2012 MERCEDES-BENZ E350 Complaints

The contact owns a 2012 Mercedes-Benz E-350. The contact stated that while attempting to start the vehicle, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a failed crankshaft sensor. The contact stated that the crankshaft sensor was replaced; however, the failure reoccurred. The vehicle was taken to another independent mechanic where the contact was informed that the crank shaft sensor needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to another independent mechanic, and the crankshaft sensor was replaced. The vehicle was repaired, but the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 152,000.

The contact owns a 2012 Mercedes-Benz E350. The contact stated that while driving at an undisclosed speed, there was an abnormal odor coming from the inside of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a fuel leak. The vehicle was not repaired. The contact researched and was made aware of NHTSA Campaign Number: 12V557000 (Fuel System, Gasoline); however, the VIN was not included in the recall. A dealer was contacted; however, the vehicle was not yet diagnosed by the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Brake failure due to leaking brake fluid after dealership conducted rear sub frame extended warranty coverage replacement and recent brake fluid services and after two (2) multi point inspections including video and reported “no items failed” and “no items cautioned.” Vehicle was released to me both times Vehicle was inspected and is available for further inspections. My safety was jeopardized due to brake system failure while traveling at high speed on public highway. The problem was confirmed by two (2) dealerships. “ Please see below for recommended repairs on your 2012 E350, VIN - [XXX] Inspection by a different Mercedes Benz dealership reported the following: [XXX] Concern – vehicle is leaking brake fluid from behind the drivers front wheel / tire Cause – Confirmed concern, installed vehicle on lift and found brake fluid dripping from plastic side panel under the drivers door. Brake fluid flush recently completed on vehicle by Portsmouth MB, verified bleeding valves on calipers are tight and not leakingRemoved paneling and found fluid is dripping from wheel well area. Removed left front wheel well cover, and found rear brake lines are leaking due to heavy corrosion and bubbling (see attached photo). Correction – Rear brake lines need to be replaced to repair. Due to corrosion, will require brake hoses due to rotted connections. Lines are formed, fitted and secured by technician during repair (they do not come pre-formed to vehicle). Repair Estimate – Labor ($199.88 / hr) 9 hours (includes diagnostic time), $1798.92 Parts, estimate $690 if no further connections are needed (tax included) Shop supplies, $26.95 Estimate $2520 total repair **Tech notes there is a fuel line running in an area of the brake lines that is showing bubbling in the metal, not yet leaking. Additional $375 parts and labor to replace if we replace with the brake lines. MB parts states there are only 2 of these lines remaining globally.” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)

The contact owns a 2012 Mercedes- Benz E350. The contact stated while operating the vehicle the odor of fuel was present coming from the vehicle. Upon inspection it was discovered that the fuel had leaked from the vehicle. The vehicle was taken to the local dealer who diagnosed that the fuel pump had failed and needed to be replaced. The vehicle was not yet repaired. Also, the contact indicated that the front driver seat heat element had overheated and cause melting to the seat cushion. The vehicle was taken to the local dealer who diagnosed that the front driver seat needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failures but no assistance was offered. The failure mileage was 35,000.

The failed component is a fuel pump, and it is available for inspection upon request. My safety and the safety of others was put at risk due to the following: 1) Sudden engine stalling 2) Dangerous power loss while accelerating 3) Potential fire risks; a damaged fuel pump assembley can cause fuel leaks and overheating due to insufficient fuel supply can increase the risk of explosion or fire. 4) Gas fumes from a fuel leak are highly harmful and dangerous. They are toxic to inhale causing dizziness, headaches, nausea or respitory issues.

The brake lines on my car rusted out from the brake booster all of way to the rear calipers. This is the third time it’s happened to me as I’ve owned multiple E classes. If Mercedes-Benz covers the subframe, why is the brake lines which are located right above said subframe not covered?

The rear subframe got separated from chassis. I was driving to work and had to hard brake to void a collision with another vehicle all of a sudden vehicle shifted to the left and I ended up on a curb. Further inspection vehicle`s rear subframe rotted out due to rust. Also, both rear brake lines from abs module to calipers are damaged due to corrosion. I ended up replacing both brake lines and did not think too much of it and now I see a lot of people complaining about both brake line corrosion and subframe separation or excessive rust, casing rear subframe to fail. It is a very serios safety issue and Mercedes should hold accountable for these failures. My vehicle is 2012 Mercedes E350 and only has 118k miles on odometer. I have attached pictures for the rear subframe for your review, but I did not take any pictures of the brake lines due to limited space to get my camera between the body and the rear subframe.

Brake line is thoroughly corroded, went to a repair shop, when they brought it back down, the Subframe collapsed. Mercedes has a 20 yr warranty on the subframe so they will cover that but want another $3K to fix the brake line that was obviously tied to the same mfr issue that the sub frame was in regards to rusting. Dealer won't take any responsibility for anything but the subframe.

The contact owned a 2012 Mercedes-Benz E350. The contact stated that while attempting to shift to drive(D), the gear shifter detached from the steering column. No warning light was illuminated. Neither a dealer nor an independent mechanic was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The vehicle was towed to the residence by AAA. The manufacturer was not notified of the failure. The failure mileage was 420,000.

I recently took my 2012 Mercedes-Benz E350 to an authorized Mercedes-Benz dealership after experiencing corrosion of the rear subframe. The dealership confirmed and is servicing the vehicle under an active recall notice that extended the original New Vehicle Limited Warranty from 4 years/50,000 miles to 20 years /unlimited miles. After removing the subframe for repair, they observed serious corrosion of the brake lines. There had been no warnings or symptoms to alert me to any corrosion problems with the brake line prior to this. Most likely, the issue would not have been discovered if the dealership had not removed the subframe. The dealership advised me that this issue requires immediate service due to safety concerns (potential failure) as the braking system could fail while driving the vehicle. The cost to have the work done is $5800. Beyond the dealership service center, I'm not aware if brake line has been inspected by others (engineers) in Mercedes-Benz. However, this issue appears to be frequently observed in vehicles experiencing the rear subframe corrosion issue.