2015 MERCEDES-BENZ SPRINTER 3500 Complaints

VEHICLE HAS A HIGH FAILURE RATE FOR TIRE ROTATION SPEED SENSORS. THIS CONDITION IMMEDIATELY DISABLES THE ANTILOCK BRAKES, STABILITY CONTROL, TRACTION CONTROL AND CRUISE CONTROL. VEHICLE MILEAGE WAS 31000 MILES AT LOSS OF THIRD SENSOR. VEHICLE WAS IN MOTION AT HIGHWAY SPEEDS AT THE TIME OF ALL FAILURES.

TL* THE CONTACT OWNS A 2016 THOR SIESTA INSTALLED ON A 2015 MERCEDES BENZ SPRINTER 3500 CHASSIS. THE CONTACT STATED THAT UPON APPROACHING A STOP, THE CONTACT HEARD A LOUD ABNORMAL GRATING NOISE. UPON INSPECTION, THE CONTACT NOTICED THAT THE RECEIVER HITCH THAT WAS ATTACHED TO A BAR HAD FRACTURED FROM THE CHASSIS. THE TOW BAR WAS STILL ATTACHED TO THE RECEIVER HITCH HOWEVER, DUE TO THE FAILURE, THE TOW BAR WAS DRAGGING ON THE ROAD. THE SAFETY CABLE FROM THE TOW BAR WAS ALSO NO LONGER ATTACHED TO THE VEHICLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 31,842.

WHILE GOING UPHILL AT ABOUT 50 MPH ON A HIGHWAY THE VEHICLE DID A HARD DOWNSHIFT AND THREE ENGINE LIGHTS CAME ON,ESP,ABS&ASR . I STOPPED AND CHECK TIRES AND AIR PRESSURE ALL OK. AT TIMES THE ENGINE WOULD BUCK, THEN SPEED UP. TURNED OFF ENGINE THEN STARTED IT AGAIN. I WAS ABLE TO DRIVE ABOUT 50 MILES TO MERCEDES DEALER WHO DIAGNOSED AS THE REAR AXEL SPEED SENSORS FAILURE. MEDFORD MERCEDES-BENZ REPLACED BOTH REAR REAL AXEL SPEED SENSORS (VEHICLE MILEAGE 27907) COST $909.00. VEHICLE WARRANTY ON SPEED SENSOR IS 5 YR OR 100,000 MILES.

I WAS DRIVING AT 65 MILES AN HOUR ON INTERSTATE AND THE VEHICLE DECELERATED AND THEN ACCELERATED AND CONTINUED TO ACCELERATE. THE CRUISE CONTROL WAS NOT ON AT THE TIME. I TRIED TO BRAKE BUT THE VEHICLE CONTINUED TO TRY TO ACCELERATE AS I DEPRESSED THE BRAKE PETAL. THE ONLY WAY TO STOP THIS WAS TO PHYSICALLY PUT THE VEHICLE IN NEUTRAL. AFTER SITTING FOR A PERIOD OF TIME MULTIPLE ALARMS WERE DISPLAYED. I WAS ABLE TO DRIVE AGAIN ONCE THE VEHICLE WAS IN ALARM MODE AND THE ANTI LOCK BRAKING SYSTEM HAD DISABLED ITSELF. I AM AN EXPERIENCE DRIVER. I AM AFRAID THAT ANOTHER PERSON MAY HAVE PANICKED AND THE RESULT MAY HAVE BEEN MUCH DIFFERENT. THE ATTACHED IMAGES SHOWS THE ALARMS THAT WERE PRESENT AFTER THE INCIDENT, ABS ALARM, ESP ALARM, AND ANTI TRACTION LIGHT THE PROBLEM WAS ULTIMATELY FOUND TO BE A FAULTY WHEEL SPEED SENSOR ON THE DRIVER SIDE REAR TIRE. VERY DANGEROUS, I HAVE ALSO FOUND OTHER TESTIMONIALS ONLINE SINCE THIS INCIDENT

I'M EXPERIENCING WHEEL SPEED SENSOR MALFUNCTION AND FAILURE AT INTERSTATE HIGHWAY SPEED. IT'S HAPPENED APPROX 10 TIMES. ONCE WHEN ENCOUNTERING A DIP IN THE ROAD. ONCE IN HEAVY CROSS WINDS. AND LASTLY WHEN PASSING AN 18 WHEELER. UPON MALFUNCTION, MY CAMPER LOOSES POWER DUE TO CRUISE CONTROL DROPPING OUT. THIS PUT ME IN UNSAFE CONDITION PASSING 18 WHEELER. FIRST FAILURE WAS ON I-8 IN REMOTE COUNTRY. I MADE IT TO SAFE AREA BUT WAS VERY STRESSED. FAULT CLEARED AFTER RESTARTING MY ENGINE. NEXT EVENT WAS IN COLORADO IN AUGUST 2019. IN HEAVY CROSSWIND ON INTERSTATE SYSTEM CODED 'WHEEL SPIN, LOSS OF TRACTION.' MULTIPLE TIMES I STOPPED, KILLED ENGINE, BUT CODES DIDN'T CLEAR. UPON LEAVING CAMP IT CODED ADDITIONAL ABS FAILURE. THIS RESULTED IN BREAKDOWN. VEHICLE BECAME ERRATIC JERKING AND LURCHING. I CALLED MERCEDES AND WAS TOWED 250 MILES TO DEALER IN LITTLETON CO. RIGHT REAR WHEEL SPEED SENSOR REPLACED. LASTLY THIS HAPPEN AGAIN TWO DAYS AGO ON I-20 IN LOUISIANA. WHILE PASSING AN 18 WHEELER MY SPRINTER CODED 'WHEEL SPIN, VEHICLE SKID'.' IMMEDIATE LOSS OF CRUISE CONTROL CAUSED LOSS OF SPEED. THE LARGE TRUCK SPED BY ME IN THE INSIDE LANE BUFFETING ME BADLY! I MAINTAINED CONTROL BUT THIS WAS UNSAFE FOR MYSELF AND THE TRUCK DRIVER! UPON GETTING OFF INTERSTATE I GOT ABS CODE WITH VEHICLE STUCK IN LOW GEAR (COMPUTER GENERATED RESPONSE).MERCEDES HAS ONCE AGAIN TOWED MY SPRINTER TO DEALER FOR REPAIR. ALL SAID THESE SENSORS ARE NOT FIT FOR PURPOSE. THEIR FAILURES AT HIGHWAY SPEED PUT OPERATORS AT RISK. THIS RUINS CONSUMERS PLANS.IT PUTS US UNSAFELY ON THE SIDE OF THE ROAD WAITING ON TOW TRUCKS.

WHILE DRIVING OUR 2015 MERCEDES SPRINTER 3500 ON I-5 SOUTH FROM OAKLAND, CA TO JOSHUA TREE NATIONAL PARK ON THURSDAY, MARCH 19 SUDDENLY OUR SPEED CONTROL QUIT FUNCTIONING AND THE ABS, ESP AND TRACTION CONTROL LIGHTS ON OUR INSTRUMENT PANEL LIGHTED UP. WE IMMEDIATELY CALLED A MERCEDES BENZ SERVICE DEPARTMENT IN BAKERSFIELD, CA AND WERE TOLD THAT AS LONG AS THE VAN SEEMED TO BE DRIVING , BRAKING AND HANDLING NORMALLY WE DID NOT NEED TO BRING IT IN FOR SERVICE BUT COULD CONTINUE DRIVING. THE VAN DID SEEM TO BE RUNNING NORMALLY SO WE DROVE ON WITHOUT SPEED CONTROL. ABOUT 400 MILES LATER AS WE WERE DRIVING INTO JOSHUA TREE NATIONAL PARK THE BRAKES STARTED TO MAKE A LOUD CLICKING NOISE WHEN THE PEDAL WAS DEPRESSED COMPLETELY AND THE TRANSMISSION WOULD NO LONGER SHIFT OUT OF 2ND GEAR MAKING IT IMPOSSIBLE TO DRIVE OVER 30 MPH. WE HAD TO HAVE THE VAN TOWED 46 MILES BACK TO PALM SPRINGS, CA AND AWAIT THE MERCEDES BENZ SERVICE DEPARTMENT THERE OPENING ON MONDAY, MARCH 23. AT THE SERVICE DEPARTMENT THEY DIAGNOSED THE REAR WHEEL SPEED SENSORS HAD FAILED WITH ONLY 48,271 MILES ON THE ODOMETER. THE FOLLOWING DAY THEY REPLACED THE REAR WHEEL SPEED SENSORS AND THE VAN WAS RUNNING NORMALLY AGAIN. I HAVE RESEARCHED THE PROBLEM WITH THE WHEEL SPEED SENSORS ON MERCEDES BENZ SPRINTER VANS. IT SEEMS TO BE A COMMON PROBLEM AT LEAST FROM THE YEAR 2013-2016. IT IS UNACCEPTABLE THAT A VAN THAT MERCEDES PROMOTES FOR ITS UTILITY HAS THIS KIND OF FAILURE COMMONLY. IT IS A SIGNIFICANT SAFETY ISSUE. WE WERE DRIVING ON DRY PAVEMENT SO NOTICED NO PROBLEM WITH PERFORMANCE UNTIL THE BRAKES BEGAN TO MALFUNCTION AND THE VAN WOULD NOT SHIFT ABOVE 2ND GEAR. IF WE HAD BEEN ON WET OR SLICK ROADS THE LACK OF ANTI-LOCK BRAKES, TRACTION CONTROL AND ELECTRONIC STABILITY CONTROL WOULD HAVE MADE THE VAN DANGEROUS TO DRIVE. MERCEDES BENZ NEEDS TO DO SOMETHING TO REMEDY THIS COMMON FAILURE.

THIS IS THE SECOND TIME THE RPM SPEED SENSORS HAVE NEEDED TO BE REPLACED ON MY 2016, 3500 MERCEDES SPRINTER

THE 2015 SPRINTER VAN WAS CONVERTED TO RECREATIONAL VEHICLE (RV) BY ERWIN-HYMER GROUP NA AKA ROADTREK WHICH I PURCHASED IN 2016. IT WAS SOLD AS SEATING FOR 4 (ORIGINAL SPRINTER VAN - DRIVER AND FRONT PASSENGER SEAT AND AN ADDED ROW/2 CAPTAIN CHAIRS BEHIND THAT) IN 2019 ERWIN-HYMER NA GROUP /ROADTREK FILED BANKRUPTCY TAKING AWAY 4 OF THE 6 YEARS WARRANTY I PURCHASED (VIOLATION OF MAGNUSON-MOSS WARRANTY ACT). I REACHED OUT TO THE COURT APPOINTED RECEIVER ALVAREZ&MARSAL CANADA WHO SAID THAT NO FUNDS WERE SET ASIDE FOR CONSUMERS. ADDITIONALLY, IN 2019 I WAS NOTIFIED THAT THE SECOND ROW/ 2 ADDED CAPTAIN SEATS/SEAT BELTS COULD FAIL IN A CRASH AND NOW MY VEHICLES SECOND ROW SHOULD NOT BE OCCUPIED WHILE THE VEHICLE IS MOVING. (NOTIFIED IN JAN. 2020 NHTSA 19V450) YES THIS IS A SAFETY VIOLATION BUT ALSO A CONSUMER AND ROAD SAFETY ISSUE. THE RV INDUSTRY IS PUTTING LARGE VEHICLES ON THE ROAD AND THEIR IS NOT ENOUGH REGULATION TO INSURE HIGHWAY SAFETY.

TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ SPRINTER 2500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SURGED AND THE ANTI-SKID AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF MELBOURNE (509 E NASA BLVD, MELBOURNE, FL 32901) WHERE IT WAS DIAGNOSED THAT THE WHEEL SPEED SENSOR WAS DEFECTIVE. THE SENSOR WAS REPLACED. THE CONTACT STATED THAT ALL FOUR WHEEL SENSORS WERE REPLACED WITHIN THE LAST YEAR. THE REPAIRS WOULD LAST APPROXIMATELY FIVE MONTHS BEFORE THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED 10% OFF THE REPAIR COST. THE CONTACT STATED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 12,000. *PM CONSUMER STATES THAT VEHICLE IS UNSAFE TO DRIVE IN RAIN OR ON WET ROADS. *DL

WHILE DRIVING, THREE WARNING LIGHTS ILLUMINATED ADVISING I HAD LOST MY ABS AND MY CRUISE CONTROL FAILED. THE VEHICLE SOON WENT INTO LIMP MODE. BOTH REAR WHEEL ABS SPEED SENSORS FAILED AND WERE REPLACED BY A MERCEDES SPRINTER DEALER. I SOON DISCOVERED THIS IS A VERY COMMON FAILURE. THE VEHICLE ONLY HAD 32000 MILES ON IT WHEN THE PROBLEM OCCURRED. THE SERVICE AGENT SAID IT WAS A VERY COMMON PROBLEM ON THE SPRINTER RV VEHICLES. I FEEL MERCEDES SHOULD FIX THE PROBLEM AS IT IS AN INHERENT SAFETY PROBLEM FOR THESE VEHICLES. I WAS TRAVELING 65 MPH ON AN INTERSTATE HIGHWAY WITH CRUISE CONTROL ENGAGED WHEN THE PROBLEM OCCURRED. THIS COULD HAVE BEEN A SAFETY ISSUE HAD I NEEDED THE BRAKES AT THAT MOMENT.