1994 MAZDA B-SERIES TRUCK Complaints

ON LONG TRIPS, OFTEN IN COLD, WET OR SNOWY WEATHER, THE ENGINE WILL OCCASIONALLY REV OUT OF CONTROL. THIS IS NOT AN ISSUE OF THE THROTTLE CABLE ICING UP BECAUSE TURNING THE ENGINE OFF AND RESTARTING IT (WHICH IS THE LAST THING YOU WANT TO DO WHILE STILL MOVING ON ICY ROADS) TEMPORARILY RESOLVES THE ISSUE. THEREFORE, IT SEEMS TO BE MOST LIKELY AN ELECTRICAL PROBLEM. NO DIAGNOSTIC TROUBLE CODES (DTCS) ARE REGISTERED IN THE COMPUTER'S MEMORY, THEREFORE NO INFORMATION EXISTS BY WHICH TO DIAGNOSE THE PROBLEM. I HAVE BEEN TO DEALERS AND THEY HAVE SAID THEY CANNOT HELP ME UNLESS THEY CAN REPLICATE THE PROBLEM IN THE SHOP. AS I SAID, IT HAS ONLY HAPPENED AFTER MANY HOURS OF DRIVING ON LONG TRIPS, WHICH MAKES IT IMPOSSIBLE TO REPLICATE IN THE SHOP. *NM

DT: THE CONTACT STATED THE FUEL FILLER HOSE CRACKED WHICH RESULTED IN A LEAK. WHEN ATTEMPTING TO FILL THE FUEL TANK THERE WAS A LARGE AMOUNT OF GASOLINE THAT LEAKED AROUND THE FILLER NECK AND FORMED A LARGE PUDDLE UNDERNEATH THE VEHICLE. THE FILLER HOSE WAS PREVIOUSLY REPLACED BY AN INDEPENDENT REPAIR SHOP, BUT THE HOSE CRACKED AGAIN. NO FURTHER REPAIRS HAVE BEEN MADE AT THIS TIME. *AK UPDATED 12/27/2005 - *NM

MY 1994 MAZDA B3000 PICKUP (I.E. FORD RANGER) LEAKS GASOLINE WHEN BEING FILLED AT THE FILLING STATION DUE TO A FAULTY FUEL TANK FILLER NECK. FUEL SPILLS ON THE GROUND OF FILLING STATION (APPROX 1/2 GAL) AND IS A FIRE HAZARD. COST TO REPLACE FUEL FILLER NECK IS $280 FROM FORD DEALERSHIP, NOT INCLUDING LABOR - THIS IS PROHIBITIVELY EXPENSIVE FOR A RUBBER HOSE. MANY OTHER RANGER OWNERS EXPERIENCE THIS SAME PROBLEM, THUS INDICATING THAT THERE'S A DEFECT IN THE DESIGN/CONSTRUCTION OF THE FILLER NECK. *NM

DT: THE GAS TANK FILLER HOSE ON THE MAZDA PICK UP TRUCK IS FAULTY AND IS LEAKING GASOLINE WHEN THE TANK IS FULL, AND FUMES WHEN THE TANK IS HALF FULL OR LESS. IN THE CONSUMER'S RESEARCH HE FOUND THAT THIS IS A COMMON PROBLEM. MADZA IS CHARGING $400.00 FOR THE REPLACEMENT PART. CONSUMER HAS BEEN IN CONTACT WITH MAZDA, WITH NO HELP. CONSUMER HAS PLACED ON ORDER FOR THE REPLACEMENT PART. CONSUMER HAD REMEDY FOR THIS ISSUE AND IT 4 YEARS. HOWEVER, PROBLEM RECURRED. *AK

WHILE THE VEHICLE WAS PARKED CONSUMER NOTICED FLUID LEAKING FROM UNDERNEATH THE VEHICLE. IT WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FRONT FUEL LINE ASSEMBLY NEEDED TO BE REPLACED. *AK

I HAVE A 1994 MAZDA B3000 WITH 75000 MILES AND AFTER TEN YEARS THE TANK HAS DEVELOPED A CRACK IN AN AREA THAT IS PROTECTED FROM ROAD DEBRIS AND HAS NO STREES OR FLEX . I BELEIVE THAT THIS TANK WHILE IT IS TEN YEARS OLD IS DEFECTIVE AND SHOULD BE REPLACED BY THE MANUFACTURER. THE RESULT COULD BE FIRE FROM THE LEAKING FUEL . THE CRACK IS NOT AT A SEAM . THE VEHICLE IS NOT USED IN ROUGH TERRAIN CAUSING STRESS. *JB

REQUEST FOR ASSISTANCE-CHECK ATTACHED PAID BILLS TO DETERMINE IF ANY REPAIRS QUALIFY FOR RECALL. *BF THE DRIVABILITY PROBLEM WAS CONSTANT AND WAS PRESENT DURING NORMAL ROAD CONDITIONS AND THE EGR WAS FOUND RUSTED AND ALLOWED INCORRECT EGR FLOW. *SC

DURING A TRIP FROM HOME TO STORE, THE DASH LIGHTS FOR THE ABS AND BRAKE SYSTEM CAME ON WITHOUT ANY PRIOR WARNING. ANOTHER DRIVER MADE A U-TURN IN FRONT OF ME PRIOR TO MY ARRIVAL AT THE STORE CAUSING ME TO HAVE TO APPLY THE BRAKES IN AN EVASIVE MANUEVER. THE BRAKES L,OCKED UP AND CAUSED ME TO LOSE CONTROL OF THE VEHICLE. FORTUNATELY, I WAS ABLE TO AVOID THE COLLISION. I TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND THEY INFORMED ME THAT THE ABS HYDRAULIC CONTROL VALVE NEEDED TO BE REPLACE. THEY INDICATED THAT THERE HAD BEEN 3 REVISIONS OF THE ORIGINAL ABS SYSTEM VALVE, INDICATING THAT MAZDA WAS AWARE THAT THERE HAD BEEN A PROBLEM WITH THIS VALVE. WE HAVE NEVER RECEIVED ANY INDICATION OF A RECALL OR PROBLEM.*AK

THE PAINT ON THE HOOD AND ROOF HAS BUBBLED AND FLAKED OFF. I PURCHASED THE TRUCK WITH 8,000 MILES ON IT. I CONSISTENTLY WASHED AND WAXED THE TRUCK.(WAXED 5-7 TIMES YEARLY). THE BODY SHOP I TOOK THE TRUCK TO SAID THIS WAS POOR QUALITY WORK AND THEY WERE SUPRISED TO HERE THIS WAS FROM THE FACTORY AND NOT REPAIR WORK. *LA

I HAVE REPLACED THE FUEL ASSEMBLY TWICE ON MY 1994 MAZDA B-3000 DUE TO LEAKING FUEL AND PAID $400.00 EACH OCCURENCE SINCE I PURCHASED THE TRUCK FROM THE DEALER. I TOOK NOTE OF RECALL NUMBER 94V111002 AND MAZDA STATES MY VIN NUMBER DOES NOT MATCH. MY TRUCK SPECIFICATIONS MATCH AS MUCH AS I CAN TELL AND I WOULD APPRECIATE A DETAILED EXPLANATION. THANK YOU. *AK