2004 MAZDA RX-8 Complaints

CLUTCH PEDAL BRACKET BROKE WHILE SHIFTING GEARS ON FREEWAY. COULD BARELY GET CAR INTO AND OUT OF GEAR TO REMOVE CAR FROM TRAFFIC AND SAFELY IN PARKING LOT. *TR

ONLY A PARTIAL FAILURE OCCURRED, BUT HAD I NOT TAKEN PREVENTIVE MEASURES, A FULL FAILURE WOULD CERTAINLY HAVE OCCURRED. NOTICED BIZARRE SQUEAKING FROM CLUTCH PEDAL UNDER NORMAL USE. REMOVED PEDAL ASSEMBLY AND NOTICED METAL HAD TORN HALFWAY THROUGH ON BRACKET. HAD USE CONTINUED, METAL WOULD HAVE TORN COMPLETELY THROUGH, RENDERING THE CLUTCH PEDAL USELESS WITHOUT REPAIR. HAD A FULL FAILURE OCCURRED WHILE DRIVING, IT COULD HAVE CAUSED A CAR ACCIDENT, ENDANGERING LIFE AND PROPERTY. TO CORRECT THE PROBLEM, I HAD THE CLUTCH BRACKET SEAM-WELDED IN THE EXISTING PROBLEM AREA AND IN ALL POTENTIAL PROBLEM AREAS. *TR

TL*THE CONTACT OWNS A 2004 MAZDA RX-8. WHEN THE CONTACT ATTEMPTED TO STOP THE ENGINE, THE MOTOR WOULD KICK, BUT THE ENGINE WOULD NOT STOP. A MECHANIC STATED THAT THE FUEL PUMP WAS FAULTY AND MADE THE REPLACEMENT. THE REPAIR ONLY LASTED ONE WEEK. HE TOOK THE VEHICLE TO A MAZDA DEALER AND THEY STATED THAT THERE WAS A FLOODING ISSUE. THE DEALER REPAIRED THE VEHICLE FOR FREE, BUT THE FAILURE RECURRED A MONTH LATER. THE MECHANIC STATED THAT THE OUTER GRIP ON THE FLY WHEEL WAS LOOSE. THE MECHANIC REPAIRED THE VEHICLE, BUT THE ENGINE STILL WOULD NOT START. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 42,000.

2004 MAZDA RX8 IS EXPERIENCING THE SAME RECALL PROBLEM AS THE 2005-08 MAZDA RX8. *NJ THE CONSUMER STATED HIS VEHICLE FAILED EMISSIONS DUE TO AN EVAPORATOR LEAK. *JB

WHILE DRIVING MY 2004 MAZDA RX8 THE CLUTCH PEDAL SNAPPED AND WENT TO THE FLOOR AND WOULDN'T COME BACK UP. I WAS NOT ABLE TO CHANGE GEARS AND HAD TO COAST TO THE SIDE OF THE ROAD. THERE WAS NO ACCIDENT BUT IF I HAD BEEN ON THE FREEWAY AND TRAVELING AT A HIGHER RATE OF SPEED IT COULD HAVE BEEN VERY DANGEROUS. AFTER INSPECTING THE CLUTCH PEDAL I DETERMINED THAT A WELD JOINT ON THE BRACKET THAT HOLDS THE CLUTCH PEDAL COMPLETE BROKE OFF. CLEARLY THIS IS THE RESULT OF POOR DESIGN, POOR WELDS AND POOR METAL THICKNESS. MAZDA CLAIMS THIS PART IS NOT UNDER WARRANTY SO I PROCEEDED TO REMOVE THE BRACKET AND REPAIR THE WELDS MYSELF. FROM WHAT I'VE READ ON THE FORUMS THIS IS A VERY COMMON ISSUE AND I WOULD THINK IT IS ONLY A MATTER OF TIME BEFORE A SERIOUS ACCIDENT OCCURS. MAZDA WANTS OVER $500 TO MAKE THE REPAIR WHICH IS NOT ACCEPTABLE. *TR

I'VE BEEN HAVING A COUPLE OF INCIDENTS WHERE MY SAFETY HAS BEEN IN DANGER BECAUSE MY VEHICLE SUDDENLY SHUTS DOWN IN MIDDLE OF ROAD. LAST TIME HAPPENED IN A MIDDLE OF AN INTERSECTION, BUT IT HAS HAPPENED IN CURVY UPHILL ROADS AND HIGHWAYS, WHERE I HAVE BEEN EXPOSED TO ACCIDENTS BECAUSE ENGINE SHUTS DOWN. I AM MORE THAN CONCERNED BECAUSE ITS NOT JUST MY SAFETY BUT THE ONES TRAVELING WITH ME AND THE ONES THAT NOT. MAZDA HAS ACKNOWLEDGE THE PROBLEM WITH THE ENGINE OF THE 2004 RX-8, BUT IN THE DEALERSHIP THEY ALWAYS MAKE SOMETHING UP NOT TO CHECK IT UNDER WARRANTY. I NEED YOUR INTERVENTION TO DEAL WITH THIS ISSUE. I HAVE ALMOST BEEN INVOLVED IN ACCIDENTS BECAUSE OF THIS PROBLEM. I HAVE FOUND ABOUT THE RECALL IN THIS WEBSITE. I HAVE LOST MONEY, AND TIME BUT NOT WILLING TO RISK MY LIFE. I NEED TO KNOW WHAT STEPS TO TAKE ACTION, BECAUSE ALL THEY DO IS DENY THAT'S ITS WARRANTY RELATED EVEN WHEN THEY KNOW ABOUT THE RECALLS THAT RELATED TO THIS PROBLEM, ALL THEY DO IS SELL YOU SPARK PLUGS AND IGNITION COILS (WHICH THEY SAY IS THE CAUSE AND NEVER SOLVES ANYTHING BUT THEIR SALES). THIS HAS TO STOP. ITS NOT FAIR TO PAY SO MUCH FOR A 2004 CAR AND GET BACK SUCH A NIGHTMARE. I NEED TO KNOW WHAT TO KNOW IF I CAN GET A REMEDY UNDER FEDERAL LAWS OF TRANSPORTATION SAFETY. THIS IS SERIOUS. *TR

I WAS DRIVING MY 2004 MAZDA RX-8 ON THE HIGHWAY AT APPROXIMATELY 60MPH AND WENT TO SHIFT FROM 5TH GEAR INTO 4TH GEAR WHEN I FELT A "POP" AT WHICH POINT MY CLUTCH FELL TO THE FLOOR AND I NO LONGER HAD ANY ABILITY TO ACCELERATE. FORTUNATELY TRAFFIC WAS LIGHT AND I WAS ABLE TO COAST OFF ONTO THE NEXT EXIT RAMP AND PULLED TO THE SIDE OF THE ROAD. I CALLED MAZDA ROADSIDE ASSISTANCE WHO TOWED THE CAR TO MAZDA BEDFORD. I WAS TOLD THAT THE CLUTCH WAS "BLOWN" AND NEEDED TO BE COMPLETELY REPLACED. THE MAZDA FORUM IS FULL OF SIMILAR EPISODES AND I WAS ENCOURAGED TO FILE A COMPLAINT. *TR

MAZDA HAS REPLACED THE ENGINE IN MY 2004 RX8 3 TIMES IN THE LAST 700 MILES. THEY KEEP SAYING BAD ROTARY ENGINE BUT THIS IS TERRIBLE. HOW MANY MORE ENGINES WILL IT TAKE??? *TR

THE CLUTCH PEDAL BRACKET BROKE WHILE DRIVING, RENDERING ME UNABLE TO SHIFT I WAS ABLE TO SAFELY STOP THE CAR, BUT ON THE HIGHWAY OR IN HEAVY TRAFFIC THIS COULD HAVE BEEN EXTREMELY DANGEROUS. *TR

I'M VERY UPSET, I BOUGH MY CAR RX8 2004 ON JANUARY 2009 FROM A MAZDA DEALER AND MY CAR JUST DIED 3 MONTH AFTER BUYING THE CAR, THEY WON'T REPLACE MY ENGINE BECAUSE OF AND AFTERMARKET HEADERS. NOW I UNDERSTAND THAT AFTERMARKET PARTS WILL VOID THE WARRANTY OF THE CAR BUT THE FIRST MONTH I BOUGHT THE CAR WENT TO THE DEALER 5 TIMES AND I HAVE THE RECORD OF THAT, THE KNEW THE CAR WAS DAMAGE AND THEY NEVER REPLACE MY ENGINE NOW THAT I PUT MY HEADERS AND THEY SAW THEM THEY DON'T WANT TO REPLACE IT AND PRETTY MUCH I LOST 13K ON A CAR THAT LAST ME ONLY 3 MONTH AND I'M STILL PAYING THE CAR A MONTH I DON'T HAVE MONEY TO REPAIR THE CAR JUST BECAUSE THEY KNOWING THAT THIS CARS HAVE PROBLEMS AND STILL DON'T WANT TO HELP IF I DON'T HAVE CAR I PROBABLY CAN LOSE MY JOB AND TRUST ME I DON'T WANT THAT BUT I CAN EVEN BUY A NOTHER CAR BECAUSE I'M STILL PAYING THIS CAR I NEED MY CAR FIX AND I WANT SOMEONE TO TAKE ACTION ON THIS, I WILL REALLY WANT TO REPORTS THIS ISSUE TO THE LOCAL NEWS PAPERS AND LET EVERYONE KNOWS ABOUT THIS PLEASE HELP ME HERE I CAN AFFORD TO LOSE MY JOB MY WIFE DOESN'T WORK AND MY SON IS ONLY 2Y AND 5 MONTH PLEASE SOMEONE HELP ME...!!!! *TR