2010 MERCEDES-BENZ GLK350 Complaints

After breaking hard the vehicle started to pull left and the rear felt like it had locked up. I took it immediately to my local mechanic who diagnosed a prematurely rotted out subframe. I am in the process of having MB review and quote for the repair.

I had my 2010 Mercedes GLK in for B service today (Jan. 3, 2023), and the repair team inspected the vehicle and informed me that I have a RUST HOLE approximately 1" x 2" in size located adjacent to an attachment point for the wheels in the REAR SUBFRAME. If it breaks, it could cause the vehicle to become difficult to control. Additionally, they informed me that the BRAKE LINES are also RUSTING/WEAKENING. If the brakes fail while driving it could cause loss of control of the vehicle. Since these are hidden parts that I typically can't see, I had no warning that there was anything wrong until I had it in for routine maintenance. I have the invoice for the oil change, with a notation from the repair team regarding these parts. The vehicle is available for inspection should it be necessary.

Gas leak when filling tank with fuel. Last year I had fuel pump replacement Smells like gas in my garage and I noticed leak This is not good

Premature rear subframe corrosion due to design of component, vehicle is available for inspection upon request. If control arm detaches geometry of suspension will change and divert into another lane and cause a crash, the issue was confirmed by an independent service center. The vehicle is due to be inspected by the manufacturer 12-30. No warning of issue as the majority is covered by body panel.

I am the owner of a 2010 Mercedes GLK 350 with 102,531 miles. The problem I have is the rear subframe rusted with a crack on the rear subframe making it very dangerous if the rear subframe fails while driving. This issue has become very popular with the c class Mercedes Benz.

The contact owns a 2010 Mercedes-Benz GLK350. The contact stated while driving 40 MPH and depressing the brake pedal, the rear end began to fishtail and shattered. The contact stated no warning light was illuminated. The contact was able to continue driving slowly to a nearby repair shop. The mechanic informed the contact that the rear subframe was corroded and had detached from the vehicle. The contact was able to drive to her residence. The contact took the vehicle to the local dealer, where it was diagnosed with needing the rear subframe to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 149,000.

On 10/5/22, my wife was driving her 2010 GLK 350 to work, suddenly she felt the break pedal was going deep inside easily and noticed break fluid light warning sign in dashboard. She was scared to drive and slowly drove car to Mercedes authorized technician. After diagnosis, MB technician said the issue in not just on break fluid leaks but the entire breaking system is failing due to rear subframe rust which holds the entire suspension and body. He said car is not safe to drive will cost $4K to $10k to repair. Called another dealer near by said the same as this is common issue with Mercedes due to snow the subframe rust during winter. It is ironic that even with frequent servicing with dealer they never found these rust issue early because rusting process started early on any metals. Went online to dig deeper on this issue and surprised this issue is widespread check https://mbworld.org/forums/c-class-w204/805501-rotted-rear-subframe-2.html#post8650716 Apparently Mercedes recalled all C class cars to replace subframe as they realized it is their design issue in Europe, UK and Canada. Here in USA dealers give excuses saying it due to winter snow it rust even though they did not catch such dangerous safety issue in the car. Imagine if how severe this break safety issue. Please take action on Mercedes Benz to address this safety issue US, specially it has been addressed in UK, EU, and Canada.

The cross beam-in the rear are completely rusted out as are the brake lines. I had this vehicle from brand new and there isn’t any rust except for there.This problem has happened in Canada and other countries. Mercedes’ Benz has recalled it there and not in the United States. I stope to a representative at Mercedes Benz and she said they were aware of the problem and said it would be the next recall. I’m afraid to drive this vehicle it’s unsafe

I took my MB in for service to have alternator replaced. After it was finished service did a multipoint inspection on vehicle and keep in mind I have had my car in for service before and if there had been a multi inspection wouldn't this have been seen before now? This report includes Rear sub Frame rusted & broke, rear brake lines rusted, fault code for intake manifold flap malfuntion, actuator arms broke, engine misfire on cylinders 3-5. Recommended Services is to replace transmission mounts, left engine mount, right engine mount, rear sub frame, rear brake llines, intake manifold. diagnose misfires. All of this and I was never notified of any issues before now and its only been a year since my car was in before. I was also told I didn't need an oil change and my brakes were only making noise because of wear!? And due to the issue I was also told to be very careful when I do drive! Total cost for this is $11,996.85 So I feel that MB is liable for this as there has not been any recommendation s before now. I had $2,081. worth of work done February 5th 2019 and the underbody of vehicle was inspected so why was this not caught then?

My mechanic reported that the subframe is corroded and that the vehicle is unsafe to drive. He told me that I cannot drive it at all. Apparently this is a very common problem in C class and Glk class Mercedes vehicles. I read that this problem is considered a recall issue in Germany and Canada, but not here in the US. My suv has 102,000 miles and is in good shape otherwise…. This is a very dangerous issue that Mercedes in not acknowledging as a recall.