2018 MAZDA MAZDA6 Complaints

Cracked cylinder head causing oil leak and possible coolant leak. This is a known issue with this year and model. Mazda is trying to suggest the issue is only for the turbo engine, but the non-turbo engine is also defective, per countless reports online. I have a video from the service technician from the mazda dealership, but it is too big to upload.

Was driving then car suddenly shut down and all panel lights turned on. The car would not start after an hour it started but was Perkins when driving. Mechanics were unable to diagnose the issue.

Premature caliper failure on front and rear. Ruined rotors at 40k miles, confirmed caliper failure by two service shops. Grinding/squeaking sounds intermittently been happening for since 30,000 miles

The contact owns a 2018 Mazda Mazda6. The contact stated upon taken the vehicle to the dealer for an oil change, the dealer notified the contact of a fuel leak. The dealer diagnosed the vehicle and informed the contact that the top of the fuel tank and bolts connected to the fuel pump were significantly rusted, causing the fuel leak. The dealer determined that the fuel tank and the fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that no assistance would be provided because the contact had already authorized the dealer to repair the vehicle. The failure mileage was approximately 75,000.

Bought used with 47k miles. Two weeks later, took it to my mechanic for an inspection, they found a massive oil leak on the back of the motor. Took it back to the dealership and they diagnosed it as a cracked cylinder head, for which there is a known TSB and warranty extension. Unfortunately, the warranty extension only covers a coolant leak from the cracked cylinder head, not an oil leak. Thankfully, the dealership took care of me but had they not, I was looking at a $7k+ repair on a car I had owned for 2 weeks. In the TSB, Mazda acknowledges that there were both design and manufacturing flaws for the affected model years. In acknowledging the issue, they should have issued a recall for affected vehicles, not a simple warranty extension

I am having my brake pads changed at a local mechanic and when changing the pads, the mechanic was unable to change them because the rotors and calipers were rusted and the brake pistons stuck. The previous recall only considered Mazda 6 up to 2013 but my 2018 has had the same problem.

Software error/loss of engine power. No warning of this before it happens. The car completely loses power, and stalls or stops in the middle of me driving. This has happened on the freeway and risked my life as well as my husbands, and children. This same issue has been a previous recall and fixed in 2019 for my car, and now it is happening again.

Coolant leaks at the cylinder head around the exhaust manifold causing my car to over heat. Also when my thermostat is set to the exact temperature for both sides my driver side blows cold and the passenger side blows hot

Driving in traffic and the engine temperature warning appeared on dash. Dealer has confirmed there is a large coolant leak from the cylinder head. Mazda released a technical service bulletin regarding the issue affecting Mazda6, cx-5 and cx-9, but I will have to pay for a head gasket replacement.

Cracked cylinder head near the exhaust manifold. Created a large oil leak. Oil on the exhaust is a fire hazard. After one quart of oil loss a low oil level light comes on. This is a reported problem. One version of the engine I have has a Mazda TSB and an extended warranty. TSB 01-0022/23 A local repair shop has diagnosed the problem.