, BUT PARKED, THE A/C SUDDENLY STOPPED WORKING. AIR CONTINUED TO BLOW, BUT IT WAS HOT INSTEAD OF COOL. DIAGNOSTIC REPORT SAYS THE ACET SENSOR FAILED. REPAIR WAS DECLINED DUE TO COST ($550). NOW, EVEN WITHOUT ANY CLIMATE CONTROLS ENGAGED, THE PANEL GETS VERY HOT WHEN THE CAR IS RUNNING. IF THE SEAT A/C IS ENGAGED, IT WILL WORK UNTIL THE PANEL GETS HOT, THEN IT WON'T WORK ANYMORE. IF THE FAILED ACET SENSOR IS RESPONSIBLE FOR THE OVERHEATING BEHIND THE CLIMATE CONTROL PANEL, IT MAY BE A SAFETY ISSUE AND NOT JUST A COMFORT ISSUE. *TR

ISSUE WITH WEAK, INADEQUATE WELDS ON A 2006 LINCOLN ZEPHYR. THIS ISSUE IS RELATED TO FORD TSB 06-24-07, AND INVOLVED THE SUBFRAME OF THE VEHICLE. SINCE THE SUBFRAME NOT ONLY HOLD THE ENGINE AND SUPPORTING PARTS, THE AREA IN QUESTION IS ALSO INTEGRAL TO THE FRONT SUSPENSION/STEERING. THIS IS A SAFETY HAZARD IS A WELD BREAKS WHEN THE VEHICLE IS IN MOTION AND POSES A SERIOUS INJURY RISK. *TR

TL*THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED THAT ALL FOUR WHEELS ON HIS VEHICLE WERE DEFECTIVE. THE WHEELS CAUSE THE TIRES TO FLATTEN AND WILL NOT HOLD AIR. THE CONTACT MUST PLACE AIR IN THE TIRES EACH WEEK. THE DEALER STATED THAT THE VEHICLE NEEDED NEW WHEELS, BUT AT THE CONTACT'S EXPENSE BECAUSE THEY WERE NOT COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS 43,905. UPDATED 4/16/09 *CN UPDATED 04/20/09.*JB

TL*THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. WHILE DRIVING APPROXIMATELY 50 MPH ON AN ICY ROAD, THE VEHICLE BEGAN TO FISHTAIL AND DECELERATED TO 35 MPH. THE CONTACT CONTINUED TO DRIVE THE VEHICLE, STOPPED AT A REST STOP, AND CALLED A MECHANIC. THE CONTACT WAS INFORMED THAT THE FAILURE COULD POSSIBLY BE DUE TO THE TRACTION CONTROL, WHICH WAS RELATED TO THE ABS. HE DROVE THE VEHICLE IN REVERSE AND THEN IN DRIVE WITH THE PARKING BRAKE ENGAGED. THE VEHICLE BEGAN DRIVING NORMALLY AFTER THE PARKING BRAKE WAS RELEASED. THE FAILURE HAS RECURRED AND THE MANUFACTURER AND DEALER HAVE NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 20,000 AND FAILURE MILEAGE WAS 19,000. UPDATED 02-23-09 *BF UPDATED 02/25/09. *JB

TL*THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED THAT THE WINDOWS AND SUNROOF OPEN WITHOUT THE VEHICLE BEING STARTED SIMPLY BY PUSHING THE REMOTE IGNITION KEY. SHE STATED THAT IT WAS A SAFETY ISSUE BECAUSE THE WINDOWS AND SUNROOF COULD BE OPENED WITHOUT HER KNOWLEDGE, ALLOWING SOMEONE TO ENTER THE VEHICLE. THE FAILURE HAS BEEN OCCURRING SINCE MARCH OF 2008. THE VEHICLE WAS TAKEN IN FOR AN OIL CHANGE AND THE MECHANIC STATED THAT THEY WOULD INVESTIGATE THE ISSUE. FORD STATED THAT THERE WAS A GLITCH IN THE REMOTE IGNITION KEY. THE CURRENT MILEAGE WAS 23,348 AND FAILURE MILEAGE WAS 2,000. UPDATED 06/25/08 *BF THE CONSUMER STATED THERE ARE 4 SYMBOL BUTTONS ON THE IGNITION KEY THAT DO NOT REQUIRE A LOT OF FORCE TO ACTIVATE. THE BUTTONS CAN BE ACTIVATED BY OBJEXTS PUCHING AGAINST THEM. UPDATED 06/25/08