2009 MAZDA MAZDA6 Complaints

I BOUGHT THIS CAR 2009 FROM MECHANIC 2 WEEKS AGO I RUN FOR 100MILES FOR TO AND FROM WORK ONLY.AFTER SUDDENLY AT LIGHT CAME SO I WENT TO CHECK NEAREST AUTO PARTS STORES WITH CODE READER FOR DIAGNOSTIC & HE SAID THERE MIGHT BE A TRANSMISSION PROBLEMS. AFTER I AM ABLT TO START ENGINE BUT CAR WON'T DRIVE IN D MODE BUT R CAN WORK WITH JERK AND HORSE POWER GO UP TO 5000 UP. SO I AM GOING TO SEE WITH HAYES MAZDA IN KALAMAZOO. THEREFORE, PLEASE TAKE A SERIOUS ACTION OR INVESTIGATION INTO THIS MATTER

THE DASH MATERIAL ABOVE THE PASSENGER AIRBAG HAS BEEN DETERIORATING AND MELTING AS IF A CHEMICAL REACTION HAS OCCURRED. THIS WINTER THE SECTION IN QUESTION HAS GENERATED SEVERAL CRACKS AND FISSURES IN THE SURFACE.

THIS VEHICLE HAD THE FRONT SUB-FRAME REPLACED BASED ON NHTSA COMPLAINT 11100333 AND THE SUBSEQUENT RECALL FROM MAZDA WITH NHTSA ID 18V-631. IT IS NOW TWO YEARS LATER AND THE REAR SUB-FRAME WAS SO ROTTED THAT IT WAS FALLING APART. MY VEHICLE WOULD NOT PASS THE STATE SAFETY INSPECTION WITHOUT IT BEING FIXED. IT WAS REPAIRED BY A NON-DEALER MECHANIC IN FEB 2020. THE MECHANIC TRIED FOR SEVERAL MONTHS TO GET A NEW REAR SUB-FRAME BUT COULD NOT BECAUSE IT IS ON MANUFACTURER BACK-ORDER. SINCE THIS IS MY ONLY VEHICLE AND I NEEDED IT TO BE FIXED ASAP, A USED SUB-FRAME HAD TO BE INSTALLED. BECAUSE THE NEW PART WAS UNAVAILABLE THIS MAKES ME THINK THAT THIS IS A WIDESPREAD PROBLEM AND THE MANUFACTURER CAN'T KEEP UP WITH THE DEMAND. I WAS TOLD BY A MAZDA DEALER THAT THE REAR SUB-FRAME IS NOT COVERED UNDER THE SAME RECALL AS THE FRONT. BOTH ITEMS WERE MANUFACTURED AT THE SAME TIME USING THE SAME INFERIOR STEEL SO I THINK THIS SHOULD ALSO BE COVERED. I DEFINITELY FEEL THAT ANOTHER MAZDA RECALL SHOULD BE ISSUED FOR THE REAR SUB-FRAME.*DT *AS

ENGINE SURGES WHEN I BRAKE, BUT NOT ALWAYS. USUALLY IT IS WHEN I'M GOING STRAIGHT AHEAD, HOWEVER, IT HAS DONE IT IN A TURN AND ONCE BACKING UP. THIS HAS HAPPENED AGAIN TODAY, AND AFTER I HAD THROTTLE BODY CLEANING DONE TWO WEEKS AGO.

TL* THE CONTACT OWNS A 2009 MAZDA 6. THE CONTACT STATED THAT THE DASHBOARD WAS MELTING, SHINY, AND STICKY TO THE TOUCH. THE REFLECTION FROM THE SUNSHINE AND APPROACHING HEADLIGHTS FROM ONCOMING TRAFFIC AT NIGHT AFFECTED THE CONTACT'S VISION TO SAFELY OPERATE THE VEHICLE. HENNESSY MAZDA (7261 JONESBORO RD, BUILDING 2, MORROW, GA 30260, (844) 237-2079) STATED THAT THE EXTENDED WARRANTY WAS EXPIRED BY SIX MONTHS AND NOTHING COULD BE DONE TO ASSIST WITH THE REPAIR COSTS. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO CALL NHTSA. THE FAILURE MILEAGE WAS 125,000.

TL* THE CONTACT'S DAUGHTER OWNS A 2009 MAZDA 6. WHILE THE VEHICLE WAS UNDERGOING A ROUTINE OIL CHANGE, THE TECHNICIAN AT WHALING CITY FORD LINCOLN MAZDA (475 BROAD ST, NEW LONDON, CT 06320, (860) 333-1841) NOTICED THAT THE REAR SUBFRAME HAD SEVERE CORROSION AND NEEDED TO BE REPLACED. THE DEALER DEEMED THE VEHICLE UNSAFE TO DRIVE. THE FRONT END SUBFRAME WAS REPLACED; HOWEVER, THE REAR SUBFRAME WAS NOT. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 18V631000 (SUSPENSION, STRUCTURE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000. *LN *JB

TL* THE CONTACT OWNS A 2009 MAZDA 6. WHILE THE CONTACT WAS PLACING AIR INTO THE FRONT DRIVER'S SIDE TIRE, HE FOUND THAT THE VALVE STEM WAS CORRODED AND FRACTURED. IN ADDITION, THE LOW TIRE PRESSURE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO DEAN PATTERSON CHEVROLET CADILLAC (101 PLEASANT VALLEY BLVD, ALTOONA, PA 16602, (814) 942-2222) WHERE IT WAS DIAGNOSED THAT THE SENSOR AND VALVE STEM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 104,000.

THERE HAVE BEEN PROBLEMS WITH OTHER MAZDA CARS THAT GOT RECALLED DUE TO A POSSIBLE FAULTY FUEL SHUT-OFF VALVE THAT COULD ALLOW GASOLINE TO ENTER THE FUEL TANK EMISSION SYSTEM. IF ENOUGH FUEL GETS INTO THE SYSTEM, IT CAN CAUSE THE ENGINE TO STALL. HOWEVER, THIS RECALL DID NOT COVER MY 2009 MAZDA 6 AND I HAD THE SAME PROBLEM. DOOR LOCK ACTUATOR HAS FAILED! THE ALARM ON MY MAZDA GOES OFF AT RANDOM PERIODS OF TIME. SOMETIMES ITS ONCE A WEEK AND SOMETIMES IS 5 TIMES A DAY OR NIGHT. I HAVE REVIEWED SEVERAL INTERNET FORUMS AND IT APPEARS THAT THERE ARE A LOT OF PEOPLE WITH THE SAME PROBLEM BUT THEY HAVE NOT CREATED A COMPLAINT ON THIS WEBSITE. THE REMEDIES THAT THEY HAVE FOUND TO HAVE THE DEALER REPLACE A DOOR ACTUATOR THAT IS FAULTY. THIS DOOR ACTUATOR LOCKS THE DOORS AND IF WHEN IT FAILS TO PROPERLY LOCK THE DOOR IT WILL INTERMITTENTLY SOUND THE ALARM. THE ALARM IS NOT SO MUCH THE CONCERN AS MUCH AS THE DOOR LOCK ACTUATOR. IT IF FAILS TO LOCK IT CREATES A SAFETY HAZARD FOR PEOPLE AS THEY ARE DRIVING DOWN THE ROAD THE DOOR COULD ACCIDENTALLY BE OPENED. CHILDREN COULD OPEN THE DOOR AND FALL OUT OF THE CAR AS IT IS FAILING. PLEASE LOOK INTO THIS ISSUE AS IT IS A SAFETY CONCERN. THIS HAS BEEN HAPPENING FOR AT LEAST THE PAST 4-5 YEARS.

THE DOOR LOCK ACTUATORS GO BAD ON THIS CAR WHICH CAUSES THE CAR TO BELIEVE ONE OF THE DOORS IS OPEN WHEN IT IS NOT. THE DOME LIGHTS ARE DRIVEN BY THE DOOR ACTUATORS SENSING THAT A DOOR IS OPEN, SO WHEN YOU ARE DRIVING, THE INTERIOR LIGHTS WILL FLASH ON AND OFF. VERY DISTRACTING, ESPECIALLY AT NIGHT. THE LIGHTS TURNING ON AND OFF ONLY HAPPENS WHEN THE CAR IS BEING DRIVEN, I HAVE NOT NOTICED IT WHEN STATIONARY. USUALLY IT OCCURS DURING TURNS AND THE LIGHTS STAY ON FOR A FEW SECONDS. THE DOOR ACTUATORS ARE A COMMON PROBLEM ON THIS CAR AND HAS MANY COMPLAINTS ABOUT THIS ISSUE ONLINE. THIS HAS BEEN GOING ON FOR SEVERAL MONTHS NOW. THE DOOR ACTUATOR BEING FAULTY ALSO CAUSES THE SECURITY ALARM TO GO OFF AND START SOUNDING THE CAR'S HORN SPORADICALLY. THE CAR WILL BE PARKED IN A DRIVEWAY WITH NOBODY AROUND THROUGH ALL HOURS OF THE DAY AND IT WILL GO OFF. ALTHOUGH NOT A SAFETY CONCERN LIKE THE PROBLEM WITH THE LIGHTS, IT IS STILL SYMPTOMATIC OF THE MALFUNCTIONING DOOR ACTUATORS.

WHILE PULLING DOWN MY STREET AFTER BACKING OUT OF MY DRIVEWAY, I HEARD A NOISE FROM THE REAR OF THE CAR THAT WAS NOT NORMAL. IT WAS MORE EVIDENT GOING OVER BUMPS. MY CAR WAS DUE FOR AN OIL CHANGE ANYWAY SO I WENT TO MY LOCAL REPAIR SHOP AND ASKED THEM TO INVESTIGATE. THE REAR CROSS MEMBER IS COMPLETELY RUSTED THROUGH CAUSING A NEARLY CATASTROPHIC FAILURE OF THE RIGHT REAR SECTION, INCLUDING A PIECE THAT RUSTED OFF AND IS FLOATING WITHIN THE SPRING. MAZDA DID ISSUE A RECALL FOR THIS VERY ISSUE, BUT IT ONLY COVERS THE FRONT CROSS MEMBER, WHICH IS ABSURD. I CALLED MAZDA TO CONFIRM THAT THE RECALL DOESN'T APPLY TO THE REAR, AND JOSE, THE REPRESENTATIVE I SPOKE TO BY PHONE ACKNOWLEDGED THAT IT DOES NOT. I AM IN A RUST BELT STATE, AND IF SALT CAN AFFECT THE FRONT CROSS MEMBER, OBVIOUSLY IT CAN AFFECT THE REAR IN THE SAME NEGATIVE FASHION. JUST BECAUSE THE REAR DOESN'T TURN THE CAR, DOESN'T MEAN IT POSES LESS OF A DANGER AS EVIDENCED BY MY VEHICLE.