2016 MAZDA CX-9 Complaints

I started smelling coolant after exiting the vehicle from a drive. Coolant level was very low. Adding coolant did not last long. I could not see where the leak was. The dealership evaluated and determined I had a cracked cylinder head and the car is leaking coolant near the rear of the engine. This could cause the engine to seize should coolant get into the engine. The dealer (New Rochelle Mazda) explains the cylinder head needs replacing. The dealer also observed bad rear sway bar links. One was detached. The car is serviced at the same dealership every 5k miles. The car has approximately 85k miles. The cylinder head has been repaired by the dealer under the extended warranty. Safety risk was moderate as the car could have stalled on the highway. The component was inspected by the warranty company and dealer only. The only warning lamps that showed up once were both brake indicator lights came on and the climate control would not warm the car.

Vehicle “surges” at idle. 300-500 RPMS at a time. Sometimes the brakes hold and sometimes not. Have nearly been in 3 collisions the last 2 days because of this issue. The ECM codes indicate throttle body or TPS issue, both of which have been unfounded. Vehicle has 63,000 miles. Researching this topic online found that many others have had this issue with no associated safety recalls noted. I am hoping to bring light to this so someone doesn’t have to be injured or killed to have this rectified.

The car started to overheat so we added coolant and then the car started to stall had our mechanic look at it and he said the head gasket needs to be replaced. How is this not a recall

The intercooler failed or failed cylinder head causing coolant leaking into the exhaust side and cause the engine to over heat.

Engine is leaking coolant. Took the car to Horne Mazda of Avondale dealership for inspection, was told coolant is leaking from cylinder head. Was told the engine overheated and both cylinder head and cylinder block warped and will need to replace the engine. I feel my safety and others were at risk because the car could have lost power and stalled in the middle of roadway at any time due to there was no symptoms of my car engine overheated, car was running as normal, no check engine light, coolant temperature gauge did not show it was overheating, no sign of engine loosing power, no smoke from under the hood, no sweet smell or any indication engine is loosing coolant and overheating while driving. It appears to be a slow leak because coolant reservoir still have coolant above minimum level. First sign of coolant leak was notice during first week of October 2023 when small amount of green fluid was found on garage floor, took car to dealer on Oct.12.2023 for inspection. MazdaUSA refused to cover engine replacement under paid Mazda Extended Confidence warranty (MEC), blaming it's owners fault for operating car while engine overheated and refused to provide written copy of inspection details.

The vehicle has tire pressure monitoring system malfunction warnings and parking brake malfunction warnings even after taking to dealership to be fixed. Was told it’s a known problem by Mazda, should be recalled, but there were not any current recalls for the issue.

While driving, engine suddenly overheated due to coolant leak from cracked cylinder head. This was a known issue per the TSB 01-002/23. See attached. Vehicle only has 55k miles and has been maintained, only requiring oil change, topping off of fluids, and filter changes. Dealership has determined that it will require a completely new long block. Mazda USA is currently only willing to cover a small fraction of parts costs, requiring me to pay the remaining parts and all labor costs.

Car started running rough and losing power intermittently. After arriving home and parking the car, a puddle of coolant started at the rear of the engine. Online research indicates this is a known issue for the 2016 CX-9. Head gasket failure causes coolant leak from back side of engine at the head gasket. Coolant is still leaking 24 hours later without the car being run.

I have taken the Mazda CX9 since I bought it new to service at Mazda every 6 months or 5,000miles as suggested. Two years a new engine was required due to overheating and coolant problem which the service man noticed 5 months prior during service appointment but didn’t suggest doing anything. Now two years later new engine they installed overheated also.The Mazda has never been in a wreck of any sort. The Mazda has 86,000 miles on it only. How can a car have 2 engines fail in 7 years when it has been serviced there at the agency punctually as required?

The car has 75K miles on it and has always been maintained by either Mazda or independent garages. Engine overheating, took car to Mazda specialist and found the engine cylinder head is cracked. This is a known issue with this type of Mazda engine and Mazda has published a TSB which I attach. Car is unsafe to drive as coolant may leak completely at any stage and leave myself and family stranded. The cost of the fix exceeds $6,000!