2004 MAZDA MAZDA3 Complaints

2004 MAZDA 3 WITH 2.3 LITER ENGINE AND MANUAL TRANSMISSION MAZDA HAS A POOR DESIGN ENGINE OIL FILTER HOUSING. THE END IS MADE OF PLASTIC. THESE END CAPS TEND TO FATIGUE AND CRACK WITH AGE. THIS PART IS EXPOSED TO HIGH HEAT, VIBRATIONS, AND TORQUE. WHEN IT CRACKS AND LEAKS IT LEADS TO CATASTROPHIC ENGINE FAILURE. *TR

WHEN DRIVING ON THE HIGHWAY, THE TRANSMISSION OF MY 2004 MAZDA 3 WITH ONLY 84,000KM DIED AS IT LOST THE ABILITY TO REACH 3RD AND 4TH GEAR. THIS INCIDENT NEARLY COST ME MY LIFE YET MAZDA CANADA WOULD DO NOTHING ABOUT IT. WHAT KIND OF COMPANY CAN NOT STAND BEHIND THEIR PRODUCT AFTER SUCH A NEAR-FATAL INCIDENT. SUFFICE TO SAY THAT MAZDA WILL NEVER GET MY BUSINESS AGAIN. $3,200 LATER, I'M STILL ALIVE NO THANKS TO MAZDA. *TR

2004 MAZDA 3 HATCHBACK POWER STEERING LOCKUP, HARD TO STEER WHILE DRIVING. STARTED HAPPENING IN 2009. *TR

2004 MAZDA 3 HAS FREQUENT LOSS OF POWER STEERING. WHILE IN MOTION POWER STEERING SUDDENLY STOPS WORKING. TURNING OFF CAR FOR SEVERAL MINUTES THEN RESTARTING SEEMS TO CLEAR PROBLEM. INCIDENT OCCURS EVERY 3 - 4 DAYS. *TR

RANDOM POWER STEERING FAILURE. WHEN DRIVING ON HIGHWAY APPROX 65MPH, THE YELLOW DASH INDICATOR WARNING LIGHT FOR THE POWER STEERING SYSTEM ILLUMINATED AND POWER STEERING STOPPED WORKING. I EXITED THE HIGHWAY AFTER A FEW MINUTES AND PULLED INTO A SIDE ROAD (WITH NO POWER STEERING), AND THEN ALL OF THE SUDDEN THE POWER STEERING LIGHT EXTINGUISHED AND IT WORKED FINE AGAIN. THIS WAS A VERY DANGEROUS SITUATION, ESPECIALLY FOR THOSE WHO DO NOT HAVE MORE THAN AVERAGE STRENGTH TO TURN THE STEERING WHEEL WITHOUT POWER STEERING!! *TR

LETTER FROM CONGRESSMAN VAN HOLLEN ON BEHALF OF CONSTITUENT RE SAFETY PROBLEMS (RANDOM STALLING) WITH HIS 2004 MAZDA3 *TGW THE CONSUMER WENT TO SEARS TO PURCHASE A BATTERY THINKING THAT WAS THE CAUSE OF THE RANDOM STALLING, BUT WAS TOLD THE BATTERY WAS FINE AND IT APPEARED THERE WAS AN ELECTRICAL PROBLEM, BUT THEY WERE UNABLE TO FIGURE OUT WHAT IT WAS. THE CONSUMER THEN WENT TO THE DEALER AND WAS TOLD DIFFERENT THINGS WERE WRONG WITH THE VEHICLE, WHICH WAS CAUSING IT TO STALL. THE CONSUMER PAID FOR THE REPAIRS, BUT WEEKS LATER THE VEHICLE STALLED AGAIN. THE CONSUMER ALSO STATED THE CLUTCH AND TRANSMISSION WAS REPLACED. *JB

TL*THE CONTACT OWNS A 2004 MAZDA3. THE CONTACT STATED THAT NHTSA CAMPAIGN ID 04V468000, AIR BAG SENSOR, CONTROL MODULE WAS A PART OF HIS YEAR, MAKE AND MODEL VEHICLE; HOWEVER, THE DEALER STATED THAT IT WAS NOT ALTHOUGH IT WAS EXHIBITING THE IDENTICAL FAILURE. THE CONTACT STATED THAT THE LIGHT ILLUMINATED WHENEVER WAS RAINING OR WET OUTSIDE. THE DEALER WAS NOTIFIED BUT THEY STATED THAT THERE WAS NOTHING THEY COULD DO. MAZDA WAS NOT CONTACTED WHEN THE COMPLAINT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 87,000.

I HAVE A 04 MAZDA 3 W/ AUTOMATIC TRANS / DRIVING INTO PARKING LOT HEARD A LOUD NOISE , CAR QUIT MOVING , DRIVER SIDE AXLE WAS HANGING / THE ENGINE HAD ALMOST DROP TO THE FLOOR , VEHICLE WAS TOWED TO A SHOP , THEY FOUND OUT THAT THE BRACKET WHICH HOLDS TRANSAXLE / ENGINE , ON DRIVER SIDE HAD BROKEN !! IT IS A ALUMINUM BRACKET WITH 3 BOLTS THAT CARRY ALL THE WEIGHT OF ENGINE / TRANSAXLE IT DAMAGED BOTH AXLE SHAFTS , CAUSED ABOUT $ 950.00 ON REPAIRS MY CONCERN IS THAT IT A VERY BAD / POOR / WEAK / DESIGN / THE GOOD THING IT HAPPENED AT LOW SPEED , IF IT WOULD HAVE BROKEN AT FREEWAY SPEED IT WOULD HAVE CAUSED A MAJOR DAMAGE / ACCIDENT !! *TR

I AM VERY CONCERNED ABOUT THE SAFETY OF THE CAR THAT I HAVE HAD SINCE 2004 MAZDA 3. ON SUNDAY, I WAS HIT BY A CAR AT ABOUT A 20 TO 30 DEGREE ANGLE AND THE IMPACT HIT MY PASSENGER DOOR. NEITHER ONE OF US WAS GOING AT A SPEED THAT SHOULD HAVE HAD A RESULT IN THE DAMAGE THAT OCCURRED. WHEN HE HIT US AND THE CAR CAME TO REST, THE POLICE AND TOWING PEOPLE DISCOVERED THAT THE ENGINE HAD SNAPPED OFF ITS' MOUNTING. MY AIRBAGS DID NOT DEPLOY EITHER. HE TOLD ME THAT BOTH HE AND THE TOWING AGENT HAD EVER SEEN THIS HAPPEN BEFORE TO A CAR WITH AS LITTLE DAMAGE TO IT. I WENT TO THE TOW PLACE WHERE THEY WERE HOLDING MY CAR TO TAKE PICTURES AND LOOK AT THE CAR, AND BOTH OF THE PEOPLE (DIFFERENT PEOPLE THAN THE ORIGINAL TOW DRIVER) SAID THEY HAD NEVER SEEN ANYTHING LIKE THAT. THE ONE GUY SAID ONLY TWICE HAS HE SEEN THAT HAPPEN AND BOTH HAD MAJOR DAMAGE TO THE CAR AND THAT THEY WERE DEMOLISHED UP TO HALF OF THE CAR. HE ALSO SAID THE MOUNTING PIECE OF HARDWARE LOOKED LIKE IT WAS MADE OF DIECAST NOT METAL OR ALUMINUM, WHEN WE INSPECTED IT WE NOTICED THE PART THAT WAS SNAPPED AND I MUST ADMIT IT LOOKED LIKE PLASTIC. I HAD TO HAVE THE STRUTS REPLACED IN 2008, BUT YET I HAD NEVER HIT THE TIRES HARD ON ANYTHING. MY QUESTION IS THIS SOMETHING THAT SHOULD BE INVESTIGATED AND COULD IT BE DANGEROUS TO OTHER DRIVERS OF THIS YEAR. I KNOW THAT THEY HAVE MADE ENGINES THAT ARE DESIGNED TO DROP IN ACCIDENT RECENTLY, BUT NOT FOR THIS YEAR AND NOT FOR THAT TYPE OF ACCIDENT. I HAVE WRITTEN TO MAZDA REQUESTING AN INVESTIGATION AND I AWAIT THEIR RESPONSE. *TR

TL*THE CONTACT OWNS A 2004 MAZDA3. SHE STATED THAT THE VEHICLE COULD BE DRIVEN AS AN AUTOMATIC OR A MANUAL. WHILE DRIVING 20 MPH IN MANUAL MODE SHE ATTEMPTED TO SHIFT GEARS, TO NO AVAIL. SHE HAD TO TAKE HER FOOT OFF OF THE GAS PEDAL IN ORDER FOR THE GEARS TO RELEASE AND AFTERWARDS THE GEARS STARTED TO SHIFT ON THEIR OWN. SHE WAS ABLE TO EXIT THE FREEWAY WHEN THE VEHICLE LOST ALL POWER, BUT CONTINUED TO ACCELERATE. SHE WAS UNABLE TO STOP THE VEHICLE OR MAKE A TURN. THE VEHICLE BEGAN MOVING FROM ONE LANE TO ANOTHER AND ACCELERATED THROUGH A RED LIGHT TO AVOID A COLLISION. THE VEHICLE STOPPED ACCELERATING WITHIN IN A FEW MINUTES. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO DIAGNOSED THE FAILURE AS THE INTAKE MANIFOLD. THE INTAKE MANIFOLD MELTED, DAMAGED THE SENSOR AND THE CATALYTIC CONVERTER. THE MECHANIC REPLACED THE CATALYTIC CONVERTER, SENSORS, AND THE GASKETS; HOWEVER, SHE HAD TO ADD OIL TO THE ENGINE BECAUSE THE ENGINE LIGHT ILLUMINATED CONSTANTLY. SHE TOOK THE VEHICLE BACK TO THE MECHANIC WHO STATED THAT THE ENGINE ALSO NEEDED TO BE REPLACED. SHE CONTACTED THE MANUFACTURER AND FILED A REPORT; HOWEVER , THE MANUFACTURER STATED THAT THEY WOULD NOT ASSIST WITH THE REPAIRS. THE ENGINE WAS NOT REPLACED. THE FAILURE MILEAGE WAS 25,000 AND THE CURRENT MILEAGE WAS 75,000.