2005 MAZDA RX-8 Complaints

TL*THE CONTACT OWNS A 2005 MAZDA RX-8. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH ATTEMPTING TO MAKE A TURN. THE GEAR SELECTOR WAS SHIFTED INTO FIRST GEAR AND THE CLUTCH TRAVELED TO THE FLOOR. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE FAILURE WAS CONTRIBUTED TO THE CLUTCH ASSEMBLY. THE ESTIMATED COST TO REPLACE THE CLUTCH ASSEMBLY WAS $390.00. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT WAS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 63,400. UPDATED 06/08/10. *LJ UPDATED 09/28/10

WHILE DRIVING NORTHBOUND ON I-75 IN DOWNTOWN ATLANTA IN STOP-AND-GO TRAFFIC CONDITIONS, THE CLUTCH PEDAL IN MY 2005 MAZDA RX-8 SUDDENLY MADE A CRACKING SOUND AND FELL TO THE FLOOR. THE CLUTCH REMAINED ABOUT 1" FROM THE FLOOR, ALLOWING MINIMAL DISENGAGEMENT OF THE TRANSMISSION, SUFFICIENT TO ALLOW ME TO RETURN THE CAR TO THE DEALER. THE DIAGNOSIS WAS A BROKEN CLUTCH PEDAL, RESULTING IN DAMAGE TO THE MASTER CYLINDER. THERE HAD BEEN SOME CREAKING AT THE TOP OF THE RETURN OF THE CLUTCH PEDAL OVER THE PAST 2-3 WEEKS.

MY CLUTCH PEDAL ON MY MAZDA RX 8 BROKE AT 80,000 MILES. I SEARCHED THE INTERNET AND THIS SEEMS TO BE A PROBLEM. *DT

WHILE DRIVING A 2005 MAZDA RX8 I LOST CONTROL AFTER SHIFTING FROM 5 TO 4TH GEAR. THE CLUTCH PEDAL STUCK IN AND MOVED SLIGHTLY RIGHT NEAR THE BREAK PEDAL AND WOULD NOT RELEASE. THIS SURPRISED ME WHICH CAUSED ME TO RUN OFF THE SIDE OF THE ROAD. I CALLED A TOW COMPANY TO TRANSPORT THE VEHICLE BACK TO THE TOYOTA DEALER WHERE I BOUGHT IT USED WITH 58000 MILES ON IT. THEY SAID THE CLUTCH HAD TO BE REPLACED FOR 1400 DOLLARS. AT THE TIME I DIDN'T HAVE THE MONEY SO I ASKED FOR IT TO BE TOWED BACK TO A LOCAL GARAGE. MY LOCAL GARAGE FOUND THAT THE CLUTCH PEDAL ASSEMBLE BROKE AWAY FROM THE MOUNTING PLATE. THIS IS A PART THAT YOU WOULD NOT EXPECT TO BREAK. ALL INDICATIONS POINT TO A FAULTY WELD. THE METAL RIPPED FROM THE POINT OF A SPOT WELD. THIS SPOT WELD MAY HAVE WEAKENED WHAT IS RELATIVELY THIN METAL FOR THIS USE. I HAD A LOCAL GARAGE REPLACE THE PART FOR 500 DOLLARS WITH PARTS AND LABOR. THE CAR WAS STILL UNDER THE ORIGINAL GUARANTEE BUT MAZDA REFUSED TO PAY FOR ANY OF THE COST BECAUSE IT WAS NOT REPAIRED BY MAZDA. ALL I WANTED WAS THE COST OF THE PART. I EXPLAINED TO THEM THAT I HAVE A SAFETY CONCERN IF THIS WERE TO HAPPEN TO SOMEONE AT HIGHWAY SPEEDS. *TR

1. DRIVING ON THE FREEWAY AT ABOUT 50 MPH EXITING OFF A LONG OFF RAMP. 2. CLUTCH PEDAL BROKE. PUSHED CLUTCH IN AND HEARD A LOUD "CRACK!". BARELY GOT THE CAR INTO FIRST GEAR AND INTO A PARKING LOT WHERE IT WAS DOA AND HAD TO BE TOWED. THE PEDAL WAS BENT AND NEARLY STUCK BEHIND THE BRAKE PEDAL. 3. NO REPAIR. DEALER ASKING $595 TO REPAIR. I CAN'T AFFORD IT (I AM UNEMPLOYED AND COULDN'T FIND A SINGLE JOB IN A YEAR AND A HALF). *TR

2005 MAZDA RX-8. CONSUMER STATES ROUGH RUNNING, STALLING AND FLOODING. *TGW THE CONSUMER STATED THE VEHICLE BECAME ALMOST IMPOSSIBLE TO START. HE TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THERE WAS CARBON IN THE ENGINE AND PERFORMED IT A COMPRESSION TEST. IT BARELY PASSED THE TEST. THE DEALER INFORMED THE CONSUMER THERE WERE A LOT OF DEFECTS IN MAZDA RX-8 ENGINES AND THAT HE WOULD PROBABLY NEED A NEW ENGINE IN THE FUTURE. THE DEALER REPLACED THE BATTERY AND DECARBED THE ENGINE. THE VEHICLE HAS CONTINUED TO IDLE ROUGHLY, STALL AND FLOOD SINCE THE FIRST VISIT TO THE DEALERSHIP. SIX MONTHS LATER WHEN THE CONSUMER WENT TO START THE VEHICLE TO WARM IT UP, THE ENGINE LIGHT STARTED TO BLINK AND THE ENGINE CUT OFF. THE VEHICLE WAS TOWED BACK TO THE DEALERSHIP. THEY STATED THE ENGINE NEEDED TO BE DECARBED AGAIN AND THE COILS NEEDED TO BE REPLACED. *JB

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) AROUND 30 DAYS AGO I HEARD A "POP" SOUND WHEN I DEPRESSED THE CLUTCH PEDAL OF MY 2005 MAZDA RX-8. IT FELT A LITTLE SOFTER AFTER THE "POP" SOUND. I THOUGHT SOMETHING HAD BROKEN BUT COULD NOT SEE ANYTHING AND THE CLUTCH SEEMED TO WORK OK. HOWEVER, OVER THE NEXT 30 DAYS, IT BECAME HARDER AND HARDER TO GET THE MANUAL TRANSMISSION INTO REVERSE. ON FEBRUARY 23, 2010, I BROUGHT MY 2005 MAZDA RX-8 TO CONGRESSIONAL MAZDA IN ROCKVILLE, MD TO HAVE MY CLUTCH INSPECTED. THE DEALER INFORMED ME THE CLUTCH PEDAL ASSEMBLY BRACKET WAS BROKEN AND NEEDED TO BE REPLACED. THE QUOTE WAS OVER $500 SO I SAID I WOULD BRING THE CAR BACK IN WHEN I HAD THE MONEY. HOWEVER, WHEN I DROVE AWAY I COULD NOT SHIFT OUT OF 1ST GEAR AND THE CAR WAS NOT DRIVABLE. I IMMEDIATELY DROVE BACK TO THE DEALER IN 1ST GEAR AND ASKED THEM TO ORDER THE PART AND REPLACE THE CLUTCH PEDAL ASSEMBLY BRACKET. WHEN THE CLUTCH PEDAL ASSEMBLY WAS REPLACED, THE CAR SHIFTED FINE. I HAVE THE BROKEN CLUTCH PEDAL ASSEMBLY AND I CAN SEE CLEARLY THAT THE METAL ON ONE SIDE OF THE MOUNTING BOLT HAS TORN APART MAKING IT IMPOSSIBLE TO FULLY ENGAGE THE CLUTCH. THAT MUST HAVE BEEN THE "POP" SOUND I HEARD. I HAVE 77,000 MILES ON MY RX-8. I DRIVE THE CAR TO WORK, NOT ON COMPETITIVE OR CHALLENGING TRACKS OR COURSES. I AM VERY CONCERNED THAT MAZDA USED POOR QUALITY METAL AND/OR POOR QUALITY SPOT WELDS IN CONSTRUCTING THE CLUTCH PEDAL ASSEMBLY ON THE 2005 RX-8 AND I REQUEST THAT NHTSA EVALUATE IF THERE IS A DEFECT IN MANUFACTURING QUALITY OF THAT PART. I HAVE THE OLD CLUTCH PEDAL ASSEMBLY BRACKET AND CAN SEND IT TO NHTSA FOR INSPECTION. I BELIEVE MAZDA NEEDS TO RECALL THE CARS AND REPLACE THE CLUTCH PEDAL ASSEMBLY WITH A BETTER CONSTRUCTED SYSTEM. THE REPLACEMENT CLUTCH ASSEMBLY I RECEIVED HAS THE SAME POOR QUALITY METAL AND SPOT WELDS AS THE ORIGINAL PART. MAZDA DOES NOT SEEM TO BE ADDRESSING THIS POTENTIALITY SERIOUS SAFETY PROBLEM. PLEASE LOOK INTO THIS SITUATION. [XXX] *TR

I OWN A 2005 MAZDA RX8 WITH 30K MILES. I NOTICED A SQUEAKING NOISE WHEN APPLYING MY CLUTCH PEDAL APPROX A MONTH AGO. THE OTHER EVENING WHILE I WAS ATTEMPTING TO PULL ONTO A BUSY ROAD THE CLUTCH MADE A LOUD POPPING NOISE WHEN I APPLIED THE CLUTCH AND I WAS UNABLE TO PUT IT INTO GEAR. LUCKILY I WAS ABLE TO ROLL BACK TO A SAFE PLACE AND WAIT FOR A TOW. MAZDA INFORMED ME THIS IS NOT A WARRANTY ITEM & I WILL BE RESPONSIBLE TO PAY FOR THE REPAIR. I'VE READ OTHER COMPLAINTS AND THIS IS A SAFETY ISSUE. HAD I BEEN ABLE TO PULL INTO TRAFFIC AND IT BROKE, I WOULD NOT OF BEEN ABLE TO SHIFT WHICH WOULD HAVE LEFT ME IN A VERY UNSAFE SITUATION. I'M VERY DISAPPOINTED THAT MAZDA IS NOT WILLING TO REPLACE THIS PART W/O A CHARGE. I THINK THIS SHOULD BE LOOKED INTO. *TR

TL*THE CONTACT OWNS A 2005 MAZDA RX-8. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 10-30MPH; PROCEEDING TO MAKE A TURN. THE STEERING WHEEL BEGAN TO STICK WITHOUT WARNING. THE VEHICLE STEERED IN ONE DIRECTION. THE DRIVER MANEUVERED THE STEERING WHEEL IN A FORWARD AND BACKWARD POSITION TO RELEASE IT. THE VEHICLE WAS EQUIPPED WITH AN ELECTRONIC POWER STEERING SYSTEM. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE WAS CONTRIBUTED TO THE POWER STEERING RACK. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 55,000. UPDATED 3/16/10 *CN UPDATED 05/10/10*JB

I'VE BEEN HEARING THIS SQUEAKING SOUND COMING FROM MY CLUTCH FOR THE PAST FEW MONTHS. APPROXIMATELY A MONTH AGO I WAS DRIVING HOME WHEN I FELT/HEARD A POPPING SOUND. MY CLUTCH PEDAL WAS NOW ALMOST TO THE FLOOR. I ASSUMED MY CLUTCH WAS GONE BUT THE CAR STILL DROVE HOME I WAS 1/2 MILE FROM HOME. I DROVE SLOWLY AND CAREFULLY HOME. I HAD THE CAR TOWED TO MAZDA TODAY AND THEY INFORMED ME THAT MY CLUTCH BRACKET IS BROKEN. THE ESTIMATE TO REPLACE THIS IS ROUGHLY 500$. *TR