2015 MERCEDES-BENZ SPRINTER 3500 Complaints

The contact owns a 2015 Mercedes-Benz Sprinter 3500. The contact stated while driving approximately 35 mph, the transmission inadvertently downshifted into third gear and the vehicle stalled with an unknown warning light illuminated. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the rear wheel speed sensors were faulty and needed to be replaced. The vehicle was repaired, and the failure was remedied. The contact later received notification of NHTSA campaign number 21V042000 (Electronic Stability Control) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not contacted. Vin tool confirms parts not available. The failure mileage was 52,000.

I RECEIVED A RECALL NOTICE FOR THE THE REAR SPEED SENSORS ON THIS VEHICLE. I HAVE HAD BOTH FRONT SPEED SENSORS FAIL AND I BELIEVE THIS SHOULD BE LOOKED INTO AS WELL AS I BELIEVE THE ABS BRAKE SYSTEM WAS EFFECTED BY MY FRONT WHEEL SPEED SENSOR FAILURES. THE FIRST SENSOR FAILED 30 DAYS AFTER WARRANTY EXPIRED WHEN THE VEHICLE HAD LESS THAN 19,000 MILES. THE SECOND SENSOR FAILED ABOUT 3 MONTHS LATER.

WHEN DRIVING THE VEHICLE WILL ACCELERATE BY ITSELF. THE BRAKES WILL PULSATE WHEN YOU TRY TO STOP AT THE ACCELERATED LEVEL YOU MUST PUT THE VEHICLE IN NEUTRAL TO STOP. THEN 3 LIGHTS APPEAR ON DASH, ABS,TIRE AND TRACTION. WHEN THE LIGHTS APPEAR THE VEHICLE RUNS FINE BUT CRUISE CONTROL WILL NOT WORK. WHEN VEHICLE IS TURNED OFF FOR THE DAY THE NEXT DAY THE LIGHTS ARE GONE FROM DASH AND THE VEHICLES RUNS PROPER FOR A SHORT PERIOD OF TIME. THIS ISSUE IS BECOMING MORE FREQUENT.

WE WERE TRAVELING ON FLAT, OPEN INTERSTATE ROADWAY IN RAINY WEATHER AT NIGHT WITH CRUISE CONTROL SET WHEN THE VEHICLE UNEXPECTEDLY ACCELERATED QUICKLY. I NOTICED THE VEHICLE FELT LIKE IT DOWNSHIFTED AND FELT LIKE IT WAS ACCELERATING HARD. I LOOKED AT SPEEDOMETER AND SPEED HAD INCREASED BY MORE THAN 5 MPH OVER WHAT CRUISE WAS SET IN A MATTER OF 4 SECONDS OR SO. I THEN APPLIED PRESSURE TO BRAKE PEDAL AT WHICH POINT THE VEHICLE FELT LIKE BRAKE SYSTEM PULSED 4 TIMES, AND CRUISE CONTROL DID NOT APPEAR TO DISENGAGE. I THEN HIT BRAKES AGAIN, AND PUSHED THE CRUISE CONTROL LEVEL TOWARD DASH AND CRUISE DISENGAGED THIS TIME. DURING OR IMMEDIATELY AFTER THIS EVENT, WARNING LIGHTS CAME ON IN DASH FOR ABS, ESP, VISIT WORKSHOP, AND OTHER WARNING LIGHTS THAT SAFETY FEATURES WERE DISABLED SUCH AS FORWARD COLLISION, BLIND SPOT INDICATORS IN MIRROR, ETC. THESE WARNING LIGHTS HAVE OCCASIONALLY WENT OFF FOR SHORT PERIODS OF TIME, BUT HAVE REMAINED ON FOR MOST OF TIME. SOMETIMES THEY WILL BE OFF WHEN STARTED, BUT COME ON AFTER TOUCHING BRAKE PEDAL. NO WARNING LIGHTS WERE ON PRIOR TO THIS EVENT.

BOTH REAR WHEEL SENSORS WENT OUT WITHIN 2 MONTHS OF EACH OTHER. ONE 6,000 MILES, THE OTHER 8,000 MILES. BOTH HIGHWAY DRIVING NO ROUGH ROAD

I WAS DRIVING ON THE FREEWAY WITH MY CRUISE CONTROL SET AT 65. THE VEHICLE ABRUPTLY STARTED ACCELERATING. FORTUNATELY I HAD LEFT MYSELF A GOOD DISTANCE FROM THE SEMI IN FRONT OF ME OR I WOULD HAVE RAMMED INTO THE BACK OF IT. THIS WAS QUITE UNNERVING AND AFTER BRAKING I RECEIVED THE FOLLOWING ERROR CODES: ABS, ESP, TRACTION CONTROL AND CRUISE CONTROL.

THIS VEHICLE HAS HAD 4 SEPARATE WHEEL SPED SENSOR FAILURES. WHEN EACH INCIDENT OCCURRED, THE VEHICLE WILL ACCELERATE ON ITS OWN AND AT THE SAME TIME THE ABS WILL NOT ALLOW FULL BRAKING PRESSURE WHILE UNDERWAY. YOU WILL HEAR THE ABS SOUND LIKE IT'S SLIDING ON A SLIPPERY SURFACE IN ANY CONDITION. AS THE VEHICLE ACCELERATES AND BRAKING PRESSURE IS GREATLY REDUCED, IT IS SOMETIMES NECESSARY TO QUICKLY SHOVE THE VEHICLE IN NEUTRAL TO KEEP FROM HITTING ANYTHING AHEAD. WHEN THESE FAILURES OCCUR IT CAN BE AT ANY SPEED OR ON ANY SURFACE. THIS VEHICLE WAS PURCHASED NEW AND NOW HAS APPROXIMATELY 45,000 MILES. OCCASIONALLY, PRIOR TO THE DASH LIGHTS INDICATING A WHEEL SPEED SENSOR FAILURE, THE VEHICLE WILL ALSO CUT ALL POWER. THIS TYPICALLY HAS HAPPENED ON HARD ACCELERATION ONTO A HIGHWAY, BEING EQUALLY DANGEROUS TO DRIVE. THE VEHICLE IS JUST GOING OUT OF WARRANTY AND I HAVE TRIED TO WORK OUT A SOLUTION WITH MERCEDES WHO HAVE NOW STATED I HAVE NO CLAIM. A FINAL FACTOR IS THAT AT ABOUT 10,000 MILES THIS VEHICLE HAD A MASSIVE SHORT THAT LITERALLY MELTED THE BATTERY DOWN. I HAVE SUGGESTED TO MERCEDES THAT THAT INCIDENT, UNDER WARRANTY, MAY HAVE DONE SEROUS HARM TO THE ENTIRE ELECTRICAL SYSTEM/COMPUTERS.

I WAS DRIVING ON AN INTERSTATE HWY AND THE ABS AND ESP WARNING MALFUNCTION OCCURED WITH A VISIT WORKSHOP MESSAGE. THE ENGINE RPM REVED UP AND THE VEHICLE SLOWED TO 40 MPH. I WAS ABLE TO GET TO A SAFE PLACE. CONSULTATION WITH A REPAIR FACILITY DETERMINED THE CAUSE TO BE THE WHEEL SPEED SENSORS ON THE REAR WHEELS. FURTHER INVESTIGATION REVEALED THIS SAME THING PREVIOUSLY OCCURED WITH THE PREVIOUS OWNER WITH 4000 MILES ON THE VEHICLE THE SPEED SENSORS WERE REPLACED AT FACTORY AUTH DEALER AT THAT TIME. THIS INCIDENT I AM DESCRIBING OCCURED AT 12000 MILES ON THE VEHICLE. I WAS 700 MILES FROM HOME AND THE NEAREST FACTORY REPAIR FACILITY'S ONLY EMERGENCY OPENING WAS 3 DAYS IN THE FUTURE. THE INDEPENDENT REPAIR FACILITY THAT DIAGNOSED THE PROBLEM WAS NOT ABLE TO PERFORM THE NECESSARY REPAIRS. I DROVE HOME IN LIMP MODE. 4 SPEED SENSORS WERE PURCHASED AT A MERCEDES DEALER FOR A COST OF $900.00 AND REPLACED BY MYSELF. PRIOR TO REPLACING THE SENSORS THE SECOND TIME THE ABS AND ESP WARNING OCCURED BRIEFLY AND CLEARED ON THEIR OWN. MUCH RESEARCH HAS SHOWN THIS IS A VERY COMMON FAILURE OF THESE VEHICLES.

IN OCTOBER OF 2018 AT 28,860 ODOMETER MILES, THE PASSENGER REAR WHEEL SPEED SENSOR FAILED WHILE DRIVING FROM ATLANTA, GA TO WEST PALM BEACH, FL. CAUSING THE EPS, ABS, ANTI_COLLISION AND CRUISE CONTROL SYSTEM TO STOP FUNCTIONING WITH WARNING MESSAGES DISPLAYED ON THE DASH. I EXPERIENCED ERRATIC SPEEDS WHILE MANUALLY DRIVING HOME. ON OCTOBER 3, 2020, AT 39,214 ODOMETER MILES, THE SAME ISSUE HAPPENED AGAIN, ONLY THIS TIME IT WAS THE FRONT PASSENGER WHEEL SPEED SENSOR THAT FAILED WITH ALL THE SAME WARNING LIGHTS AND DISABLED EPS, ABS, ANTI-COLLISION AND CRUISE CONTROL SYSTEMS BEING SHUT DOWN. IN BOTH CASES THE FAILED SENSORS WERE REPLACED UNDER THE MERCEDES-BENZ EMISSION WARRANTY. I AM VERY CONCERNED THAT THESE FAILURES ARE COMMON WITH THIS MODEL VEHICLE AND I WILL CONTINUE TO EXPERIENCE FAILURES OF THESE SENSORS AFTER THE WARRANTY EXPIRES. I HAVE REPLACED TWO OF THEM SO FAR WITH LESS THAN 40,000 MILES ON THE VEHICLE AND THERE ARE STILL TWO MORE ORIGINAL SENSORS YET TO FAIL.

THIS IS A WINNEBAGO VIEW 24G ON SPRINTER 3500 CHASSIS. WHILE HIGHWAY DRIVING, SUDDEN ABS AND ESP WARNING LIGHT WITH MESSAGE TO GO TO WORKSHOP. CRUISE CONTROL STOPS WORKING. LOSS OF POWER AND SHIFTING ABILITY IS INTERMITTENT. WAS ABLE TO DRIVE (WITHOUT CRUISE CONTROL AND WITH WARNING LIGHTS ON) FOR 100+ MILES TO SHOP. WHEN LOSS OF POWER OCCURED, I WOULD PULL OFF THE ROAD AND TURN OFF ENGINE, AND THIS WOULD TYPICALLY RESOLVE THE PROBLEM FOR AWHILE SPRINTER AUTHORIZED SERVICE CENTER REPLACED BOTH REAR WHEEL RPM SENSORS 7/3/20 ($581.09). SAME CONDITION RE-APPEARED DURING SIMILAR DRIVING CONDITION. SAME SPRINTER DEALER REPLACED RIGHT FRONT WHEEL SPEED SENSOR TO RESOLVE THE PROBLEM ON 8/18/20 ($507.48).