2014 MERCEDES-BENZ SPRINTER 3500 Complaints

AFTER DRIVING FOR SEVERAL HOURS, THE CRUISE CONTROL WOULD DROP OUT & THE ABS, STABILITY CONTROL & WHEEL SPEED SENSOR LIGHTS WOULD COME ON.

ABS SAFETY FOR OUR 2015 MERCEDES SPRINTER CHASSIS [XXX]. TWO YEARS AGO WE STARTED TO HAVE PROBLEMS WITH OUR ABS BRAKING. TWO DIFFERENT DEALERS SAID THE RIGHT REAR SENSOR IS DEFECTIVE. THEY WERE CHANGED BUT PROBLEM RETURNED. WE ARE CONCERNED ABOUT OUR SAFETY NOT HAVING BRAKES THAT SHOULD WORK ACCORDING TO THE MANUFACTURE. WITH OUT ABS THE CRUISE CONTROL DOES NOT WORK EITHER. THANK YOU FOR ANY HELP. NOTE; THE MANY FRUSTRATED OWNERS DISCUSSIONS ON THE INTERNET ABOUT THIS PROBLEM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

POWER STEERING WENT OUT AND CAR CRASHED. MERCEDES BENZ WALNUT CREEK CALIFORNIA REFUSED FREE REPAIR

AT APPROXIMATELY 11,600 VEHICLE MILES THE DEF WARNING MESSAGE CAME ON STATING THAT THERE WERE ONLY 10 REMAINING STARTS LEFT ON THE VEHICLE. PREVIOUS MESSAGE PRIOR TO THIS WAS TO CHECK THE DEF SYSTEM LEVEL. DEF HAD BEEN ADDED FOR THE PREVIOUS 2500 MILES EVERY 500 MILES TO MAINTAIN A FULL TANK. SINCE I WAS IN WYOMING THERE WERE NO MERCEDES DEALERS AVAILABLE TO TROUBLESHOOT THE WARNING MESSAGES. AFTER THE LIMITING START MESSAGE I CONTACTED THE NEAREST MERCEDES DEALER IN FARMINGTON, UTAH FOR AN EMERGENCY APPOINTMENT THE FOLLOWING DAY. I DROVE APPROXIMATELY 260 MILES FROM THE TETONS IN WYOMING TO HAVE THE SYSTEM CHECKED AND REPAIRED AT MY EXPENSE. THE REPAIR REQUIRED THE REPLACEMENT OF THE DEF TANK AND ASSOCIATED COMPONENTS AT A COST OF $3,400.00. MERCEDES REFUSED TO COVER THE COST OF REPAIR DUE TO VEHICLE AGE FOR THE STATE( NC ) NOT COVERED IN EXTENDED EMISSIONS WARRANTY.

TL* THE CONTACT OWNS A FOREST RIVER SOLERA RV TRAILERED TO A 2014 MERCEDES-BENZ SPRINTER 3500. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE ENGINE STALLED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO SEVERAL UNKNOWN MERCEDES-BENZ DEALERS WHERE, THE KNOCK SENSOR WAS REPLACED. THE CONTACT ALSO STATED THAT WHENEVER ONE OF THE SPEED SENSORS ON THE WHEELS FAILED, THE GEAR SHIFTER FAILED TO OPERATE INTERMITTENTLY. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THE SUN MOTOR CARS, INC LOCATED AT 6677 CARLISLE PIKE, MECHANICSBURG, PA 17050, WHERE THE TECHNICIAN DIAGNOSED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THE WARRANTY HAD EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 1,100.

WHILE DRIVING ABOUT 30 MILES PER HOUR ON A SLIGHTLY BUMPY ROAD, THREE INDICATOR LIGHTS ON THE DASHBOARD STARTED TO SHOW PROBLEMS WITH THE ABS, ASR/BAS, AND EBD SYSTEMS. ACCORDING TO THE ONBOARD DIAGNOSTICS THE ROOT PROBLEM IS A FAULTY RIGHT REAR WHEEL SPEED SENSOR. THIS DESIGN SEEMS TO HAVE PUT THE WHEEL SPEED SENSOR IN A DANGEROUS POSITION EXPOSED TO THE ELEMENTS, WHICH CAUSES IT TO DEGRADE AND STOP WORKING AT A HIGH RATE.

VEHICLE HAS HAD TWO SPEED SENSORS REPLACED, FIRST ONE IS THE LEFT REAR AT ONLY 10,385 MILES MAY 29TH 2020. THE SECOND ONE ON THE RIGHT REAR AT 10,615 MILES JULY 8TH 2020. DEALERS ARE AWARE OF THE SPRINTERS HAVING THIS ISSUE YET THERE HAVE BEEN NO RECALLS ON THIS. AS OF THIS DATE TOTAL COST TO GET IT OPERATING SAFELY AGAIN IS $1018.93 ( PARTS AND LABOR ) WHEN THESE GO OUT THERE IS NO WARNING WHILE YOU ARE DRIVING DOWN THE ROAD WHICH YOU THEN LOSE YOUR ABS BRAKING, TRACTION CONTROL AND STABILITY CONTROL. AFTER INVESTIGATING THIS IT IS A KNOWN FACT AND HAS BEEN FOR YEARS. THIS IS A VERY SERIOUS SAFETY ISSUE AND NOT ANY TECHNICIAN CAN REPLACE THIS. ALL THIS HAPPENS WHILE IN MOTION CITY DRIVING AND HIGHWAY DRIVING.

AT HIGHWAY SPEED THE VEHICLE SUDDENLY SHIFTED DOWN AND I NOTICED 3 YELLOW WARNING LIGHTS: ABS, ESP, ASR/BAS. FORTUNATELY, I WAS ABLE TO PULL OVER. I PHONED A MERCEDES DEALER AND WAS TOLD IT SOUNDED LIKE A FAULTY WHEEL SPEED SENSOR AND THAT IT WAS OK TO DRIVE WITH CAUTION. A AUTHORIZED SPRINTER REPAIR CENTER DID DIAGNOSE THE REAR WHEEL SPEED SENSOR. $345.00 LATER THE PROBLEM IS FIXED. THE SERVICE MANAGER SAID THEY SEE A LOT OF THESE. HE SAID THAT THE REPLACEMENT SENSOR HAS A NEW PART NUMBER WHICH TELLS HIM THAT IT HAS PROBABLY BEEN IMPROVED. I HOPE SO!

ABS, TRACTION CONTROL AND STABILITY CONTROL LIGHTS CAME ON WHILE GOING DOWN THE ROAD. THIS OBVIOUSLY DISABLED ALL OF THE ABOVE FUNCTIONS. CAUSE OF FAILURE WAS VERIFIED TO BE A FAULTY LH WHEEL SPEED SENSOR BY THE REPAIR SHOP. *TR

TL* THE CONTACT OWNS A 2014 MERCEDES-BENZ SPRINTER 3500. CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE TRACTION CONTROL FAILED WITHOUT WARNING. THE CONTACT COASTED TO THE SHOULDER, TURNED THE VEHICLE OFF AND BACK ON WHICH FAILED TO REMEDY THE FAILURE. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF EASTON (4300 MORSE XING, COLUMBUS, OH 43219, (888) 530-5742) WHERE IT WAS DIAGNOSED HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE ABS SENSORS WERE REPLACED HOWEVER, THE FAILURE RECURRED MULTIPLE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT NO FURTHER ASSISTANCE WAS TAKEN. THE FAILURE MILEAGE WAS APPROXIMATELY 21,000. THE VIN WAS NOT AVAILABLE.