2014 MERCEDES-BENZ E350 Complaints

During state inspection (Pennsylvania) I was told that the rear subframe was rusted. If this part failed the vehicle could become uncontrollable and crash. They are not able to repair this since so many other vehicles have this problem. They have no idea when they could get a replacement subframe. The car is 8 years old but very low mileage (~34,000). Do to the frequent occurrence of this problem (by their report) and potential safety issues, I believe this should prompt a recall.

I want to report a structural issue with the Mercedes rear subframe rusting. Three Mercedes dealers told me that it is common but there is no recall. The mechanic told me that if this is not corrected the back wheel will fall off while you are driving. There are no warning lamps. Please help.

Rusted Rear Subframe presenting a safety hazard. Possible separation of suspension link could lead to loss of control. Brought the 2014 Mercedes Benz E350 (85000 miles) in to the local dealership today for spark plug replacement. Technician performed a visual inspection of the underside of the vehicle and found that the rear subframe had rusted completely through making the care unsafe to drive. Car has been driven in Maryland since new and never exposed to any extraordinary corrosive elements that you might find on roads in colder climates. Car is in otherwise excellent shape with no other visible rust and has never been involved in an accident. The failure of a major suspension component like this on a car in otherwise excellent condition leads me to believe that there is a defect in the manufacturing of the rear subframe component. A quick Google search shows that other Mercedes vehicles suffer from this same problem. NHTSA ID Number: 11456512 also reports the same problem on the same model car. I have not had the problem repaired yet as I am deciding on next steps. Replacement estimate is approximately $4000. If I have the work done, I will retain the old subframe for inspection by NHTSA.

The Height adjustment of electric steering column adjustment sticks in adjustment position at the top limit stop. This has been fixed twice!

The car was brought in for scheduled maintenance and they told me that my rear sub frame rusted out and had snapped. Car is only 7 years old, always garaged, basically a main part rusted out. Mercedes prides itself on durability and safety. There were no warning lights, alarms, nothing. Whenever I braked the rear end of the car would slide to the left and I had to try and adjust accordingly. Prior to bringing the car in for its maintenance I was reluctant to drive it on highways and at higher speeds. Now that I am aware of the problem, had the rear of the car given out while I was on a highway, I had the potential to roll over and possibly blown up had the gas tank been impacted. I researched the issue on Google and found many instances of others having the same issue, with the same part, luckily no one appears to have been killed as yet. As I mentioned this was never picked up during all the scheduled maintenance work, nor state inspections, all handled by this dealership. The dealership is in the process of replacing the part and all work associated with that replacement. I don't know if they kept the part or tossed it out, but will ask. No one else has seen the car or rusted part other than the dealership. I'm also sending you a copy of the letter I sent to he dealership and Mercedes-Benz Home Office.

brake line failed the hard line. lost my brakes . Mercedez Ralley Motors of Roslyn N.Y said that it was normal rust . there was no warning before the failure.

Mercedes Benz had a previous recall Campaign # 2009100001 which affected vehicles until 2012 and mine is a 2014 model E350. It has the same issue with Engine severely misfiring and jerky on the road as if it is going to STOP IN THE MIDDLE OF FREEWAY while driving and cause a SAFETY RISK for my family and others on the road. Specific component is Oil leaks from transmission wiring harness and ECM connector. The leak is from camshaft hall sensors and transmission drain plug. Mercedes Benz dealer in Pleasanton, CA has confirmed the issue after I paid $218 for diagnosis.

Severe gasoline leak smell inside and outside the vehicle. Smell is so bad as to make it impossible to stand next to the vehicle without gasping for air and watering eyes. Due to a fire hazard situation, car can not be parked inside the garage as there is a gas water heater installed in the vicinity. Fuel leak in the feed system has been a known problem in Mercedes vehicles in the past. A recall was even issued on E350, 2014 model (Recall # 15V792000). However, my vehicle was excluded from the recall on account of mfg. date not matching with the recall notice. But here we are same problem showing up in the vehicle even after so called fuel leak probe was closed. Took it to the dealer for diagnosis and repair was quoted to be $2297. That's an outrageous amount of money to repair a problem which should not have happened as part of regular wear and tear and is most certainly a fire-hazard and safety issue. My wife and kids ride in this vehicle several times a day and currently I can't let them in this car due to the fear of fire. I would kindly request you to reopen the fuel leak matter with Mercedes and look into the matter while I seek a reimbursement of the repair cost from Mercedes Corporate.

Mercedes Benz E350 2014 - Panoramic Sunroof rattling and squeaking noise/sound: This issue has been reported by many online, and it is a well known problem with E350. It starts with a little bit of squeak and metallic rattle noise here and there, and then after a year or so it is almost happening all the time as you drive the car. Dealer states that Sunroof Frame bolts have to be retorqued and loose bolts which rattle around have to be put back on. Estimated cost $712. If not a safety risk causing Pano sunroof to eventually fly off, it should definitely be a recall as many E350 owners have reported the same issue, and it is a manufacturer defect.

TL* TAKATA RECALL. THE CONTACT OWNS A 2014 MERCEDES-BENZ E350. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V010000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED MERCEDES-BENZ OF DANBURY (100 FEDERAL RD, DANBURY, CT 06810, (203) 778-6333) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.