2019 MAZDA CX-5 Complaints

I own a 2019 Mazda CX-5 with approximately 36,000 miles. The vehicle developed a strong burning oil smell while driving, particularly through the HVAC/vent system. I initially reported the odor to a Mazda dealership, but no issue was identified. Approximately two months later, the smell returned and worsened. The vehicle was later diagnosed by a Mazda dealership with an oil leak originating from the cylinder head near the exhaust manifold. According to the repair documentation, oil was accumulating on the exhaust due to seepage from the cylinder head. The repair required full cylinder head replacement. This created significant safety concerns because leaking oil was contacting hot engine/exhaust components while the vehicle was being operated. Burning fumes entered the passenger cabin through the vents while driving. I was concerned about the risk of fire, smoke inhalation, sudden oil loss, and possible engine failure while on the road. There were no warning lights prior to the failure. The primary symptom was the persistent burning smell. The dealership replaced the cylinder head. The original repair estimate was approximately $6,000. Mazda later provided partial goodwill assistance, but I was still required to pay approximately $2,500 out of pocket. After researching this issue further, I found numerous similar NHTSA complaints involving 2019 Mazda CX-5 vehicles experiencing cylinder head leaks/cracking near the exhaust manifold, burning smells, smoke or fumes entering the cabin, and major engine repairs at relatively low mileage. Mazda has acknowledged similar cylinder head concerns in CSP11 and TSB 01-002/23 for certain VIN ranges but denied coverage for my vehicle because the leak involved oil rather than coolant and because my VIN was outside the covered range. I am requesting that NHTSA investigate whether this represents a broader cylinder head defect affecting additional 2019 Mazda CX-5 vehicles outside the currently covered VIN range.

Cylinder head is cracked and leaking oil. The Cylinder head has an active warranty extension but Mazda only applies this to coolant leaks and not oil leaks. The root cause is a casting defect along with a exhaust manifold design issue that imparts undue stress onto the cylinder head causing cracks. The limitation of the warranty to the type of fluid that leaks rather than the failure due to design issues with the exhaust manifold and cylinder head does not make sense given that both components have been redesigned due to the prevalance of both coolant and oil leaks from cylinder head cracks. Problem has been confirmed by Quality Mazda Service departmetn on April 4, 2026 but no warranty coverage extended to repair the failure due to the fluid leak being oil and not coolant. No warnings or messages given prior to leaks. Leaks began at roughly 76,400 miles.

The cylinder head cracked, causing a coolant leak, which then lead to the car overheating. My car was taken into Mazda dealership because there is a warranty extension for this specific part CSP111. The Mazda dealership, corporate, and warranty department all stated the known widespread defect cracked cylinder head will not be replaced on their behalf due to an overheating code. Mazda is using a symptom as an excuse to the problem. Due to the overheating code, Mazda recommended replacing the whole engine for $10,000 with 20 hours of labor. This defect part and Mazda’s unwillingness to provide a proper solution caused my car engine to fail, posing a safety risk. No symptoms other than low coolant were present, which my car was then parked, not driven, and towed to the dealership, in hopes the warranty would be honored.

A Mazda Dealership should me a Mazda cx5 2019, in 2023, at nearly 38k miles, right about where many have reported a cracked cylinder issue due to a manufacturing issue in age, and in milage. There is a lawsuit ongoing regarding the turbo version, however many reporting the same issue in the non turbo versions. My engine started smoking while on the highway causing a highly dangerous scenario to which I was barely able to make it to a mechanic where all the oil spilled out upon arrival. I got a diagnostic from a reputable mechanic confirming the cracked cylinder.

My wife's vehicle has a "Infotainment screen" (dashboard touch screen). There is a class action suit (CSP13d dealer letter) for issues regarding the screen performing tasks (Ghost screening touch) on its own. In lieu of a Mazda vehicle mass recall, they agreed to "FIX" the issue with a software update and replace the CMU Module of the vehicle to rectify this issue. I am here to report / advise you that MANY Mazda owners are NOT happy and have taken it upon themselves to disconnect these screens and do other "work around self repairs (removing/ disabling the unit) in order to fix the issues that occur. I have directly contacted Mazda in regards to my issues and they stat they can ONLY do what was advised on the court ordered settlement and NOTHING more to fix the issue. I want to advise you first hand, their FIX for this issue does NOT fix the problems. In fact, it is making it much worse! NOW my wife's vehicle is operating this screen by itself, WHILE driving, creating a MAJOR distraction. This "Ghost Touching" is actually going into the braking system settings and trying to change/ alter them AS she is driving! A MAJOR SAFETY ISSUE. She has had to, on several occasions, pull over /off the road, shut down the vehicle and try to "reset" what has occurred and check her system for ANY altered setting..if possible. As a retired Police Officer, I can tell you first had that if we ever encountered such thing/ safety issues reported by drivers, we would NOT allow them to travel any further with the vehicle and have it safely towed to a dealer or mechanic for repair. For their safety as well as the rest of the publics safety!! Mazda has refused to fully fix this issue and you can even see on numerous social media posts of MANY others reporting similar issues, disabling their devices on their own and doing other work arounds to mute or disable their devices totally. I Implore you to do a FULL RECALL of ALL affected vehicles to fix the problem ASAP!

Today I was using this vehicle and the cars my pocket got stuck in between the car seat dial for the movement of the car seat and the door and as I was in reverse the car seat started to move and pushed me all the way to the steering wheel as I was in a drive situation mode so I had to break it all off disconnected and everything

Engine has a crack in the head, well under 100,000 miles. It's a known defect but Mazda refuses to do anything about it. It is currently a very expensive paperweight sitting under our carport.

My 2019 Mazda CX-5 with approximately 78,000 miles developed a sudden major engine oil leak. The Mazda dealership diagnosed the issue as a cracked cylinder head and quoted approximately $5,600 for repair. The vehicle was properly maintained and this failure occurred without warning. A cylinder head failure at this mileage appears premature and may represent a defect. The oil leak created a large puddle under the vehicle and could pose a potential safety hazard due to loss of engine oil.

2019 Mazda CX5 has a cracked cylinder head. This is causing oil to leak out. The oil is leaking out onto the exhaust manifold which is causing the manifold to smoke and has the possibility to catch fire. Mazda is aware of this issue and issued CSP 11( customer service program). This does not cover the oil leak, only coolant leak. Several Class Action Lawsuits have been filed. Local Mazda dealership has inspected the car and confirmed the issue. The issue occurred suddenly with no warning. Again, Mazda is aware of this issue but has failed to issue a recall or service program to fix it, this is a dangerous issue as it can lead to a fire with the oil leaking onto the exhaust manifold.

My 2019 Mazda CX-5 started to smoke from the engine and I could smell oil burning. My car was due for an oil change so I brough it to a mechanic. After a diagnostic, they determined that there was a major oil leak and that the cylinder head was cracked and suggested I take it to the dealership. I did and they confirmed that there was a cracked cylinder head causing the massive oil leak. The technician even said in a video sent to me that the oil is leaking "in the same place as the others". I was then quoted $5,960.75 to make this repair. I did research and found that this is a manufacturing defect that is long known to Mazda. There is a TSB and a CPS that extends the warranty for this issue but only for turbo engines, not my non-turbo engine. My car is 2 years past the warranty but I only have 32K miles on it. I asked if Mazda could cover all or some of the cost since it is a defect, not caused by anything I did or didn't do. I was then told that because I didn't take my car there regularly for service, that they wouldn't cover it. I regularly took my car in for oil changes and other maintenance to a local shop as the nearest dealership was almost 30 miles away so it was very inconvenient. It's outrageous that Mazda won't issue a recall or extend the warranty for the same issue in the non-turbo engines. Asking me to pay $6K for a defect they caused is unconscionable.